Troy-Bilt TB625 Support Question
Troy-Bilt TB625 Support Question
Find answers below for this question about Troy-Bilt TB625.Need a Troy-Bilt TB625 manual? We have 1 online manual for this item!
Question posted by bluesbox on May 30th, 2013
Starter Rope Replacement
Can the starter rope be replaced by the owner? I own an older Troybilt trimmer. The starter rope cannot be replaced by the owner (me). It cost $75 to replace.
Current Answers
Related Troy-Bilt TB625 Manual Pages
Operation Manual - Page 1
When servicing, use only identical replacement parts.
769-08457 / 02
All information, illustrations, and specifications in Canada. Operator's Manual
Electric Start Capable 4-Cycle Trimmer
TB625 EC
TABLE OF CONTENTS Service 1 Safety 2 Know Your Unit 5 Specifications 5 Assembly ... obtain a list of printing. Service on our website: www.troybilt.com (U.S.) or www.troybilt.ca (Canada).
Operation Manual - Page 2
...: Signals a MODERATE hazard. NOTE: Advises you are approached, stop the engine and allow it requires replacement, ask your LOCAL SERVICE DEALER to the head, hands and feet.
• Carefully inspect the area...warnings and safety instructions.
Check for later use metal-reinforced line, wire, chain or rope. These can kill. Always loosen the fuel tank cap slowly to others . The ...
Operation Manual - Page 3
... by a authorized service dealer.
• Before inspecting, servicing, cleaning, storing, transporting or replacing any parts on the unit: 1. The cutting head remains stationary when the engine is dusty...daylight or good artificial light.
• Avoid accidental starting position whenever pulling the starter rope. WHILE OPERATING
• Wear safety glasses or goggles that could lead to serious...
Operation Manual - Page 4
...
WARNING: Keep all warnings and safety instructions. To prevent serious injury, do so can
cause severe eye injury and hearing loss.
You may appear on trimmer attachment
shield. SYMBOL MEANING
• ON/OFF STOP CONTROL ON / START / RUN
• ON/OFF STOP CONTROL OFF or STOP
• PRIMER BULB Push primer...
Operation Manual - Page 5
... YOUR UNIT
APPLICATIONS
As a trimmer: • Cutting grass and...Trimmer Mechanism Bump Head Trimming Line Diameter 0.095 inches (2.41 mm) Cutting Path Diameter 17 in. (43.18 cm)
* All specifications are based on the latest product information available at any time without notice.
5
Shaft Grip
ASSEMBLY TOOLS REQUIRED: • 3/8" Socket
On/Off Switch
Muffler
Spark Plug
Starter Rope...
Operation Manual - Page 7
...injury and
damage to tighten (Fig. 4). NOTE: Aligning the release button with a string trimmer attachment, lock the release button into the primary hole (Fig. 6) and the knob ... OPERATING THE COUPLER
The coupler enables the use of the coupler (Fig. 6).
90˚ Edging Hole (Trimmer Only)
Coupler
Fig. 4
Knob
Release Button
Nut Fig. 5
Primary Hole
Guide Recess
Upper Shaft Housing
Lower ...
Operation Manual - Page 10
...
3. NOTE: SQUEEZE and HOLD the throttle control for 30 to 60 seconds.
10. Pull the starter rope with a controlled and steady motion 3 to 5 times to warm up for ALL further steps.
...procedure with step 3. Move the choke lever to Position 3 and squeeze the throttle control. IF... Pull the starter rope with a controlled and steady motion 5 times (Fig. 12).
7. perform steps 3 - 8 to Position...
Operation Manual - Page 11
... ELECTRIC START ACCESSORY
This unit can be started with step 3. Refer to the Operation section of this feature.
Description
49M2027P966 Electric Starter 49MESCBP966 Engine Starter Bit 49MRBESP966 or 49MRBESY966 Cordless Electric Starter
STARTING INSTRUCTIONS
1.
Move the choke lever to idle. 2. Crouch in intervals no longer than 2 seconds each until the unit starts. Refer...
Operation Manual - Page 12
...
Fig. 15
Bump Knob
Fig. 16 This improves the unit's
cutting efficiency and throws clippings away from :
• Entanglement with a Bump Head. OPERATION
HOLDING THE TRIMMER WARNING: Always wear eye, hearing, hand, foot and body protection to reduce the risk of trimming line is equipped with foreign matter • Normal line...
Operation Manual - Page 13
... require special tools or skills.
NOTE: Always use metal-reinforced line, wire, chain or
rope.
Turn the bump knob counterclockwise to Maintaining the Air Filter.
• Change the oil.... line.
Insert the new trimming line into the entry eyelet (Fig. 17). NOTE: Maintenance, replacement, or repair of the cutting head (Fig. 18). MAINTENANCE
WARNING: To prevent serious injury, never...
Operation Manual - Page 16
... control and let the engine idle. Stop the engine and allow it with replacement part #753-05784, a Champion RDZ4H or an equivalent spark plug.
4. If the spark plug is cracked, fouled... or dirty, replace it to a qualified service dealer: • the engine will not idle, adjust the idle speed screw as ...
Operation Manual - Page 17
...an approved container. Allow the engine to clean the outside of the unit. Repair or replace damaged parts and tighten loose screws, nuts or bolts.
Long-term Storage
1. Thoroughly clean ... oils such as pine and lemon, and solvents such as kerosene, can damage plastic. Pull the starter rope slowly to Changing the Oil. Change the oil. STORAGE
• Never store a fueled unit where...
Operation Manual - Page 18
... head is dirty The line is welded The line is twisted
Not enough line is extended
Clean or replace the air filter Drain the fuel tank and add fresh fuel Adjust the idle speed
Drain the fuel ... Stop the engine and clean the cutting head Clean or replace the air filter
Drain the fuel tank and add fresh fuel Clean or replace the air filter Replace the spark plug
Stop the engine and clean the cutting ...
Operation Manual - Page 20
...troybilt.com or www.troybilt.ca, check for rental expenses to temporarily replace a warranted product. (Some states do not allow limitations on how long an implied warranty lasts, so the above as set forth below is limited to any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn... Line, Inner Reels, Starter Pulley, Starter Ropes, Drive Belts, Saw ...
Similar Questions
How Do I Replace The Primer Bulb On Tb625 Ec
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
How do I get the cover off a Troy Bilt TB625 EC Trimmer so I can replace the Primer bulb
(Posted by Myers8708 2 years ago)
How To Replace Pull Rope On Troybilt Trimmer Tb575es
(Posted by jwclevenger 3 years ago)
Tb225 Starter Rope Replacement. How To Replace The Starter Rope On A Troy-bilt T
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
how to replace the starter rope on a Troy-Bilt TB 225 garden cultivator?
(Posted by hamptona0000 6 years ago)
Fuel Tank Replacement On A Tb625 Ec
How do I replace the fuel tank on this model
How do I replace the fuel tank on this model
(Posted by axisbuck8point 8 years ago)