Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by fardsha on October 5th, 2013
Toro 7.25 190cc Won't Start
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on December 15th, 2013 11:41 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,895
Member since:
December 20th, 2011 Points: 23,253,895
Hi, there are many things that could prevent your mower from starting. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
If you need a copy of the user manual, you can download it here:
http://www.homedepot.com/catalog/pdfImages/b8/b8846e14-7457-4b62-b721-c5a01068a347.pdf
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
If you need a copy of the user manual, you can download it here:
http://www.homedepot.com/catalog/pdfImages/b8/b8846e14-7457-4b62-b721-c5a01068a347.pdf
Related Toro 20332 Manual Pages
Operation Manual - Page 1
...serious injury or death if you need service, genuine Toro parts, or additional information, contact an Authorized Service Dealer or Toro Customer Service and have similar laws.
Original Instructions (... may have the model and serial numbers of your product. Figure 2 1.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up ...
Operation Manual - Page 2
... before starting .
• Do not put hands or feet near drop-offs, ditches, or embankments. The safety alert symbol (Figure 2) is clear of slopes; The following instructions have been adapted from the ANSI/OPEI standard B71.1-2003. Slope Operation
Slopes are familiar with stated engine horsepower, the gross horsepower of lawn mower will...
Operation Manual - Page 3
... gas cap or add fuel with manufacturer's recommended parts, when necessary.
• Mower blades are sharp. WARNING
Exhaust contains carbon monoxide, an odorless, deadly poison that...
Gasoline is not alert to prevent unintended starting .
• Never make any fuel-soaked debris. Service
Safe Handling of Gasoline
To avoid personal injury or property damage, use extra caution ...
Operation Manual - Page 5
... sheet that you install the handle.
2
Filling the Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with a bottle of oil. Note: When the crankcase is empty, pour about 3/4 of... oil level is at the Full mark on the dipstick. Before starting the engine, fill the engine with oil in step 1 .
1. Move the mower to the operating position. 3. Figure 3
2.
Operation Manual - Page 6
... Full.
6. change it yearly thereafter. Cutting height lever (4)
2. Side-discharge deflector
models only)
4. Side discharge chute
3.
Blade control bar
9. Recoil start models only)
6 Battery charger (electric-start handle
7. Important: Change the engine oil after the first 5 operating hours; Product Overview
3
Charging the Battery
No Parts Required
Procedure
Electric...
Operation Manual - Page 7
...and run the engine. Figure 7 7 Important: Do not overfill the crankcase with a clean cloth.
4.
Move the mower to the fuel all season, mixing it with an API service classification of 87 or higher) from igniting the gasoline,...prevent a static charge from a major name-brand service station (Figure 7). Important: To reduce starting problems, add fuel stabilizer to a level surface. 2.
Operation Manual - Page 8
... the ignition key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it sharply (Figure 12).
Note: To raise the mower, move the front cutting height levers forward and the rear cutting height levers rearward.
1. Lower the mower
Note: The cutting height settings are 1 inch (25 mm); 1-3/8 inches (35 mm); 1-3/4 inches...
Operation Manual - Page 9
... mower (electric-start after self-propelling, stop before bagging the clippings.
Figure 13
WARNING
A worn grass bag could allow the mower to recycle the grass and leaf clippings back into the lawn..... contacting the blade can also try reaching just under the personal pace handle to the metal handle and push the mower forward a couple of inches (centimeters) forward to Operating the...
Operation Manual - Page 11
... deflector.
11 WARNING
The blade is on the mower and the bag-on -Demand Lever). contacting the blade can result in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating ...parts to Operating the Bag-on -demand lever is in serious personal injury. Stop the engine and wait for cutting very tall grass.
If the grass bag is sharp;
Operation Manual - Page 12
...blade before the cutting season begins.
• Replace the blade when necessary with a Toro replacement blade. If the grass is unsatisfactory, try one notch lower than the rear ...starts to stall.
- WARNING
Wet grass or leaves can cause the mower to plug or the engine to vibrate, immediately stop the engine, disconnect the wire from the spark plug, and examine the mower for the best lawn...
Operation Manual - Page 13
... 25 ...mower.
• Replace the air filter;
Note: Replacement parts are available from an Authorized Service Dealer (go to www.toro.com to leak.
WARNING
Tipping the mower... is flammable, explosive and can cause personal injury. Figure 18
3. Recommended Maintenance Schedule...mower onto its side, with a hand pump; never siphon.
If you must
13 Preparing for 24 hours (electric-start...
Operation Manual - Page 14
... 10 until the oil level on the dipstick. Tip the mower onto its side with oil and run the engine.
Insert the...Read the oil level on the dipstick reads Full. 11. Return the mower to warm it. Pour about 3/4 of the crankcase capacity of oil ... and repeat steps 8 through the oil fill tube (Figure 21).
Move the mower to open the air filter cover
(Figure 19). 2. Use a screw driver...
Operation Manual - Page 15
...holds a charge, recycle or dispose of charging: • A red light indicates that the charger is charging the
battery.
2. Charging the Battery
Service Interval: Every 25 hours
Electric-start models only
If the... LED display that indicates the following states of the lead-acid battery according to the mower wire harness
located below the ignition key (Figure 22).
• A green light ...
Operation Manual - Page 16
...replace it immediately. If the blade edge is sharp; Refer to hold the blade steady
(Figure 25). While holding the blade with the screw that you removed in the battery compartment. 5. Fuse holder...Use a block of wood, put your weight behind the
16 Replace the fuse in serious personal injury. Note: Your mower comes with the air filter up. 3. contacting the blade can result in the fuse ...
Operation Manual - Page 17
... dislodge material from under the rear deflector where the
clippings go from under the mower housing.
7.
Start the engine and run it from the mower.
9. Note: Wash out the area with the bag-on the mower housing (Figure 28). Shut off the water and disconnect the garden hose from rusting.
10.
Tighten the nut...
Operation Manual - Page 18
... plug.
9. Loosen the handle knobs until the engine stops from running out of hard starting. Removing the Mower from the spark plug.
7.
Do not store fuel without stabilizer more than 30 days,...18 Charge the battery for 24 hours (electric-start the engine, it .
1.
Connect the wire to prevent cylinder corrosion during the off-season.
8. Recycle it according to run until it in an ...
Operation Manual - Page 20
... Use)
The Toro GTS Starting Guarantee
A 3-Year Full Warranty (Not Applicable for Commercial Use)
22 in Recycler® 20 in the fuel system
-
Such routine maintenance, whether performed by a dealer or by this procedure:
1. Neither The Toro Company nor Toro Warranty Company is considered commercial use, and the commercial use of repairs under "Lawn Mowers") or access...
Parts Catalog - Page 1
Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Original Instructions (EN)
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA.
Parts Catalog - Page 4
...14 114-7960
1 Deflector-Recycle
15 114-7958
1 Knob-Recycle
Ref. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 ...Spring-Compression
18 32104-120
2 Screw-PPH
19 121-5776
1 Rear Door ASM
19:2 114-7982
1 Decal-Warning
20 115-2859
1 Spring-Torsion
21 114-7924
1 Spring-Torsion
22 112-6400
1 Port-Washout
23 112-6401
1 Coupling-Hose, Washout Port
25...
Similar Questions
Toro 190cc Personal Pace Will Not Revers
(Posted by daddbp 10 years ago)
My 1 Year Old Toro Personal Pace Lawn Mower Won't Start
(Posted by nasb 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
Toro 190cc Personal Pace Won't Start
(Posted by Soupokef 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)