Toro 20332 Support Question
Toro 20332 Support Question
Find answers below for this question about Toro 20332 - Recycler 190CC Personal Pace Lawn Mower.Need a Toro 20332 manual? We have 2 online manuals for this item!
Question posted by terjeanw on October 2nd, 2013
My Brand New Toro 22 In Recycler Lawn Mower Will Not Start
The person who posted this question about this Toro product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Answer #1: Posted by freginold on December 15th, 2013 9:22 AM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
Hi, if it's a brand new mower, make sure you put the oil in correctly and added gasoline. If neither of those things is the problem, you may want to take it back to your servicer or dealer since it should still be under warranty.
If it's not under warranty, then the following tips can help you to troublehsoot the problem. There are many things that could prevent your mower from starting. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
- Toro 20332 owner's manual
If it's not under warranty, then the following tips can help you to troublehsoot the problem. There are many things that could prevent your mower from starting. If it's been stored for a while and not used, but there was gas in the tank, the gas might just be old. Try flushing out the gas tank and carburetor, then filling the tank with new gas.
Another highly likely cause of the mower not starting is a bad spark plug. Spark plugs usually only cost a few bucks, so it's not a big investment to try a new one and see if that gets your mower to start.
If neither of those solutions helps, you may want to try changing the oil and replacing the air filter. If it still won't start, the carburetor may have a blockage, or you could have a more serious problem. Post a new question with what you've tried and whether you've gotten the mower to start at all, and we'll go from there.
- Toro 20332 owner's manual
Related Toro 20332 Manual Pages
Operation Manual - Page 1
... service, genuine Toro parts, or additional information, contact an Authorized Service Dealer or Toro Customer Service and have similar laws. You may contact Toro directly at www.Toro.com. Whenever ... the State of your product properly and to avoid injury and product damage.
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up Model No. 20334-Serial No. 312000001 and Up...
Operation Manual - Page 2
...and understand the contents of this class of lawn mower will be thrown by the blade. Failure to vibrate abnormally, stop before starting the engine.
• If the machine should start the engine. Material may be sure of ...with the instructions, to operate this symbol to potential personal injury hazards.
Only use accessories approved by the engine manufacturer in severe injury.
Operation Manual - Page 3
....
If this is not possible, then refuel such equipment with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to prevent unintended starting .
• Never make any fuel-soaked debris.
Allow machine to cool before starting .
• Check grass catcher components and the discharge guard frequently and replace with a portable container...
Operation Manual - Page 4
...the original machine manufacturer.
94-8072
104-7953
1. Cutting/dismemberment hazard of hand or foot, mower blade-stay away from moving parts.
5. Manufacturer's Mark
1. Warning-read the Operator's Manual...Decals
Important: Safety and instruction decals are located near areas of hand or foot, mower blade-remove the ignition key and read the instructions before leaving the operating position; ...
Operation Manual - Page 5
...Engine with Oil
No Parts Required
Procedure
Important: Your mower does not come with oil in the engine, but it out (Figure 4). Move the mower to the operating position. 3. Figure 3
2. Note..., then remove the dipstick.
5. Read the oil level on the dipstick (Figure 4).
5
Before starting the engine, fill the engine with a clean cloth.
4.
Dipstick
Figure 4
3. Max. Install and...
Operation Manual - Page 7
...gasoline can burn you and others.
• To prevent a static charge from a major name-brand service station (Figure 7). Note: Never use or daily
Note: Max.
Dipstick
Figure 8
3....: Do not overfill the crankcase with a clean cloth.
4. Move the mower to the fuel all season, mixing it with gasoline. Do not mix oil...: To reduce starting problems, add fuel stabilizer to a level surface. 2.
Operation Manual - Page 8
... forward and the rear cutting height levers rearward.
1. Keep away from the hot muffler.
Note: When you pull the recoil start handle (Figure 12). and 4 inches (102 mm).
8
Figure 11
Lower the mower
Note: The cutting height settings are 1 inch (25 mm); 1-3/8 inches (35 mm); 1-3/4 inches (44 mm); 2-1/8 inches (54 mm); 2-1/2 inches...
Operation Manual - Page 9
...-start after self-propelling, stop the engine, release the blade control bar.
Stop the engine and wait for all moving parts to recycle the grass and leaf clippings back into the lawn. Installing the Grass Bag
1. Recycling the Clippings
Your mower comes from the lawn. Check the grass bag frequently.
WARNING
The blade is damaged, install a new Toro...
Operation Manual - Page 10
...The blade is attached to the mower. • For bagging the grass and leaf clippings, press the
button on the bag-on-demand lever and move the
• For recycling the grass and leaf clippings,...and other similar debris to be thrown in the operator's or bystander's direction and result in serious personal injury or death to another.
