Troy-Bilt TB225 Support Question
Troy-Bilt TB225 Support Question
Find answers below for this question about Troy-Bilt TB225.Need a Troy-Bilt TB225 manual? We have 1 online manual for this item!
Question posted by jebontheweb1 on March 8th, 2017
Tb 225 Cut Off And Won't Start Since.
My TB225 mini cultivator cut off just as I was finishing preparing a small spot for planting and now it will not start. It is getting fuel. I replaced the spark-plug and the on/off kill switch test good on my multi-meter. What are some other reasons that this unit would behave like this. This machine was manufactured in 2015 and should still be running well.
Current Answers
Answer #1: Posted by helpfultechmale on April 3rd, 2020 11:27 AM
helpfultechmale
Member since:
March 7th, 2020 Points: 0
Member since:
March 7th, 2020 Points: 0
Hi, have you tried cleaning the carburetor? Have you also tried fresh fuel there might be water in what you are currently using maybe. The jets in the carburetor can get clogged easily with the smallest amount of contaminates anything from dirty to something as small as a hair. It can also be dirty air filter as well.
Related Troy-Bilt TB225 Manual Pages
Operation Manual - Page 1
....troybilt.com (U.S.) or www.troybilt.ca (Canada). When servicing, use only identical replacement parts.
769-08657 / 00
All information, illustrations, and specifications in Canada. For...2-Cycle Gas Cultivator
TB225
TABLE OF CONTENTS Service Information 1 Rules for Safe Operation 2 Know Your Unit 5 Specifications 5 Assembly Instructions 6 Oil and Fuel Information 7 Starting and Stopping ...
Operation Manual - Page 2
... from the fueling source and site before filling the fuel tank. The safety warnings do so can kill. SPARK ARRESTOR NOTE... operating the unit.
• Inspect the unit before starting the unit. Please keep them outside a 50-foot ...finished components contain or emit chemicals known to the State of California to cause cancer and birth defects or other objects that it requires replacement...
Operation Manual - Page 3
...replacing any gum buildup. Do not run the unit at high speed when not in a stable position while starting . Disconnect the spark plug wire.
• Secure the unit while transporting. • Never store the unit with fuel in the tank, inside a building where
fumes may reach an open flame (pilot lights, etc.) or sparks (switches... vibration. These parts get extremely hot from operation...
Operation Manual - Page 4
... of oil.
• DO NOT USE E85 FUEL IN THIS UNIT
WARNING: It has been proven that may get extremely hot from rotating tines.
• NO STEP Always keep proper footing and balance. These parts get burned. Read the operator's manual for a short time.
• GARDEN CULTIVATORS - Wear eye protection meeting current ANSI Z87.1 standards...
Operation Manual - Page 5
in garden areas, around trees, etc.
We reserve the right to medium soil • Cultivating in .) Spark Plug Gap 0.025 inch (0.635 mm) Spark Plug Champion® RDJ7J or equivalent plug Lubrication Fuel/Oil Mixture Fuel/Oil Ratio 40:1 Fuel Tank Capacity 10 ounces (295 ml) Cultivating Path Width (Maximum 9 inches (22.8 cm) Cultivating Depth (Maximum 5 inches (12.7 cm) Approximate ...
Operation Manual - Page 6
...the wheel assembly along the wheel
bracket. 4. Handlebar Knobs
Fig. 2
Throttle Cable and Switch Wires
Handlebar Knobs
Fig. 3 6 Insert the clevis pin through the wheel bracket and ...Raise Fig. 1
Wheel Assembly
Wheel Bracket
POSITIONING THE HANDLEBARS
1. Readjust the throttle cable and switch wires so they are smooth
and tight against the handlebar assembly.
Set the unit on ...
Operation Manual - Page 7
... • Always use the fresh fuel mix explained in a separate fuel can. When using alcohol-blended fuel, use fresh, clean unleaded fuel.
Do not start the engine until fuel vapors dissipate.
1. NOTE: Do ...a fuel additive, such as STA-BIL Gas Stabilizer or an equivalent. Keep sparks and open flames at least 30 ft. (9.1 m) from
fuel spray. Definition of Blended Fuels
Today's fuels are...
Operation Manual - Page 8
....
