Poulan HD185H46B Support Question
Poulan HD185H46B Support Question
Find answers below for this question about Poulan HD185H46B.Need a Poulan HD185H46B manual? We have 1 online manual for this item!
Question posted by geraldscott on September 26th, 2017
Transmission Slips
I have examine belt,added small amount fluid,but it hesitates n hill climb,fully engaged.what is your thoughts thanks.
Current Answers
Related Poulan HD185H46B Manual Pages
User Manual - Page 1
HD185H46B 18.5 HP 46 Inch Tractor
• Assembly • Operation • Customer Responsibilities • Service and Adjustments • Storage • Troubleshooting • Repair Parts
For Parts ...
User Manual - Page 3
...-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any). MODEL
NUMBER
HD185H46B
SERIAL
NUMBER
DATE OF PURCHASE
THE MODEL AND SERIAL NUMBERS WILL BE FOUND ON A PLATE UNDER THE SEAT. Other states may have competent, well-trained...
User Manual - Page 4
... limitations and exclusions. 1. Transportation charges for any power equipment unit or attachment are belts, blades, blade adapters, normal wear, normal adjustments, standard hardware and normal maintenance...on these
items. 2. In the event you have other than AYP manufactured transaxle/transmission components, battery
(except as manufactured is requested by the original consumer purchaser, we...
User Manual - Page 6
... attachment lift lever to its highest position.
• Release parking brake by depressing clutch/brake pedal.
• Place freewheel control in freewheeling position to disengage transmission (See `TO TRANSPORT" in dash and push down to insure proper tightness. TOOLS REQUIRED FOR ASSE SLY
A socket wrench set will make assembly easier. LBS...
User Manual - Page 8
... IMPORTANT ITEMS:
Engine oil is at proper level.
Fuel tank is important to purge the transmission before you learn how to operate your tractor were overinflated at the factory for leveling).
Check mower and drive belts. Correct tire pressure is in the Service and Adjustments section of this manual).
8 Be sure they...
User Manual - Page 11
... of the American National Standards Institute. Used to control engine speed.
Disengages transmission for declutching and braking the tractor and starting the engine. LIGHT SWITCH: Turns... (+) or discharging (-) of various controls and adjustments. ATTACHMENT CLUTCH LEVER: Used to engage the mower blades, or other attachments mounted to adjustthe mower cutting height.
11 Save this ...
User Manual - Page 14
... "FULL" mark on dipstick is located at more than two (2) MPH. • To reengage transmission, reverse above .
14 Use fresh, clean, regular unleaded gasoline with gasoline. Wipe off .
Do... hold in the fuel tank or permanent damage may not be sure hood is in the transmission engaged position.
• Sit on level ground. • Unthread and remove oil fill cap...
User Manual - Page 15
... control in small steps allowing the engine to accept small changes in speed and load, until the engine begins to run roughly, pull the choke control out slightly for transmission to warm ...control lever in this procedure with engine off and parking brake set parking brake.
• Engage transmission by turning to the right so that clippings will plug mower and leave undesirable clumps. ...
User Manual - Page 18
...BELTS
Check V-belts for deterioration and wear after 100 hours of this manual.
• Use gauge on oil fill cap/dipstick for checking level.
Tighten oil fill cap/dipstick securely each eight (8) hours of the transaxle.. Be careful not to allow dirt to slip from running or while the transmission... and fluid maintenance is tightened securely for the life of operation. The belts are...
User Manual - Page 24
.... Carefully remove belt upwards from around engine pulley.
• Install new belt by reversing above adjustment procedure by tightening adjustment locknut one half (1/2) turn . See "PURGE TRANSMISSION" in the Assembly section of tractor and remove downward from transmission input pulley and over cooling fan blades.
• Pull belt toward .rear of tractor. Engage parking brake.
User Manual - Page 29
...grass, leaves and trash under mower. 4. Purge transmission. Mower deck not level. 3. Replace blade. Level mower deck. 3. Replace mower drive belt. 3. Wet grass. 4. Buildup of drive
Engine ... 2. Replace blade mandrel. 5.
Poor grass discharge
1. Replace with attachment clutch engaged
1. Turn switch "ON". 2. Replace alternator.
Clean underside of grass, leaves...
User Manual - Page 31
... SHOULD BE REPLACED TO PROPERLY SECURE YOUR WIRING.
31 THE LIGHTS ARE NOT
CONNECTED TO THE BATTERY, BUT HAVE THEIR OWN ELECTRICAL SOURCE. MODEL NUMBER HD185H46B
RED
0
BATTERY
BLACK
A
AMMETER (OPTIONAL)
RED WHITE
En_D
FUSE 30 AMP. AT IDLE THE LIGHTS WILL DIM.
