Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by fejogonzalez on July 30th, 2012
Front Wheel Problerms
the right front wheel won't move, what's going on?
Requests for more information
Request from ShannonSezz on July 30th, 2012 6:43 PM
Is this a pull mower or automatic pull? Was it being used when the wheel locked up?
Is this a pull mower or automatic pull? Was it being used when the wheel locked up?
Current Answers
Answer #1: Posted by ShannonSezz on July 30th, 2012 6:54 PM
ShannonSezz
Member since:
July 30th, 2012 Points: 3,330
Member since:
July 30th, 2012 Points: 3,330
When using an automatic pull mower the self pulling feature can be disabled by repeatedly pulling the machine back toward the operator while the transmission is engaged. This causes the automatic feature to lock up the wheel or wheels. If the reason is not debris , than this may be the problem. It will require a major repair. To PREVENT this in the future, NEVER allow yourself to pull the mower backwards when the pull feature is engaged. Lift the front of the mower to get the front spinning wheels off the ground and keep it tilted until in the correct position and area you wish to mow.
Also wheels can lock up if the wheel has picked up a wire or some cloth debris into the spindle holding the wheel on. Look for an obstruction in that area if the mower is the push/pull type. Clear this material and the wheel should work again
Related Toro 20332 Manual Pages
Operation Manual - Page 1
Figure 2 1. 22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up Model No. 20352-Serial No. 312000001 and Up
Form No. 3371-667 Rev A
Operator's Manual
Replacement parts are responsible for operating the product properly and safely. This rotary-blade, walk-behind lawn mower is not...
Operation Manual - Page 2
... at all safety messages that follow all slopes require extra caution. Failure to potential personal injury hazards. Always be significantly lower. walk; Uneven terrain could cause a slip ... Always look down . You could be ordered through the engine manufacturer. Safety
This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind before cleaning the machine...
Operation Manual - Page 3
... Never remove gas cap or add fuel with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to operate the machine.
• Use extra care when approaching blind corners...or in handling gasoline. Children are sharp. Service
Safe Handling of Gasoline
To avoid personal injury or property damage, use extra caution when servicing them .
• Keep children...
Operation Manual - Page 7
... amount of children. Install the dipstick into the oil fill tube, then remove the dipstick.
5.
Move the mower to the fuel all season, mixing it with an API service classification of SF, SG, SH, SJ, ...an octane rating of 87 or higher) from igniting the gasoline, place the container and/or mower directly on the ground before filling, not in an approved fuel container, out of the ...
Operation Manual - Page 8
Adjust the cutting height as the rear wheels (Figure 9). To lower the mower, move the front cutting height levers rearward and the rear...54 mm); 2-1/2 inches (64 mm); 2-7/8 inches (73 mm); 3-1/4 inches (83 mm); 3-5/8 inches (92 mm); Raise the mower
Figure 9 2.
Keep away from the hot muffler. Adjusting the Cutting Height
WARNING
Adjusting the cutting height may bring you into contact with ...
Operation Manual - Page 9
...).
You can result in the recycling position, move the lever to the recycling position (refer to disengage the wheel drive. WARNING
The blade is damaged, install a new Toro replacement bag. contacting the blade can also try reaching just under the personal pace handle to the metal handle and push the mower forward a couple of inches (centimeters...
Operation Manual - Page 10
... Bag
To remove the bag, reverse the steps above.
Bag-on-demand lever (in serious personal injury or death to the operator or bystanders. WARNING
The blade is attached to another. Important: ...from one position to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling the grass and leaf clippings...
Operation Manual - Page 11
... in serious personal injury.
contacting the blade can result in the bagging position, move the lever to the recycling position (refer... to stop before leaving the operating position.
Clean here
Figure 16
Side-discharging the Clippings
Use the side discharge for all moving parts to Operating the Bag-on -demand lever is sharp; If the grass bag is on the mower...
Operation Manual - Page 12
... may plug and cause the engine to slow down your mower.
- If the grass is unsatisfactory, try one or more than the rear wheels. Set the cutting height on the lawn, set the front wheels at 2-1/8-inch (54 mm) and the rear wheels at a slower pace while mowing.
- Refer to vibrate, immediately stop the engine, disconnect...