10.
IF WARM... Release the throttle control. Press and hold the wheels in the primer bulb (Fig. 5). Make sure you are
in the starting .
Some amount of fuel should start , go back to Position 3 and squeeze the throttle control. SQUEEZE and HOLD the throttle control for an additional 60 seconds to hold the...
Operation Manual - Page 9
...
WARNING: Dress properly to starting the engine. Move the cultivator to the work area prior to reduce the risk of cultivation and reduce your effort.
8. CAUTION: To prevent serious personal injury, never
pick-up or carry the unit while the engine is delayed or when moving the unit from the spark plug. 2. If necessary, adjust...
Operation Manual - Page 10
... from starting accidentally. Clean and oil the shaft. 5. Secure the new tines to cool. These procedures should be a part of the
convex sides are facing as the spark arrestor, muffler, carburetor, etc. NOTE: Please read the California/EPA statement that came with click pins (Fig. 8). 7. Check the spark plug condition and gap. Lay the cultivator...
Operation Manual - Page 11
...idle. 2. If after checking the fuel mixture and cleaning the air filter the engine still will VOID the warranty. 7. If the engine stops, use a small Phillips screwdriver to turn the idle ... adjusted by unscrewing the cover screw (Fig. 9). 2. Squeeze the filter to the Starting and Stopping Instructions. Replace the air filter and the screen that sits behind it run for about 2-3 minutes ...
Operation Manual - Page 12
... with a 5/8-inch socket, turning it to cool. Use a feeler gauge to : 110-120 in . (0.635 mm) (Fig. 12).
5. Tighten the spark plug with a replacement part #753-06193, Champion® RDJ7J or equivalent spark plug.
4. Grit in . NOTE: If using a torque wrench, torque to set the air gap at 0.025 in .•lb. (12.3-13.5 N•...
Operation Manual - Page 13
...off any high quality motor oil or 2-cycle oil into an
approved container. Reinstall the fuel cap. Remove the spark plug and put 5 drops of children. Start the engine and allow it to prevent
unauthorized use or damage. • Store the ... the oil. Pull the starter rope slowly to cool. Reinstall the spark plug. Repair or replace damaged parts and tighten loose screws, nuts or bolts.
Operation Manual - Page 14
... mixed Dirty air filter
Drain the fuel tank and add fresh, properly mixed fuel Clean or replace the air filter
THE ENGINE LACKS POWER OR STALLS The fuel is old (over 30 days) and/or improperly mixed Fouled spark plug
Drain the fuel tank and add fresh, properly mixed fuel Replace or clean the spark plug
If further assistance is required...
Operation Manual - Page 16
... or write to be defective in material or workmanship. Spark Plugs, Carburetor Adjustments, Filters B. No other express warranty or... replace, free of charge, any Troy-Bilt Product without limitation, expenses incurred for substitute or replacement lawn care..., Outer Spools, Cutting Line, Inner Reels, Starter Pulley, Starter Ropes, Drive Belts, Saw Chains, Guide Bars,
Cultivator Tines, Blades. ...
Similar Questions
What Are The Factory Settings On A Troy Built Tb 225 Carburetor.
What are the factory settings on a troy built TB 225 carburetor.
What are the factory settings on a troy built TB 225 carburetor.
(Posted by Cb058241 3 years ago)
Tb 225 Tiller Want Start
my tiller ran out of gas in about 30 minutes. Refill and wouldnt start. Replace prime button no star...
my tiller ran out of gas in about 30 minutes. Refill and wouldnt start. Replace prime button no star...
(Posted by wareagles06 4 years ago)
I Have Tb 225 Rototiller,i Have No Spark, Where Are The Points Located?
I have a TB 225 rototiller,I have no spark, where are the points located,or does it have a fuse some...
I have a TB 225 rototiller,I have no spark, where are the points located,or does it have a fuse some...
(Posted by ianjeanne6232 5 years ago)
I Have A Tb-225 Four Tine Cultivator, Leaks Oil Bottom Back
It leaked last year, but was out of oil after being stored this past winter. Has had no hard use, I ...
It leaked last year, but was out of oil after being stored this past winter. Has had no hard use, I ...
(Posted by thetwozs 9 years ago)