AS THE ENGINE IS SPEEDED UP, THE LIGHTS...
User Manual - Page 33
... Unc Ammeter Rectangular Protection Wire Loop Screw Thdrol 5/16-18 x 1/2 Tyt Harness Engine B&S
NOTE: All component dimensions given in U.S. RERA.111 FRTS
TRACTOR - - MODEL NUMW R HD185H46B
ELECTRICAL
KEY PART NO.
User Manual - Page 37
...
Washer 13/32 x 1-1/4 x 12 Gauge Strap Torque Rh Hydro Spacer Axle Hydro 300 E-Ring Key, Square
Shaft Asm. Link Shift Hydro 3000 Keeper Belt RH Hydro 3000 Washer 1-1/32 x 1-5/8 x 16 Ga. Bolt Fin Hex 3/8-16 UNC x 3/4
Gr. 5 Bushing Pinion Sector Pin Hitch 1-3-16 ... 1 inch = 25.4 mm.
37 Washer 11/32 x 1.25 x 16 Ga. REF.-.161 PP
DRIVE
TRACTOR --MC EL NUMBER HD185H46B
KEY PART NO.
User Manual - Page 38
MODEL NUMBER HD185H46B
STEERING ASSEMBLY
1
62
44
51
41 42 37 36
54 0
17
18
19
\
20
`1.
't 66 11
66 40
29'
25 6
2 0
O
29 29
68 13
46
8
47
6
9
65
46 8 6
15
7
33 10
34 35
38 REPAIR PARTS
TRACTOR - -
User Manual - Page 41
NO. inches 1 inch = 25.4 mm
JEL ZAJLER HD185H46B
ENGINE
KEY PART NO. REPAIR P14E S
TI ACTOR - - S. DESCRIPTION
1 141295 2 17720410 3 4 149723 5 144068 6 144069 7 138129 8 150176 10 145552 11 10040400 12 74780412 13 272250 14 ...
User Manual - Page 43
... -- 133671 - - 138311
159759 159760
1
DESCRIPTION
Decal Danger English/Spanish Decal Clutch/Brake English/ Spanish Decal V-Belt Dr Sch Tractor E Decal Sdl Oper Inst. Tube)
NOTE: All component dimensions given in U.S. RE IF. ...Owner's English Manual Owner's Spanish
KEY PART NO. Mi3CEL NU ER HD185H46B
DECALS
3
10
9
2
4
11 2
7
6
6
12 5
18
20
•
KEY PART NO. inches 1 inch =...
User Manual - Page 45
M= DEL NUMBER HD185H46B
LIFT
KEY PART NO. inches 1 inch = 25.4 mm
NO. Bolt Carriage 3/8-16 x 1.00 E-Ring Washer 29/32 x 1-1/4 x 16 Gauge Nut Hex Flange Lock Nut Push ...
User Manual - Page 46
... T 34 I
•
119
4
Of
118
A
3
63 6
21 67
1 5
19
21
18 I 21
21 22 23 24 25
26
2
15
I ,iclt I4I 87,
!, 127... MODEL NUMBER HD185H46B
MOWER DECK
83 77
84
81 80
75 62
0
46
/
41
76
78 92 45
,z , .53
4? --(!:)
74
0
' 49
• 41
36
46
69 1 I i 85 \:14...
User Manual - Page 47
...HD185H46B
KEY PART NO. Pulley, Idler, Flat Keeper, Belt, Idler Pulley, Idler, Driven Spring, Secondary 44/46/50 Vent Screw, Thdroll 3/8-16 x 1-1/4 Tytt Spacer, Retainer Arm, Idler Secondary Washer, Hardened Cover, Mandrel Deck Screw, Thdroll. 1/4-20 x 5/8 V-Belt, Mower, Secondary V-Belt... Gr. 5 Washer Felt Pulley Idler Link Brake 46"
Guide Belt 46" Arm Asm Brake Bolt Shld 5/16-18 Ty TT Spring...
Similar Questions
Transmission Will Not Engage
mower will not go forward or backward just makes squalling noise. can't freewheel mower by pulling r...
mower will not go forward or backward just makes squalling noise. can't freewheel mower by pulling r...
(Posted by cpatterson53 2 years ago)
Poulan Prrt65 Tiller Transmission Repair
How to diagnose and repair the transmission on a Poulan PRRT65 tiller
How to diagnose and repair the transmission on a Poulan PRRT65 tiller
(Posted by jvanderhart 9 years ago)
I Need A Diagram Of The Transmission. The Tines Turn But The Wheels Are Locked.
My Poulan Pro 850 has a transmission problem. The tines turn but the wheels are locked. I would like...
My Poulan Pro 850 has a transmission problem. The tines turn but the wheels are locked. I would like...
(Posted by Daveahne 9 years ago)