Poulan PR624 Support Question
Poulan PR624 Support Question
Find answers below for this question about Poulan PR624.Need a Poulan PR624 manual? We have 2 online manuals for this item!
Question posted by msit7774 on January 2nd, 2014
Can Fuel Be Drained From The Fuel Line?
The person who posted this question about this Poulan product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Poulan PR624 Manual Pages
User Manual - Page 1
Failure to do so can result in the U.S.A.
Always Wear Eye Protection During Operation
436132 Rev 1 05.20.10 JA/TH Printed in serious injury. IMPORTANT MANUAL
Do Not Throw Away
OWNER'S MANUAL
MODEL NUMBER:
PR624
SNOW THROWER
WARNING:
Read the Owner's Manual and follow all Warnings and Safety Instructions.
User Manual - Page 2
...
or trailer bed with electric drive motors or electric starting when setting up spilled fuel.
(h) If fuel is complete. Never allow children to prevent accidental starting motors.
6. Avoid loose ...fitting clothing that will improve footing on the ground, away from the machine. Handle fuel with a portable container, rather than from the spark plug, disconnect the cord on electric ...
User Manual - Page 3
... or light. Look behind and use a clean-out tool, not your purchase of injury associated with fuel in place and working condition.
2. never run the engine indoors, except when starting the engine.
7....or not in safe working .
10. Check shear bolts and other safety protective devices in the fuel tank inside the discharge chute is to be sure of the building. Run the machine a ...
User Manual - Page 8
...used to the cylinder for starting a cold engine.
Recoil (auxiliary) starter handle - pumps additional fuel from the 8 ground. ON / OFF switch - Remove when snow thrower is thrown.
MUFFLER
...GASOLINE FILLER CAP
CHOKE CONTROL
SAFETY IGNITION KEY
ON / OFF SWITCH
PRIMER FUEL SHUT-OFF VALVE
RECOIL STARTER HANDLE
OPERATION
AUGER CONTROL LEVER
DISCHARGE CHUTE CONTROL LEVER
...
User Manual - Page 9
...downward on discharge chute control lever and move lever left or right until chute is located beneath the fuel tank on the engine. Remove (do not turn) safety ignition key to unclog the chute and... ENGINE
1. NOTE: Never use to desired position and tighten knob securely. TO USE FUEL SHUT-OFF VALVE (See Fig. 9)
The fuel shut-off valve is in the OPEN position. WARNING: If the discharge chute or ...
User Manual - Page 11
...If necessary, add oil until the fuel lines and carburetor are adjusted to lowest (highest scraper clearance) position.
1. ADD GASOLINE (See Fig. 17)
• Fill fuel tank to bottom of snow in... evenly to give a 1/8" clearance between the scraper bar and the ground surface.
Purchase fuel in quantities that can cause serious personal injury, property damage or damage to the snow thrower...
User Manual - Page 12
... be hazardous to recoil start , repeat the above 50°F, priming is between 15° and 50°F. OPERATION
TO START ENGINE
• Be sure fuel shut-off valve is in this section of this time the snow is equipped with a recoil starter. Keep the extra safety ignition key in deep...
User Manual - Page 14
... of gasoline, oil, etc.
• We do not recommend using a garden hose to clean your snow thrower are covered to the oil drain plug and placement of this manual).
7. Be careful not to allow dirt ... cap/dipstick for 25 hours in the Service and Adjustments section of operation or at "FULL" line on level surface.
• Oil will result in contact with oil through oil dipstick tube. ...
User Manual - Page 16
... auger belt has become dislodged from around pulleys and inside belt keeper.
16. Drain gasoline from fuel tank into the square hole in the operating position and hold the snow thrower handles... injury or damage to engine crankshaft. Tip swing plate forward.
7. REMOVE GASOLINE FROM FUEL TANK - With tension relieved on crankshaft.
Install clutch rod in pulley groove and slide...
User Manual - Page 18
... to gasoline in the Service and Adjustments section of time, clean it run until the fuel lines and carburetor are securely fastened. Rust and/or dirt in your gasoline will cause problems....Store in storage.
• Empty the fuel tank by starting the engine and letting it thoroughly, remove all rusted or chipped paint surfaces; ENGINE OIL
Drain oil (with engine warm) and replace...
User Manual - Page 19
... position. 2. Insert safety ignition key.
3. Wait a few minutes before restarting, DO NOT prime. 8. Connect wire to FULL position. 6.
Engine idles or runs roughly
1. Blockage in fuel. 5. Water in fuel line. 3. Empty fuel tank & carburetor, refill with fresh, clean gasoline. 11. Replace damaged parts.
