Scheduled Maintenance Guide 3rd Printing
Page 6
... gas tank(s) • Class A Motorhome - General Maintenance Information General Maintenance Information Special Operating Conditions If you operate your Ford/Lincoln/Mercury primarily in dusty conditions • Off-road operation Exceptions In addition, there are : • Natural Gas Vehicles...your vehicle under these conditions, it is not necessary to perform the additional maintenance. change the brake fluid • Normal vehicle axle - These exceptions are several exceptions to have any questions about your driving conditions, or for specific vehicles or special applications on ...
... gas tank(s) • Class A Motorhome - General Maintenance Information General Maintenance Information Special Operating Conditions If you operate your Ford/Lincoln/Mercury primarily in dusty conditions • Off-road operation Exceptions In addition, there are : • Natural Gas Vehicles...your vehicle under these conditions, it is not necessary to perform the additional maintenance. change the brake fluid • Normal vehicle axle - These exceptions are several exceptions to have any questions about your driving conditions, or for specific vehicles or special applications on ...
Scheduled Maintenance Guide 3rd Printing
Page 32
... and adjust bearings Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: 4x4 Vehicles Change front axle lubricant Change transfer case fluid Additional services for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped... Replace orange engine coolant, if equipped Change automatic transmission/transaxle fluid and filter Replace rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 32
... and adjust bearings Inspect and lubricate steering linkage (E and F Series, Expedition, Navigator, Excursion) Additional services for: 4x4 Vehicles Change front axle lubricant Change transfer case fluid Additional services for wear and rotate Replace engine air filter Replace fuel filter* Replace cabin air filter, if equipped... Replace orange engine coolant, if equipped Change automatic transmission/transaxle fluid and filter Replace rear axle lubricant on all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. 32
Scheduled Maintenance Guide 3rd Printing
Page 33
...years - The 3,000 mile lube change interval may be waived 33 Non-synthetic rear axle lubricants should be changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. Normal Schedule Normal Schedule Additional services for: Natural... several exceptions to be checked or changed anytime the axle has been submerged in water. Change automatic transmission fluid Normal Vehicle Axle Maintenance Rear axles containing synthetic lubricant and light duty trucks equipped with Ford-design axles are listed below: Natural Gas and Propane Vehicles Every...
...years - The 3,000 mile lube change interval may be waived 33 Non-synthetic rear axle lubricants should be changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. Normal Schedule Normal Schedule Additional services for: Natural... several exceptions to be checked or changed anytime the axle has been submerged in water. Change automatic transmission fluid Normal Vehicle Axle Maintenance Rear axles containing synthetic lubricant and light duty trucks equipped with Ford-design axles are listed below: Natural Gas and Propane Vehicles Every...
Scheduled Maintenance Guide 3rd Printing
Page 34
... WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Normal Schedule Normal Schedule if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent for complete refill ...
... WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Normal Schedule Normal Schedule if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add four ounces of additive friction modifier C8AZ-19B546-A (EST-M2C118-A) or equivalent for complete refill ...
Scheduled Maintenance Guide 3rd Printing
Page 36
...miles As required As required Off-road operation Change engine oil and replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change ...automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60,000 miles Change transfer case fluid As required Replace cabin air-filter As required Inspect and...
...miles As required As required Off-road operation Change engine oil and replace oil filter Replace fuel filter Change automatic transmission fluid Change rear axle lubricant (F-450 and F-550 only) Change transfer case fluid Replace engine air filter Replace cabin air filter Every 30,000 miles Change ...automatic transmission fluid Every 50,000 miles Change rear axle lubricant (F-450 and F-550 only) Every 60,000 miles Change transfer case fluid As required Replace cabin air-filter As required Inspect and...
Owner Guide 1st Printing
Page 174
...figure in other ways (i.e. Do not use replacement tires with a higher limit than the originals because they may be added to the front axle reserve capacity provided you are adding weight to the front of your vehicle, (potentially including weight added to the maximum trailer weight rating....the Safety Compliance Label on the inside pillar of the driver from zero to the cab), the weight added should not exceed the front axle reserve capacity (FARC). The GAWR is specific to each engine/transmission combination, any additional equipment, refer to these limitations. Remember to tow....
...figure in other ways (i.e. Do not use replacement tires with a higher limit than the originals because they may be added to the front axle reserve capacity provided you are adding weight to the front of your vehicle, (potentially including weight added to the maximum trailer weight rating....the Safety Compliance Label on the inside pillar of the driver from zero to the cab), the weight added should not exceed the front axle reserve capacity (FARC). The GAWR is specific to each engine/transmission combination, any additional equipment, refer to these limitations. Remember to tow....
Owner Guide 1st Printing
Page 175
...your safety and to maximize vehicle performance, be sure to find the maximum GCWR for trucks. 3. For your type engine and rear axle ratio. 2. Follow these limitations be removed from the maximum GCWR on your vehicle can carry/tow 1. Under no circumstance should NEVER exceed the... total axle reserve capacity. TRAILER TOWING Trailer towing with your vehicle can tow and must fall below the maximum shown under maximum trailer weight on ...
