Husqvarna R 322T AWD Support Question
Husqvarna R 322T AWD Support Question
Find answers below for this question about Husqvarna R 322T AWD.Need a Husqvarna R 322T AWD manual? We have 2 online manuals for this item!
Question posted by garyjudy on August 13th, 2018
Unable To Located The Proper Connects Points For The Spring Brake Return
I have a 2014 Husqvarna O turn mower RZ 4219, I need to replace the spring brake return item 12; part no 581 542601. While it is clear where the connect hole is on the arm brake BLK it does not show where the other end of the spring is connected. A diagram would be appreciated.
Current Answers
Answer #1: Posted by hzplj9 on August 13th, 2018 2:11 PM
hzplj9
Member since:
June 25th, 2012 Points: 4,875,690
Member since:
June 25th, 2012 Points: 4,875,690
This is a link to the parts manual. It may offer help in locating the position of the spring.
https://www.manualslib.com/manual/667382/Husqvarna-Rz4219bf-966582201.html
Related Husqvarna R 322T AWD Manual Pages
Owners Manual - Page 3
...Connect battery. 8 Fill with fuel and start engine. 9 Check that there is about : Needs and benefits of applications for the hydrostat pedals.
11 Check the engine speed See the Technical data section.
12... the front and rear wheels. (Only AWD-machines) See the workshop manual. Range ... the cutting unit's cutting height setting so that the connection rod is tensed at max. 3 amp.
2 Fit...
Owners Manual - Page 5
...clear of a cliff or ditch, or if an edge caves in place.
8.Slow down for holes, ruts or bumps. Always turn off blades, set parking brake...and follow all movement on mowers
These instructions are a ...point it .
Do not use grass catcher on slopes unless necessary and then, turn...Turn off blades when not mowing.
11.Stop engine before removing grass catcher or unclogging chute.
12...
Owners Manual - Page 6
....
10.Never overfill fuel tank. Check their proper operation regularly.
5. Keep machine free of ignition.
2.Use... add fuel with the engine running. Frequently check components and replace with safety devices. Allow engine to be thrown. Do not... Mower blades are explosive. Wrap the blade(s) or wear gloves and use extrem care in contact with the engine running .
8. Check brake ...
Owners Manual - Page 8
... carefully and make sure you understand the instructions before using the machine. Keep hands and feet clear. Risk that the machine will tip over Never drive across a slope
Choke.
Fast Slow Stop...the hood when the engine is fitted
Backwards Forwards Ignition Hydrostatic freewheel Parking brake Clutch in serious or fatal injury to the operator or others.
English
The cutting...
Owners Manual - Page 11
... one person. Keep the machine at a safe distance from holes or other drugs or medication that the driver is only intended...passive medical
implants. Always stop the blades, apply the parking brake, stop quickly. Ensure you understand them and then observe them ...
• Slow before cornering.
• Switch off .
• Clear the area of the machine when you start it.
The inside of...
Owners Manual - Page 14
... or driving the machine on the machine, e.g. Place the wheel blocks in spaces lacking proper ventilation. Ensure you risk damaging the machine components.
Adjust and maintain as required.
•...run over or into anything.
frame or rear wagon. Transport
IMPORTANT INFORMATION The parking brake is heavy and can cause cuts. Exhaust fumes contain carbon monoxide, an odourless, ...
Owners Manual - Page 15
... you great pleasure for reverse. Otherwise there is moved backwards or forwards. The parking brake lock disengages automatically when the brake pedal is steplessly regulated with a BioClip-plug, finely chops the cuttings to drive backwards.
1
2
The machine 322T AWD are equipped with all wheel drive, chronometer and lights.
WARNING!
This operator's manual describes...
Owners Manual - Page 18
...concerning the placement of the engine. STOP
START
5 Turn the ignition key to its end position.
STOP
START
IMPORTANT INFORMATION
Do not run ...before subjecting it to locked position (transport position) and apply the parking brake. STOP
START
Start the engine
1 Make sure that the clutch control ...be started . Rider 322T AWD have one control for the front axle and one control for example,...
Owners Manual - Page 19
... 1
2 Carefully press down one end of the black cable to the NEGATIVE pole (-) on the fully charged battery.
• Connect the other vehicle must also have a 12-volt system with a weak battery...cutting height (1-10) with negative earth. Connecting the jump leads
Driving the Rider
1 Release the parking brake by first pressing down the parking brake pedal and then releasing it should be ...
Owners Manual - Page 20
...Turn the ignition key to select a higher driving speed without noticeably depreciating the mowing result.
• The best lawns... tips
WARNING! Clear the lawn from stones and...
! Do not use the machine on the spark plugs.
1 Lift up the cutting unit by
the blades.
• Localise and mark stones and other objects which can be poorer.
• Hose down the parking brake...
Owners Manual - Page 23
... as per item 2.
Checking and adjusting of throttle wire
Check that the engine responds to the throttle control and that the throttle wire is attached to the correct hole in the cable is adjusted correctly by placing the machine on completion of the adjustment as illustrated. Adjusting the parking brake Rider 322T AWD
Check that...
Owners Manual - Page 24
...to facilitate connection. 5 Push the hose clips back on the paper filter.
24 - Do not use compressed air to replace the ...hose ends. 4 Press the new filter into the ends of the filter to adjust the choke, proceed as follows:
Replacing the...cartridge and clean using a mild detergent.