Drive belt is
disconnected. 9. Clean snow chute...
User Manual - Page 20
MODEL NUMBER PR624 (96192004200) AUGER HOUSING / IMPELLER ASSEMBLY
5
15 14
4
11 6
11
16
12
13 11
3 12
10
11 7
8
17
1
9
37
2
9
9
33
37
32
34
30
31
31
...
User Manual - Page 21
... be hazardous, damage your snow thrower and void your warranty.
21 inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL NUMBER PR624 (96192004200) AUGER HOUSING / IMPELLER ASSEMBLY
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27...
User Manual - Page 22
inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. REPAIR PARTS SNOW THROWER - - MODEL NUMBER PR624 (96192004200) AUGER HOUSING / IMPELLER ASSEMBLY
1
KEY NO.
1 2 3 4
PART NO.
404928X421 404931X431 72270505 155377
DESCRIPTION
AUGER HOUSING SCRAPPER BAR CARRIAGE BOLT 5/16−18 X .625 NUT 5/...
User Manual - Page 23
NO. Failure to do so could be hazardous, damage your snow thrower and void your warranty.
23 MODEL NUMBER PR624 (96192004200) AUGER HOUSING / IMPELLER ASSEMBLY
2
3
1
1 2
3 01.07.024-B
KEY NO.
1 2 3
PART NO.
420478 411939 179582
DESCRIPTION
AUGER BEARING BEARING PLUG SCREW 5/16−18 X 1.00
4
3
2
3 ...
User Manual - Page 24
REPAIR PARTS SNOW THROWER - - MODEL NUMBER PR624 (96192004200) CONTROL PANEL / CHUTE
2 3
6 1
11
10 5
8
6 9
11 4 11
7
6 13
12
01.09.005-E
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13
PART NO.
435023X421 178633X421 420325 179096X421 ...
User Manual - Page 25
MODEL NUMBER PR624 (96192004200) CONTROL PANEL / CHUTE
2
2 *3
1 *7
*6
KEY NO.
1 2 *3 *4 *5 *6 *7
PART NO.
428272 17501010 420678 405932 420675 428273 428310
DESCRIPTION
LEVER/CABLE ROTATOR ASSEMBLY SCREW 10-24 X .625 ROTATOR ...
User Manual - Page 26
...;16 X 1.00
4
3
4 3
4 4
01-05-013-A
NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. MODEL NUMBER PR624 (96192004200) HANDLES
5
1
6
8
5 8
6
2 39
7
8 49
7
KEY NO.
User Manual - Page 27
MODEL NUMBER PR624 (96192004200) HANDLES
10 2
11
9 5 7 6
8 47 9
1
3 8
12 13
13 14
01.08.002-F
14 12
KEY NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14
PART NO.
412683X431 424517X431 ...
User Manual - Page 28
MODEL NUMBER PR624 (96192004200) HANDLES
10 1
2 10
3 8
9 4
KEY NO.
1 2 3 4 5 6 7 8 9 10
PART NO.
180480 405740 180445 187716 180447 178669 180926 72270505 155377 169675
DESCRIPTION
IMPELLER ROD TRACTION ROD SHIFTER ...
Similar Questions
Changing Fuel Lines On Poulan Wt 200 Le
Any instructions on how to replace the 2 fuel lines on my poulan WT 200 LE Wild Thing?
Any instructions on how to replace the 2 fuel lines on my poulan WT 200 LE Wild Thing?
(Posted by lLeaf 2 years ago)
Fuel Line And Purge Line Size For P3314
I'm look for the size of fuel line and purge line for my saw
I'm look for the size of fuel line and purge line for my saw
(Posted by hillbilly117 8 years ago)
Need Fuel Line Diagram Poulan P4018 Chainsaw.
is there a fuel line diagram or pictures step by step for a poulan p4018 chainsaw?
is there a fuel line diagram or pictures step by step for a poulan p4018 chainsaw?
(Posted by partner2010rdc 8 years ago)
Replaced Fuel Lines Now Won't Idle
a diagram of replacing fuel lines on a poulan ppb 350
a diagram of replacing fuel lines on a poulan ppb 350
(Posted by ryder28658 10 years ago)
Fuel Line
the "yellow" fuel line seems to have come attached at the gas tank. How do i reconnect???
the "yellow" fuel line seems to have come attached at the gas tank. How do i reconnect???
(Posted by hob9 11 years ago)