Operation Manual - Page 13
...Determine the left and right sides of fuel, ...go to www.toro.com to find the nearest dealer) or at www.shoptoro.com. Always tip the mower onto its side, with a hand pump; WARNING
Tipping the mower...mower.
• Replace the air filter;
Gasoline is flammable, explosive and can cause personal injury.
Important: Refer to remove the fuel. never siphon. Important: Before tipping the mower ...
Operation Manual - Page 14
... the oil level is at a local recycling center.
14 Dispose of the used oil out through 10 until the oil level on the dipstick, slowly pour a small amount of oil in
the crankcase. 7. Dipstick
Figure 20
4.
Warm oil flows better and carries more contaminants. 1. Move the mower to settle. 8. Pour about 3/4 of...
Operation Manual - Page 15
.... Battery 4. Battery compartment
Figure 22
2. Note: When the battery no longer holds a charge, recycle or dispose of charging: • A red light indicates that the charger is nearly fully charged....color LED display that indicates the following states of the lead-acid battery according to the mower wire harness
located below the ignition key (Figure 22).
• A green light indicates...
Operation Manual - Page 16
Fuse holder
4. Replace the fuse in serious personal injury.
Install the new blade and all mounting hardware (Figure 25).
5.... 26
Important: Position the curved ends of gasoline. Use a torque wrench to tighten the blade bolt to point toward the mower housing. 6. Replacing the Blade
Service Interval: Yearly
Important: You will need a torque wrench to Preparing for Maintenance. 2....
Operation Manual - Page 18
Recycle it according to local codes, or use it in an enclosure near an open flame.
• Allow...unfolding the handle improperly can move the
upper handle freely. 3. Important: Route the cables to cool before storing it.
1.
Preparing the Mower for Storage
WARNING
Gasoline vapors can no longer start models only). Loosen the handle knobs until you can damage the cables, causing an...
Operation Manual - Page 20
... us at 866-214-9807 (U.S. This can no other rights which has been altered or misused and requires
replacement or ...Toro Warranty Company.
*Residential purposes means use of repairs under "Lawn Mowers") or access our web site at their Toro Distributor (Dealer) ... states do not allow exclusions of purchase:
Products
22 in Recycler and 20 in Mulcher/Bagger and Attachments GTS (Guaranteed to ...
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 2
... thread forming PRH: phillips round head PTH: phillips truss head PTO: power-take-off RH: right hand ROPS: roll-over protection system
RRB: rear roller brush SFH: slotted fillister head SHH: ... TTH: torx truss head
2 For example, a wheel assembly might be identified by reference number 6, the tire by 6:1, the valve by 6:2, and the wheel by reference number 37 are indicated. Reference numbers of...
Parts Catalog - Page 3
All Rights Reserved Contents
Deck, Side Chute and Rear Door Assembly 4 Rear Bag Assembly 5 Engine and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington...
Parts Catalog - Page 7
Part Number Qty. Front Wheel and Height-of-Cut Assembly
Ref. Description
1 115-1956-03 2 Plate-HOC, Front
2 322-3
4 Screw-HH
3 3296-29
6 Nut-Lock, NI
4 105-1818
2 Bushing-Mount, ...
2 Arm-Spring
7 110-0549
2 Knob-HOC
8 105-3048
2 Washer-Flat
9 322-6
2 Screw-HH
10 40-1940
2 Washer
11 614650
2 Bolt-Shoulder
12 115-2894
2 8 Inch Wheel ASM
C2
7
3371-846A
Parts Catalog - Page 8
...-4668
2 Gear-Pinion, 12T
17 32151-61
2 Ring-Retaining
18 110-1792
2 Wheel Cover ASM
18:2 614426
1 Washer-Stepped
19 614650
2 Bolt-Shoulder
20 115-4695
2 8 Inch Wheel Gear ASM
21 115-8406
2 Anchor-Bag
22 105-9437
2 Screw-PPH
23 115...
1 Transmission
12 115-4669
1 Belt-V
13 114-7977-03 1 Bracket-Transmission
Ref. Transmission and Rear Wheel Drive Assembly
Ref. Part Number Qty.
Similar Questions
Owners Manual For Toro 190 Cc Personal Pace Lawn Mower
(Posted by nelsontim1 9 years ago)
How Much Oil Does A Toro Personal Pace Push Mower Take
(Posted by ricant 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 12 years ago)