Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by MarkDak on September 2nd, 2014
Toro 190cc Starts But Wont Keep Running
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on September 3rd, 2014 2:49 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
If your mower starts but won't stay running, it's likely either a problem in the fuel tank/fuel line or carburetor. Try flushing the gas tank and carburetor, giving the carburetor a good cleaning to make sure no holes are clogged, and checking the fuel hose for burrs or blockages. Then fill the gas tank with new, fresh gas and give the mower a try.
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual, if you need it:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
This is a link to a list of common maintenance parts for this model, including the carb rebuild kit:
- Toro 20332 Common Maintenance Parts List
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Here is a link to the mower's manual, if you need it:
- Toro 20332 22" Recycler Lawn Mower owner's manual (PDF)
This is a link to a list of common maintenance parts for this model, including the carb rebuild kit:
- Toro 20332 Common Maintenance Parts List
Related Toro 20332 Manual Pages
Operation Manual - Page 1
...covered land. This rotary-blade, walk-behind lawn mower is not designed for cutting brush or for agricultural uses.
Serial No.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No... injury or death if you need service, genuine Toro parts, or additional information, contact an Authorized Service Dealer or Toro Customer Service and have similar laws. Model and ...
Operation Manual - Page 2
... material toward the operator. You could be sure of your footing or balance.
2 Safety
This lawn mower meets or exceeds the CPSC blade safety requirements for walk-behind before starting the engine.
• If the machine should start the engine. The following safety instructions. Keep clear of the discharge opening at the time of...
Operation Manual - Page 3
...container, rather than the operator.
• Be alert and turn mower off if a child enters the area.
• Never allow ... Clean up . Service
Safe Handling of Gasoline
To avoid personal injury or property damage, use extra caution when servicing them... adjustments or repairs with the engine running . Children are sharp. Allow engine to prevent unintended starting .
• Never make any fuel...
Operation Manual - Page 5
... through 5 until the oil level is below the Add mark on the dipstick. Before starting the engine, fill the engine with a bottle of oil. Note: When the crankcase is damaged, contact an Authorized...come with oil in the engine, but it out (Figure 4).
Remove the handle knobs from the mower housing (Figure 3).
Setup
Important: Remove and discard the protective plastic sheet that you install the handle....
Operation Manual - Page 6
... Changing the Engine Oil. Washout port (not shown) 13. Air filter
3. Bag-on the dipstick reads Full.
6. Recoil start models only)
6 Battery charger (electric-start handle
7. Important: Do not overfill the crankcase with oil and run the engine. Figure 5
1. Handle
8.
Handle knob (2)
6. Drain the excess oil until the oil level on -demand lever...
Operation Manual - Page 7
...with an API service classification of SF, SG, SH, SJ, SL, or higher. 1. Important: To reduce starting problems, add fuel stabilizer to a level surface. 2. Note: If the oil level is cold. Important: Do...or daily
Note: Max. Wipe the dipstick clean with gasoline. Move the mower to the fuel all season, mixing it with oil and run the engine. Do not mix oil with a clean cloth.
4. Dipstick
Figure...
Operation Manual - Page 8
... wheels (Figure 9). Turn the ignition key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it sharply (Figure 12). CAUTION
If the engine has been running, the muffler will be hot and can severely burn you. To lower the mower, move the front cutting height levers rearward and the rear...
Operation Manual - Page 9
... your sides, and the mower will automatically keep pace with you want to collect grass and leaf clippings from the factory ready to recycle the grass and leaf clippings back into the lawn.
If the grass bag is on the mower and the bag-on-demand lever is in serious personal injury or death to roll...
Operation Manual - Page 10
...on-demand feature allows you move the lever rearward until the button on -demand lever (in serious personal injury or death to the operator or bystanders.
contacting the blade can result in the notches on the...to stop before you to either collect or recycle grass and leaf clippings while the grass bag is sharp; WARNING
The blade is attached to the mower. • For bagging the grass and ...
Operation Manual - Page 11
...all moving parts to Operating the Bag-on -demand lever is in serious personal injury.
Stop the engine and wait for cutting very tall grass. If the... the side discharge chute (Figure 17).
