Husqvarna M-ZT 61 Support Question
Husqvarna M-ZT 61 Support Question
Find answers below for this question about Husqvarna M-ZT 61.Need a Husqvarna M-ZT 61 manual? We have 3 online manuals for this item!
Question posted by jllshopping on May 11th, 2021
My 2020 Mzt Will Not Start With A New Battery
Installed a new battery that is fully charged. the hour counter is inop. it appears the entire system is dead. Where do I start
Current Answers
Answer #1: Posted by Troubleshooter101 on May 12th, 2021 4:26 AM
Troubleshooter101
Member since:
September 30th, 2015 Points: 2,927,030
Member since:
September 30th, 2015 Points: 2,927,030
Troubleshooting Checklist: Check battery charge and connection.
Check your fuel. Make sure your fuel is fresh(less than 30 days old) and that there is no water in the tank.
Make sure your spark plug is in good condition and spark plug wire is attached. If in doubt, replace it.
Make sure air filter is clean.
A dirty filter will make it more difficult for the engine to draw air. Check all visible wires and connections.
Check all in-line fuses.
Review starting procedures in your Operator's Manual.
Please check this video tutorial
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!
Troublshooter101
Related Husqvarna M-ZT 61 Manual Pages
Operation Manual - Page 3
... Blade Switch 20 Throttle Control 21 Hour Meter 21 Fuel Shut Off Valve ...Bar and Safety Belt 26 Before Starting 26 Starting the Engine 27
Jumper Cables ...Battery 37 Safety System 38 Tire Pressures 38 Parking Brake 38 Deck Belt 39 Pump Belt 40 V-belts 40 Cutting Blades 41 Adjusting the Mower Deck 42
Leveling deck 42 Anti-scalp Rollers 43 Caster Wheels 43 Hardware 43 Cleaning 44 ZT...
Operation Manual - Page 4
Each person operating the mower must be under the influence of California to cause cancer and birth defects or other ... sound mind and body and must allow only trained persons who understand these instructions to the operator or other persons. Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to the State of any mind altering substance...
Operation Manual - Page 5
...of control.
The machine can be used in relation to the machine's performance. Lawn mowers and all who are subject to avoid jack-knifing.
It can also considerably increase...when equipped with these instructions and common sense.
A control panel easily accessible to the new owner. Continuous dedication to improve our products require that the machine is constructed only for...
Operation Manual - Page 12
... blades shut off and be a minimum of 16 years of a child.
Never assume that may block the view of age before operating a riding lawn mower. They may suddenly appear in the mowing area for another ride and be run over or backed over by putting a
foot on the ground. • Do not mow...
Operation Manual - Page 13
...Before beginning to refuel, minimize the risk of Gasoline
WARNING! The engine must not be started until fueling is extremely flammable and the vapors are explosive.
• Extinguish all times until...indoors.
• Never store the machine or fuel container where there is risk for the mower deck's drive belt is spilled on clothing, change clothing immediately.
• Never overfill fuel...
Operation Manual - Page 14
...the discharge guard frequently and replace with manufacturer's recommended parts, when necessary.
• Mower blades are sharp. Repair, if necessary, before storing.
• If the machine ... protective glasses for damaging the machine components.
• Be very careful when handling battery acid.
SAFETY
General Maintenance
• Never operate machine in a closed area.
•...
Operation Manual - Page 15
...; Ensure that may have accumulated on the machine.
• Allow the machine to cool before starting.
• Never make a bridge short circuit across the starter relay to inspect the equipment if... when higher quality mowing is mounted tightly and no flammable substances are sharp and can cause battery explosion, fire or eye injury. If necessary, make repairs before putting it last.
•...
Operation Manual - Page 20
... knob out. The mower blades are disengaged when the knob is found on the control panel and is used to start , wait about 10 seconds before retrying.
IMPORTANT INFORMATION The machine must stand absolutely still when applying the parking brake.
CONTROLS
Parking Brake
The parking brake is pressed down fully. Push in and...
Operation Manual - Page 21
... intervals. USE FULL THROTTLE WHEN MOWING, for two hours or until the meter is moved forward or back respectively. To manually reset the timer, turn on the oil can icon after every fifty hours of use and will stay on for best mower performance and battery charging. Hour meter
Choke Control
The choke control is pulled...
Operation Manual - Page 29
...
The mower is too weak to start other end of the BLACK cable to short against chassis. 2. Jumper Cables Use 1. Connect each battery, taking care not to a good CHASSIS GROUND on each end of the fully charged battery. 3. Connect one end of the BLACK cable to the NEGATIVE (-) terminal of the RED cable to start the engine...
Operation Manual - Page 35
...mower deck Start the engine and blades, listen for unusual sounds Check for damage Thoroughly clean around the engine Clean around belts, belt pulleys Check the tire pressures Check battery connections Sharpen3)/ Replace mower...When operating with a heavy load or at high ambient temperatures, replace every 50 hours.
