Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by wareagles06 on April 19th, 2020
Tb 225 Tiller Want Start
my tiller ran out of gas in about 30 minutes. Refill and wouldnt start. Replace prime button no start then i replace carburater. Same thing. Spark plug is firing but is being flooded with gas so is the air filter. What causing this
Current Answers
Answer #1: Posted by techyagent on April 19th, 2020 8:11 PM
techyagent
Member since:
June 17th, 2014 Points: 4,799,790
Member since:
June 17th, 2014 Points: 4,799,790
The carburetor might be clogged. A clogged carburetor is most commonly caused by leaving fuel in the engine for a long period of time. Over time, some of the ingredients in the fuel may evaporate, leaving behind a thicker, stickier substance. This sticky fuel can clog up the carburetor and prevent the engine from starting. If the carburetor is clogged, try cleaning it with carburetor cleaner. If cleaning the carburetor isn't effective, rebuild or replace the entire carburetor.
Please check this link below:-
Techygirl
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
... an authorized and approved service dealer. When servicing, use only identical replacement parts.
769-08657 / 00
All information, illustrations, and specifications in...Manual
2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping Instructions...
Operation Manual - Page 2
...reproductive harm. SAFETY WARNINGS FOR GAS UNITS
WARNING: Gasoline is ...from the unit immediately before starting the unit. Wipe up ... prevention of fire. If you are still at least 30 feet (9.1...spark arrestor, maintained in order to ensure the safety of the operator and any pressure in a wellventilated outdoor area.
2 All U.S. If it requires replacement...of California to cause cancer and ...
Operation Manual - Page 3
...moving parts.
• To reduce fire hazard, replace a faulty muffler and spark arrestor. SAVE THESE INSTRUCTIONS
3 Wear... described in this tool for the cause of any parts on the unit: 1.... spark plug for maintenance or repair.
• Use only original equipment manufacturer (OEM) replacement ...good artificial light.
• Avoid accidental starting the unit.
• Use the unit...
Operation Manual - Page 4
... and
follow all bystanders, especially children
and pets, at high
speed, causing injury. ROTATING TINES CAN CAUSE SEVERE INJURY
WARNING: Stop the engine and allow the tines to the ...instructions. Be in a stable position while starting position whenever pulling the starter rope. Read the operator's manual for a short time.
• GARDEN CULTIVATORS - You may appear on steep slopes...
Operation Manual - Page 5
in garden areas, around trees, etc. We reserve the right to medium soil • Cultivating in .) Spark Plug Gap 0.025 inch (0.635 mm) Spark Plug Champion® RDJ7J or equivalent plug Lubrication Fuel/...any time without notice.
5 NO ASSEMBLY TOOLS REQUIRED
KNOW YOUR UNIT
Air Filter Cover
Muffler Spark Plug
Starter Rope Grip
Choke Lever
Throttle Control
Handlebar Knobs
Upper Handle On/...
Operation Manual - Page 7
...If you use a good 2-cycle oil designed for air-cooled engines along with one 3.2 oz. (95... clean, well ventilated outdoor
area. Keep sparks and open flames at least 30 ft. (9.1 m) from the area. ...recommended that fuel containing greater than 30 days old). Do not start the engine until fuel vapors ...with a fuel additive, such as STA-BIL Gas Stabilizer or an equivalent. Use a 40:1...
Operation Manual - Page 8
... STOPPING INSTRUCTIONS
WARNING: Avoid accidental starting position (Fig. 6). STARTING INSTRUCTIONS
1.
IF... To avoid serious injury, the operator and unit must be used during this step.
SQUEEZE and HOLD the throttle control for 30-60 seconds.
10. Allow the engine to complete the warm-up . Run the unit for an additional 60 seconds to...
Operation Manual - Page 9
...ADJUSTING THE TINE DEPTH The tines should penetrate most garden soils approximately 4 to Moving the Unit. Reconnect the spark plug wire and continue use extreme
caution when reversing ...or pulling the unit towards you are digging too deep or not deep enough, adjust them according to Adjusting the Wheel Assembly in the Starting...
Operation Manual - Page 10
...Clean and re-oil the air filter.
Grasp the spark plug wire
firmly and pull the cap from the operating position. Remove the click pins from starting accidentally. Secure the new ...sure that came with the hubs facing in a horizontal position. Reconnect the spark plug wire. NOTE: Maintenance, replacement, or repair of the
convex sides are unsure about these required maintenance procedures ...
Operation Manual - Page 11
... the filter. 5.
Replace the air filter and the screen that sits behind it run for about 2-3 minutes at a time (as follows: 1. Insert the hooks on the air filter
housing into the slots on acceleration • There is a loss of a turn during engine idle. 3. NOTE: Do not over tighten as needed ) until the engine idles smoothly (Fig. 11). Start...
Operation Manual - Page 12
... a torque wrench, torque to set the air gap at 0.025 in .•lb. (12.3-13.5 N•m). WARNING: Do not sand blast, scrape or clean
electrodes. Inspect the spark plug. Tighten the spark plug with a replacement part #753-06193, Champion® RDJ7J or equivalent spark plug.
4. If the spark plug is cracked, fouled or dirty, replace it with a 5/8-inch socket, turning it...
Operation Manual - Page 13
...stored for more than 30
days. This ensures that can damage the plastic housings or handles. The unit is ready for any loose or damaged parts. Repair or replace damaged parts and ...for storage.
13 Start the engine and allow it to keep
the air vents free of obstructions. • Do not use strong detergents or petroleum based cleaners, like
kerosene. Remove the spark plug and put 5 ...
Operation Manual - Page 14
TROUBLESHOOTING
CAUSE ENGINE WILL NOT START Empty fuel tank Primer bulb wasn't pressed enough
Engine is flooded
The fuel is old (over 30 days) and/or improperly mixed Fouled spark plug
ACTION
Fill ...mixed fuel Replace or clean the spark plug
ENGINE WILL NOT IDLE Air filter is plugged The fuel is old (over 30 days) and/or improperly mixed Improper idle speed
Replace or clean the air filter Drain ...
Operation Manual - Page 16
...Service Department of original retail purchase for any product previously manufactured. Spark Plugs, Carburetor Adjustments, Filters B. During the period of the Warranty, the exclusive remedy ... alteration, vandalism, theft, fire, water or damage because of any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care services, for transportation ...
Similar Questions
What Type Of Grease Or Oil Do I Use In A Tb 225 Gear Box?
(Posted by Jwglasscock 3 years ago)
What Are The Factory Settings On A Troy Built Tb 225 Carburetor.
What are the factory settings on a troy built TB 225 carburetor.
What are the factory settings on a troy built TB 225 carburetor.
(Posted by Cb058241 3 years ago)
I Have Tb 225 Rototiller,i Have No Spark, Where Are The Points Located?
I have a TB 225 rototiller,I have no spark, where are the points located,or does it have a fuse some...
I have a TB 225 rototiller,I have no spark, where are the points located,or does it have a fuse some...
(Posted by ianjeanne6232 5 years ago)
Tb 225 Cut Off And Won't Start Since.
My TB225 mini cultivator cut off just as I was finishing preparing a small spot for planting and now...
My TB225 mini cultivator cut off just as I was finishing preparing a small spot for planting and now...
(Posted by jebontheweb1 7 years ago)
I Have A Tb-225 Four Tine Cultivator, Leaks Oil Bottom Back
It leaked last year, but was out of oil after being stored this past winter. Has had no hard use, I ...
It leaked last year, but was out of oil after being stored this past winter. Has had no hard use, I ...
(Posted by thetwozs 9 years ago)