1.
WARNING
The blade is on the mower and the bag-on -Demand Lever). Installing the Side Discharge Chute
Lift up the... the recycling position (refer to stop before leaving the operating position.
Operation Manual - Page 12
...; When cutting grass over any object.
• If the mower strikes an object or starts to vibrate, immediately stop the engine, disconnect the wire from the spark plug, and examine the mower for even fertilization.
• If the finished lawn appearance is too long, the mower may need to make more than one notch lower...
Operation Manual - Page 13
...wire from an Authorized Service Dealer (go to www.toro.com to stop.
2. Always tip the mower onto its side, with a hand pump;
never siphon...start models only).
• Empty the fuel tank before repairs as directed and before performing any additional yearly maintenance
procedures. tip the mower prior to running out of the machine from under the mower.
• Replace the air filter;
Run...
Operation Manual - Page 14
...). Wait 3 minutes for Maintenance. 3. Note: If the oil level is at a local recycling center.
14 Tip the mower onto its side with a clean cloth. 9.
Install the dipstick into the oil fill tube... to warm it. Figure 19
Changing the Engine Oil
Service Interval: After the first 5 hours Yearly
Run the engine a few minutes before changing the oil to open the air filter cover
(Figure 19). ...
Operation Manual - Page 15
... Charging the Battery
Service Interval: Every 25 hours
Electric-start models only
If the battery does not charge or the engine does not run with a 40-amp plug-in type fuse.
1. ... the battery no longer holds a charge, recycle or dispose of charging: • A red light indicates that the charger is fully charged.
Connect the charger to the mower wire harness
located below the ignition key ...
Operation Manual - Page 16
...Figure 26). Examine the blade whenever you run out of wood, put your weight behind...mower onto its side with a spare fuse in step 3. 6. Important: A bolt torqued to point toward the mower housing. 6. Fuse
Figure 24
G017398
2. Note: Your mower... bolt to Preparing for Maintenance. 2. Replace the fuse in serious personal injury. If the blade is sharp;
Figure 26
Important: Position ...
Operation Manual - Page 17
... go from rusting.
10. Attach a garden hose that come out from the mower.
9.
Stop the engine.
8. Lower the mower to Adjusting the Cutting Height. 2. Move the mower onto a flat paved surface. 3. Start the engine and run it from the housing to cool before storing the mower in the area. Loosen the cable support nut (Figure 27...
Operation Manual - Page 18
Recycle it according to the spark plug.
18 Run the mower until the engine stops from the spark plug.
7. Disconnect the wire from running out of fuel.
4. Loosen the handle knobs until it in your automobile.
Connect the wire to local codes, or use it stops. Dispose of hard starting. Allow the engine to prevent cylinder...
Operation Manual - Page 20
...Mowers
Conditions and Products Covered
The Toro Company and its affiliate, Toro Warranty Company, pursuant to an agreement between them, jointly promise to Start) Starting Guarantee does not apply when the product is covered under "Lawn Mowers... purchase:
Products
22 in Recycler and 20 in doubt)
- failure to drain the fuel system prior to any Authorized Toro Service Dealer to the
following...
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 3
... and Blade Assembly 6 Front Wheel and Height-of-Cut Assembly 7 Transmission and Rear Wheel Drive Assembly 8 Handle Assembly 9 Attachments and Accessories 10
© 2011-The Toro® Company
Contact us at www.Toro.com.
8111 Lyndale Avenue South Bloomington, MN 55420
3
Printed in the USA. All Rights Reserved
Similar Questions
Owners Manual For Toro 190 Cc Personal Pace Lawn Mower
(Posted by nelsontim1 9 years ago)
How Much Oil Does A Toro Personal Pace Push Mower Take
(Posted by ricant 10 years ago)
Toro Recycler Personal Pace Lawn Mower Wont Start
(Posted by barnejon 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Blade For Model 20037 Personal Pace Lawn Mower
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
where can i buy a replacement 21 inch bladefor my 2003 Toro model 20037 personal Pace lawn mower???
(Posted by lynnegrede 12 years ago)