2) In dusty conditions, cleaning and replacement are required more often.
3) Performed ...
Operation Manual - Page 36
...Daily Before After
At least once each year
● ♦ ♦
Maintenance interval in hours
50
250
500
■
●
■
■
■
●
■
...hours) Replace the air cleaner's foam pre-filter 2) Change the hydraulic oil (every 500 hours) Replace the hydraulic oil filter (every 500 hours) Dismantle and inspect starter 3) (every 500 hours) Check/adjust the mower...
Operation Manual - Page 37
..., remove the bolts on the battery and terminals can cause the battery to open or remove caps or covers. Install new battery with grease or petroleum jelly 6. Reinstall battery terminal guard.
1 2
8. Connect BLACK grounding cable to prevent sparks from accidental grounding. Close access doors.
11. MAINTENANCE
Battery
The mower is not necessary. FULL CHARGE -
20 min. 35 min. 48...
Operation Manual - Page 42
... mowed or environmental conditions, additional adjustments may be installed prior to -side measurement. Reposition rear mounting bolts up to -rear manner.
Chain 3. Slotted deck hanger plates Leveling the mower deck
8011-601
42 MAINTENANCE
Adjusting the Mower Deck
Check the tire pressure before adjustment of the mower deck. Make sure the tires are under...
Operation Manual - Page 48
...will not start
Cause
• Blade switch is engaged • Steering controls are not locked in the neutral position • Parking brake is not activated • Battery is dead • ...8226; Faulty ignition system
Starter does not turn the engine over
• Dead battery • Poor contacts on the battery terminal cable connections • Fuse blown • Ignition system faulty •...
Operation Manual - Page 49
...; Poor contact with battery terminal cable connectors • Charging lead is disconnected
Machine moves slowly, unevenly, or not at all
• Parking brake on • Bypass valve on pump open • Drive belt for the transmission gears slack or has come off • Air in hydraulic system
Mower deck not engaging
• Drive...
Operation Manual - Page 50
... for extra protection. Thoroughly clean the machine, especially under the mower deck. Touch up at an authorized service workshop is very flammable...of fuel or the stabilizer has reached the carburetor.
5. Start the engine and allow it to the fuel in the ...tank, clothes drier, etc. Change the engine oil; Clean, charge, and store the battery in a cool place, but protect it from open flames,...
Operation Manual - Page 56
...
Delivery service has been carried out No remaining notes Certified:
56
SERVICE JOURNAL
Action
Delivery Service
Charge and connect the battery Adjust the tire pressure of all wheels to 15 PSI (1 bar) Connect the contact box to... with fuel and open the fuel shut off valve Start the engine Check that there is drive to both wheels Check mower deck pitch and adjustment Check:
Safety switch for the...
User Manual - Page 2
...become familiar with grass catcher partially installed.
• Disengage blades and stop engine before starting the mower and while mowing.
ALWAYS wear ...safety glasses or eye shields before storing.
Always observe the SAFETY RULES. Study the operating instructions and safety precautions thoroughly to insure proper functioning of a new...
User Manual - Page 11
...RECOMMENDATIONS Always observe safety rules when performing any maintenance. Replace bent or damaged blades.
b. Install a new plastic lawn bag with regular use . h. Replace containers, close and secure the top of the...at full speed when bagging.
• Select a speed low enough to give good mower cutting performance, good quality cut to overlap width of the tube rails. Unlatch and ...
Similar Questions
Mower Le121p, No Lights On Start Panel . Batteries Both Charged.
Can not start the mower, batteries both full . No lights at the pane
Can not start the mower, batteries both full . No lights at the pane
(Posted by Aladhunter1 9 months ago)
My Mzt 61 Appears To Have A Complete Power Failure
Recently my M-ZT 61 would not crank after sitting for about 2 weeks. I noted the I noted the hour in...
Recently my M-ZT 61 would not crank after sitting for about 2 weeks. I noted the I noted the hour in...
(Posted by jllshopping 3 years ago)
Location Of Battery On A Hu675fe Lawn Mower.
Where is the battery located on a Husqvarna HU675FE lawn mower
Where is the battery located on a Husqvarna HU675FE lawn mower
(Posted by wrileythree 3 years ago)
It Will Not Crank When Hot.
Ather you mow for awhile, you cut off the engine and then try to crank it back up,It will not crank ...
Ather you mow for awhile, you cut off the engine and then try to crank it back up,It will not crank ...
(Posted by chiefowens141 7 years ago)
Won't Start
Brand new M-ZT 61 started at shop. put on trailer and turned off...started it again. When I got home...
Brand new M-ZT 61 started at shop. put on trailer and turned off...started it again. When I got home...
(Posted by dogman5474 10 years ago)