Grass bag pin (2)
2. Operating the Bag-on-Demand Lever
The...
Operation Manual - Page 11
...in the bagging position, move the lever to the recycling position (refer to stop before leaving the operating position.
If the grass bag is on the mower and the bag-on -Demand Lever). Stop the ...engine and wait for cutting very tall grass.
WARNING
The blade is in serious personal injury. Installing the Side Discharge ...
Operation Manual - Page 12
... to stall.
• Mow only dry grass or leaves. then mow again at a slower pace while mowing.
- Wet grass and leaves tend to make more than one pass over the lawn for damage.
• For best performance, install a new blade before the cutting season begins.
• Replace the blade when necessary with each...
Operation Manual - Page 13
...operating position. Gasoline is flammable, explosive and can cause personal injury.
Run the engine dry or remove the gasoline...and dirt from an Authorized Service Dealer (go to www.toro.com to remove the fuel. Recommended Maintenance Schedule(s)
Maintenance ...mower to change the oil or replace the blade, allow the fuel tank to your engine operator's manual for 24 hours (electric-start...
Operation Manual - Page 14
...
Run the engine a few minutes before changing the oil to the operating position. 6. Move the mower to open the air filter cover
(Figure 19). 2. Wait 3 minutes for Maintenance. 3. Wipe the... dipstick clean with oil and run the engine. Note: If the oil level is at a local recycling center.
14 Replacing the Air Filter
Service Interval: Every 25 hours 1. Dipstick
Figure 20
4. Pour about...
Operation Manual - Page 15
...handling. Note: When the battery no longer holds a charge, recycle or dispose of charging: • A red light indicates that ...lead-acid battery according to the mower wire harness
located below the ignition key (Figure 22).
• A green light indicates...
3. Battery compartment
Figure 22
2. Charging the Battery
Service Interval: Every 25 hours
Electric-start models only
If the battery...
Operation Manual - Page 16
Replace the fuse in serious personal injury. Lower the rear deflector.
Refer to 60 ft-lb (82 N-m) is dull or ... Remove the blade, saving all mounting hardware (Figure 26). Install the new blade and all mounting hardware (Figure 25).
5.
Examine the blade whenever you run out of wood to point toward the mower housing. 6.
Use a block of gasoline.
Figure 26
Important: Position the...
Operation Manual - Page 17
... Pull down the cable jacket (toward the mower) until there are no slack in the area. Lower the mower to Adjusting the Cutting Height. 2. Start the engine and run it for the purpose ... 1. Cleaning the Mower
Service Interval: Before each use or daily
WARNING
The mower may dislodge material from rusting.
10. For best results, clean the mower soon after you install a new self-propel cable or...
Operation Manual - Page 18
.... Preparing the Mower for 24 hours (electric-start models only). Run the mower until the engine stops from Storage
1. Disconnect the wire from the spark plug.
7. Fold the upper handle forward as directed by the engine manufacturer.
2. On the last refueling of fuel.
4. Recycle it is damaged, contact an Authorized
Service Dealer. 1. Start the engine...
Operation Manual - Page 20
... for your sole remedy under "Lawn Mowers") or access our web site at Toro Warranty Company.
*Residential purposes means use of non-use over three months or seasonal storage
-
Some states do not allow exclusions of purchase:
Products
22 in Recycler and 20 in Mulcher/Bagger and Attachments GTS (Guaranteed to Start) Engine Battery
Warranty Period...
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3371-846 Rev A
22in Recycler® Lawn Mower
Model No. 20332-Serial No. 312000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 4
... Assembly
Ref. Part Number Qty. Description
16 114-7959
1 Latch-Recycle
17 117-1031
1 Spring-Compression
18 32104-120
2 Screw-PPH
19 121-5776
1 Rear Door ASM
19:2 114-7982
1 Decal-Warning
20 115-2859
1 Spring-Torsion
21 114-7924
1 Spring-Torsion
22 112-6400
1 Port-Washout
23 112-6401
1 Coupling-Hose...
Similar Questions
Brand New Toro Recycler 20333 Won't Run When Blades Are Engaged
I bought a Toro Recycler Personal Pace yesterday and after getting it all together and ready to use,...
I bought a Toro Recycler Personal Pace yesterday and after getting it all together and ready to use,...
(Posted by conbil40 9 years ago)
Brand New Toro 22in Recycler Lawn Mower Won't Start
(Posted by nemlove 10 years ago)
Toro 190cc Personal Pace Won't Start
(Posted by Soupokef 10 years ago)
How To Change Oil On A Toro Recycler (22 ) 190cc Personal Pace Lawn Mower
(Posted by tinaScamp1 10 years ago)
Brand New Toro Recycler Won't Start
(Posted by samdann 10 years ago)