...your safety and to maximize vehicle performance, be sure to find the maximum GCWR for trucks. 3. For your type engine and rear axle ratio. 2. Follow these limitations be removed from the maximum GCWR on your vehicle can carry/tow 1. Under no circumstance should NEVER exceed the... total axle reserve capacity. TRAILER TOWING Trailer towing with your vehicle can tow and must fall below the maximum shown under maximum trailer weight on ...
Owner Guide 1st Printing
Page 194
... jack, you or someone else could be sure the parking brake is set, then block (in P (Park). Lay the tire on the ground with the axle. Turn the lug nut wrench clockwise until the tire is raised to avoid contact with the interior side facing up. 2.
... jack, you or someone else could be sure the parking brake is set, then block (in P (Park). Lay the tire on the ground with the axle. Turn the lug nut wrench clockwise until the tire is raised to avoid contact with the interior side facing up. 2.
Owner Guide 1st Printing
Page 259
..., frame and transfer case (if equipped). 259 MFD. SEE OWNER GUIDE EXT PNT: XXXXXX XXXXXX RC: XX DSO: XXXX F0000 BAR INT TR TP/PS R AXLE TR SPR T0000 X XX XXX X XX X XXXX UTC ∇FOHT-15294A10-GA Vehicle identification number The vehicle identification number is attached to a vehicle and prescribe... RGAWR: XXXXXXX/XXXXXXX THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY STANDARDS IN EFFECT ON THE DATE OF MANUFACTURE SHOWN ABOVE. IN U.S.A. BY FORD MOTOR CO.
..., frame and transfer case (if equipped). 259 MFD. SEE OWNER GUIDE EXT PNT: XXXXXX XXXXXX RC: XX DSO: XXXX F0000 BAR INT TR TP/PS R AXLE TR SPR T0000 X XX XXX X XX X XXXX UTC ∇FOHT-15294A10-GA Vehicle identification number The vehicle identification number is attached to a vehicle and prescribe... RGAWR: XXXXXXX/XXXXXXX THIS VEHICLE CONFORMS TO ALL APPLICABLE FEDERAL MOTOR VEHICLE SAFETY STANDARDS IN EFFECT ON THE DATE OF MANUFACTURE SHOWN ABOVE. IN U.S.A. BY FORD MOTOR CO.
Owner Guide 1st Printing
Page 270
... designed for automotive use or are equipped with outputs of five watts or less will not ordinarily affect your vehicle's operation.) • Ford cannot assume responsibility for specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the... equipment, passengers and luggage to stumble or stall. When operated, such systems may result from the use of the front or rear axle (GVWR or GAWR as two-way radios, telephones and theft alarms - that may cause the engine to your dealer for any adverse...
... designed for automotive use or are equipped with outputs of five watts or less will not ordinarily affect your vehicle's operation.) • Ford cannot assume responsibility for specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the... equipment, passengers and luggage to stumble or stall. When operated, such systems may result from the use of the front or rear axle (GVWR or GAWR as two-way radios, telephones and theft alarms - that may cause the engine to your dealer for any adverse...
Owner Guide 1st Printing
Page 273
... Radio) ...38 Automatic transaxle ...169 driving with ...170 fluid, adding ...218 fluid, checking ...218 fluid, refill capacities ...255 fluid, specification ...257 Auxiliary power point ...116 Axle lubricant specifications ...256 Battery ...223 acid, treating emergencies ...223 charging system warning light ..8 jumping a disabled battery ...197 maintenance-free ...223 replacement, specifications ...254 servicing ...223...
... Radio) ...38 Automatic transaxle ...169 driving with ...170 fluid, adding ...218 fluid, checking ...218 fluid, refill capacities ...255 fluid, specification ...257 Auxiliary power point ...116 Axle lubricant specifications ...256 Battery ...223 acid, treating emergencies ...223 charging system warning light ..8 jumping a disabled battery ...197 maintenance-free ...223 replacement, specifications ...254 servicing ...223...
Owner Guide 1st Printing
Page 275
... (see Fuel economy) ...235 Gauges ...14 engine coolant temperature gauge ...15 fuel gauge ...14 odometer ...15 speedometer ...15 tachometer ...14 trip odometer ...16 GAWR (Gross Axle Weight Rating) ...173 calculating ...175 definition ...173 driving with a heavy load ...173 location ...173 GVWR (Gross Vehicle Weight Rating) ...173 calculating ...173,175 definition ...173...
... (see Fuel economy) ...235 Gauges ...14 engine coolant temperature gauge ...15 fuel gauge ...14 odometer ...15 speedometer ...15 tachometer ...14 trip odometer ...16 GAWR (Gross Axle Weight Rating) ...173 calculating ...175 definition ...173 driving with a heavy load ...173 location ...173 GVWR (Gross Vehicle Weight Rating) ...173 calculating ...173,175 definition ...173...