5 Dry the pre-filter properly. 6 Clean the filter by knocking it .
1 Release the...
Owners Manual - Page 27
... blocked cooling intake will interfere with the cooling of the equipment frame's grooves.
The spring which can damage the engine.
5 Push the deck in and put the front guide ...Push the unit in the grooves on the equipment frame, one on a flat surface and apply the parking brake.
2 Check that the lever for setting the cutting height is in the lowest position and that the lifting lever ...
Owners Manual - Page 28
...points 1-6 to avoid
! Wear protective glasses when
! dismantling the cutting unit.
Removing the cutting unit
WARNING! WARNING! The spring
which tensions up the height adjustment strut. 10 Secure the collet spring... pressure by screwing in or out the adjusting screws located behind the front wheels on a flat surface...12 and 15 kg (26.5-33 lb).
3 Open the unit catch.
28 -
Owners Manual - Page 30
The spring
which tensions up the cutting unit. Assemble the parts in the vertical position. Apply the parking brake.
2 Set the cutting height control in the lowest position and lift ... the unit frame and remove the cutting unit cover.
4 Disengage the spring for cleaning, repairs and servicing.
Observe caution to provide easy access for the drive belt tensioning wheel.
8 ...
Owners Manual - Page 34
... Engine is no fuel in the fuel tank Spark plug defective Faulty spark plug connections or interchanged cables Dirt in the carburettor or fuel line Starter motor does not turn over the engine
Starter engine
motor
does
not
turn
over
the
Battery
flat
Bad contact between the cable and battery
Lift lever...
Parts List - Page 41
...WASHER
9
725 64 48-01 SCREW IHCSFM
10
506 53 56-03 DRAW SPRING
11
578 91 05-01 BRAKE
12
506 97 48-01 PULLEY
13
506 82 68-02 BUSHING
14
725 ...64-41 WASHER
21
725 24 59-51 SCREW EHHM
22
504 62 24-01 SPRING
23
504 62 21-02 HANDLE ASSY
24
505 45 17-01 WASHER
25
... NUT
32
506 96 66-01 HAIR PIN COTTER
33
506 83 76-01 SPRING
34
506 83 77-01 RING BOLT
35
734 11 72-01 WASHER
36
...
Parts List - Page 43
MOWER LIFT / DECK LIFT
R322T AWD, 966785801, 967032101, 967153001, 2012-03
Ref
Part no. Description
1... NUT
9
544 43 36-01 LIFTING ARM
10
725 25 42-51 SCREW EHHM
11
732 25 22-01 HEXAGON LOCKING NUT
12
506 91 68-01 SPRING
13
506 90 56-01 OFFSET PULLEY
... 37 86-01 LINK
24
735 31 14-20 E-CLIP
25
544 44 88-01 CONNECTION ROD
26
734 11 64-41 WASHER
27
721 61 83-01 SPLIT PIN
28
535...
Parts List - Page 45
...-04 SCREW EHHFM
4
544 40 31-01 BRAKE LEVER ASSY
6
506 94 63-01 BRAKE SPRING
7
576 71 21-01 BRAKE WIRE
8
735 31 09-20 E-CLIP
9
574 51 11-02 CONTROL CABLE
10
574 41 12-02 CONTROL CABLE
11
506 55 73-01 ...64-02 CABLE HOLDER
26
506 56 65-01 CLIP
Remark
Qty Kit 1 1 4 1 1 1 1 1 1 2 2 2 1 4 1 1 1 1 4 5 3 1 1 1 1
PEDALS
R322T AWD, 966785801, 967032101, 967153001, 2012-03
Ref
Part no.
Parts List - Page 53
...28
535 49 97-01 ARM
29
503 73 58-01 BUSHING
30
578 29 19-01 LEVER
31
721 43 47-01 SPRING PIN
33
535 49 28...
535 49 74-02 LEVER
44
506 95 17-01 ROD END
45
535 47 52-12 SCREW EHHFM
46
544 44 19-01 ADJUSTING ROD
47
732 ... 1 1 1 1 3 3 1 2 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 2 1 1 2 2 3 2 2 2 2 1 1 TRANSMISSION
R322T AWD, 966785801, 967032101, 967153001, 2012-03
Ref
Part no.
Similar Questions
I Have A R 322t Awd With A Snowblower. When I Lift The Snowblower It Does Not St
I have a r 322t awd with a snow blower, when I lift the snowblower it does not turn off. Why is this...
I have a r 322t awd with a snow blower, when I lift the snowblower it does not turn off. Why is this...
(Posted by mcludwigsen 3 years ago)
Location Of Battery On A Hu675fe Lawn Mower.
Where is the battery located on a Husqvarna HU675FE lawn mower
Where is the battery located on a Husqvarna HU675FE lawn mower
(Posted by wrileythree 3 years ago)
Snow Blower On R 322 Awd
Takes way to much strength to life both mower in summer and now snow blower in winter. Something not...
Takes way to much strength to life both mower in summer and now snow blower in winter. Something not...
(Posted by ianshirley 3 years ago)
Installing A Drive Cable How Doi Connect The Spring End?
how do I attach the spring end of drive cable
how do I attach the spring end of drive cable
(Posted by maddoxron 5 years ago)
Husqvarna Hu700f Spring- Throttle Return Part Number: 16562-zm0-000 Attachment
The throtte return spring under the governor rod decide to join the leaves. So where are the attcach...
The throtte return spring under the governor rod decide to join the leaves. So where are the attcach...
(Posted by bgrunden66 9 years ago)