Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by jesjosuea on March 1st, 2014
Toro Recycler Wont Start 2012
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on April 9th, 2014 6:03 PM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
Hi, there are many things that could prevent your Toro mower from starting. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
Here are some links that may be of additional help:
Related Toro 20332 Manual Pages
Operation Manual - Page 1
...below:
Important: This engine is not equipped with Canadian ICES-002.
© 2011-The Toro® Company 8111 Lyndale Avenue South Bloomington, MN 55420
Register at www.shoptoro.com.
Safety ... carefully to learn how to avoid injury and product damage.
Figure 1 1.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up ...
Operation Manual - Page 2
..., wire, toys, etc., which can result in the manual(s) before starting the engine.
• If the machine should start the engine. This cutting machine can hide obstacles.
• Do not... wearing sandals.
For models with SAE J1940. As configured to potential personal injury hazards.
Safety
This lawn mower meets or exceeds the CPSC blade safety requirements for information regarding the ...
Operation Manual - Page 3
...fuel container where there is not alert to prevent unintended starting .
• Never make any fuel-soaked debris. ... contact with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to cool before filling.
• ...regularly.
• Keep machine free of Gasoline
To avoid personal injury or property damage, use extra caution when servicing them...
Operation Manual - Page 5
... repeat steps 3 through 5 until the oil level is damaged, contact an Authorized
Service Dealer.
1. Remove the handle knobs from the mower housing (Figure 3). fill: 20 oz. (0.59 l), type: SAE 30 detergent oil with oil. Before starting the engine, fill the engine with an API service classification of oil in step 1 .
1. Move the...
Operation Manual - Page 6
...oil fill tube securely. Product Overview
3
Charging the Battery
No Parts Required
Procedure
Electric-start models only)
6 Handle
8. Fuel tank cap
11. Washout port (not shown) 13... Air filter
3. Side-discharge deflector
models only)
4. Handle knob (2)
6. Battery charger (electric-start models only Refer to Changing the Engine Oil. Important: Change the engine oil after the first ...
Operation Manual - Page 7
....
4.
Install the dipstick into the oil fill tube, then remove the dipstick.
5. Move the mower to the fuel all season, mixing it with oil and run the engine.
Wipe the dipstick clean...pour a small amount of SF, SG, SH, SJ, SL, or higher. 1.
Important: To reduce starting problems, add fuel stabilizer to a level surface. 2. Dipstick
Figure 8
3. Important: Do not overfill ...
Operation Manual - Page 8
... the moving blade, causing serious injury.
• Stop the engine and wait for all moving parts to the same height as desired. Starting the Engine
1. To lower the mower, move the front cutting height levers rearward and the rear cutting height levers forward.
Adjust the cutting height as the rear wheels (Figure...
Operation Manual - Page 9
... self-propel drive, simply walk with you leave the mower (electric-start after self-propelling, stop walking, hold up the rear deflector (Figure 14).
9
WARNING
The blade is damaged, install a new Toro replacement bag. Raise and hold your hands on -demand lever is in serious personal injury.
Figure 12
Stopping the Engine
To stop...
Operation Manual - Page 10
...personal injury. Lower the rear deflector.
contacting the blade can result in bagging position)
1. Rear deflector
Figure 14 3.
WARNING
The blade is attached to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling...rest in serious personal injury or death to either collect or recycle grass and ...
Operation Manual - Page 11
...side discharge for all moving parts to Operating the Bag-on -demand lever is in serious personal injury. Figure 17
Removing the Side Discharge Chute
To remove the side discharge chute, lift up... position, move the lever to the recycling position (refer to stop before leaving the operating position. If the grass bag is sharp; WARNING
The blade is on the mower and the bag-on -Demand Lever)....
Operation Manual - Page 12
...lower setting for the best lawn appearance. Refer to Adjusting the Cutting Height.
• When cutting grass over any object.
• If the mower strikes an object or starts to vibrate, immediately stop...
then mow again at a slower pace while mowing.
- This helps disperse the clippings over the leaves.
• If there are more than one pass over the lawn for damage.
• For best...
Operation Manual - Page 13
...it more frequently in dusty operating conditions. • Charge the battery for 24 hours (electric-start models only).
• Empty the fuel tank before repairs as directed and before performing any ... (go to www.toro.com to running out of the machine from under the mower.
• Replace the air filter; Gasoline is flammable, explosive and can cause personal injury. After performing the...
Operation Manual - Page 14
... on the dipstick, slowly pour a small amount of oil in
the crankcase. 7. Tip the mower onto its side with the air filter up to settle. 8.
Replacing the Air Filter
Service Interval...oil fill tube, then
remove the dipstick. 10. Move the mower to the operating position. 6. Note: If the oil level is at a local recycling center.
14
Figure 19
Changing the Engine Oil
Service Interval: ...
Operation Manual - Page 15
...area.
3. Note: When the battery no longer holds a charge, recycle or dispose of charging: • A red light indicates that indicates... battery according to local codes.
Replacing the Fuse
Electric-start models only
WARNING
CALIFORNIA Proposition 65 Warning Battery posts, ..., chemicals known to the State of California to the mower wire harness
located below the ignition key (Figure 22)....
Operation Manual - Page 17
... if the self-propel drive is very difficult to overtighten. Lower the mower to Adjusting the Cutting Height. 2.
Start the engine and run it for the purpose of adjustment, adjust the...Washout port
Figure 28
5.
Refer to its lowest cutting height setting.
Start the engine and run it from under the mower housing.
7. ratchet or wrench and tighten the bolt securely. This bolt...
Operation Manual - Page 18
... the engine to cool before storing it is sufficiently dry.
6. Removing the Mower from the spark plug.
7. Recycle it stops. Allow the engine to the spark plug.
18 Tighten all nuts, bolts, and screws.
10. Remove the ignition key (electric-start models only).
2.
To unfold the handle, reverse the steps above. When you...
Operation Manual - Page 20
... wear are dissatisfied with the use pending completion of repairs under "Lawn Mowers") or access our web site at more than
two pulls:
-...starting your sole remedy under warranty.
3. The Toro Total Coverage Guarantee
A 2-Year Full Warranty (45 Day Limited Warranty for Commercial Use)
The Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler...
Parts Catalog - Page 1
Original Instructions (EN)
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA.
Parts Catalog - Page 4
Part Number Qty. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 Spring-Compression
18 32104-120
2 Screw-PPH
19 121-...-1084
1 Housing ASM
1:2 94-8072
1 Decal-Danger
1:3 115-4676
1 Decal-Recycler
1:4 112-8867
1 Decal-Port, Washout
2 114-7963-01 1 Baffle-Front
5 114-7961
1 Baffle-Rear
6 115-4677
1 Chute-Recycle
7 46-8091
9 Screw-HWH
8 112-6416
1 Bracket-Cover
9 99-8445...
Similar Questions
Toro 20333 Wont Start 2012
(Posted by dongleHAPPY2 9 years ago)
Toro Lawnmower Wont Start 7.25 190cc New
(Posted by krlowes 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 11 years ago)