Honeywell HW2000i Support Question
Honeywell HW2000i Support Question
Find answers below for this question about Honeywell HW2000i - Portable Inverter Generator.Need a Honeywell HW2000i manual? We have 1 online manual for this item!
Question posted by Roddymcphee on August 6th, 2022
No Fuel Going To Manual Prime Pump
unit has sat for a couple years. I have drained old gas out and replaced with new gas. It will not start due to no fuel being supplied to priming pump.
Current Answers
Answer #1: Posted by SonuKumar on August 6th, 2022 9:28 PM
SonuKumar
Member since:
May 9th, 2021 Points: 16,617,810
Member since:
May 9th, 2021 Points: 16,617,810
https://www.youtube.com/watch?v=LpGsfDm1CvI
https://www.manualsdir.com/manuals/97543/honeywell-hw2000i.html?page=33
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Honeywell HW2000i Manual Pages
Owners Manual - Page 2
... Temp.: Serial Number:
HW2000i 101440A 120V/12V 2.0kW 40oC
Phase:
1
Frequency:
60Hz
Engine RPM: 5000
Fuel:
Gasoline
Insulation Class: F
Date of others, be asked to be found on owning a Honeywell inverter generator! Identification information specific to properly follow all instructions and precautions can be seriously hurt or killed.
Northshore Power Systems, LLC Milwaukee...
Owners Manual - Page 5
... Screen ...24 Spark Plug Service ...25 Transporting Generator ...26 Storing Generator ...26
TROUBLESHOOTING ...27
SPECIFICATIONS AND WIRING DIAGRAMS 29
WARRANTIES ...33
NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY 33 NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY 34
INDEX ...37
MAINTENANCE PARTS 39
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
i
Owners Manual - Page 8
... powerful voltage that are extremely flammable and explosive under Warranty.
2
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Turn generator OFF and allow flames or sparks near the generator or where gasoline is running at least 6 feet (2 meters) away from
buildings, other equipment, and combustible materials during operation. • NEVER fill fuel...
Owners Manual - Page 11
... on the generator nameplate (see illustration below). WARNING ANYONE using this Owner's Manual.
Failure to avoid back or other bodily injury.
Ambient Temp.: Serial Number:
HW2000i 101440A 120V/12V 2.0kW 40oC
Phase:
1
Frequency:
60Hz
Engine RPM: 5000
Fuel:
Gasoline
Insulation Class: F
FIGURE 3: Generator Nameplate Location HW1000i / HW2000i Inverter Generator Owner's Manual
www...
Owners Manual - Page 15
... cap. J-Choke Control Controls choke valve.
E-Recoil Starter Handle Starts engine.
Choke control must be in better fuel consumption and less noise. B-Top Maintenance Cover Provides access to air filter, fuel filter, and oil fill cap.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
9
WARNING Muffler reaches temperatures that can cause serious burns...
Owners Manual - Page 17
...
loose sand or snow.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
11 Use generator only outdoors and far away from buildings, other equipment, and combustible materials during operation. Preparing for instructions on filling, checking, and changing oil. ‰ Check/add fuel-ADD FUEL. OPERATION
Generator Location
When deciding on the location...
Owners Manual - Page 18
... can cause permanent damage to appliances. • NEVER start generator with a full fuel tank.
2.
FIGURE 7: Efficiency Mode Switch
6. ON position
12
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual FIGURE 9: Engine Control Switch
8.
Place the generator outside on . • Do not move the generator while it is running condition. • Check engine...
Owners Manual - Page 19
... times to snap back against the engine. 11.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
13 After the engine starts, let run to empty before being refilled, the primer bulb may need to be depressed 30-50 times to prime the fuel lines.
9.
While securing the generator with one hand, grip the recoil starter handle and...
Owners Manual - Page 20
... the OFF position. 5. NOTICE If engine jetted for each 1000 foot (300 meters) increase in the crankcase. HW1000i / HW2000i Inverter Generator Owner's Manual If the overload indicator illuminates longer than 5000 feet (1500 meters) above sea level. Turn the fuel valve to operate abnormally, becomes sluggish, or stops suddenly, turn it OFF immediately. Turn the...
Owners Manual - Page 21
... working order.
• Keep the generator away from other electric cables or wires including commercial power supply lines.
• Do not use generator for any purpose other than its intended...
60 / 100
65-175 55-250 750* 1200-1875 750-1500
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
15 CAUTION
The values provided in following table are in your electrical...
Owners Manual - Page 22
...Allow up or cord damage may go unnoticed.
16
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual NOTICE
Starting appliances that of motorized appliances include refrigerators, water pumps, and furnace blowers. NOTE: Appliances in grey require a higher wattage output than the inverter generator will produce. Be sure the appliance power rating does not exceed that...
Owners Manual - Page 23
... sustained high-load or high-temperature, or use
X X
X** X**
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
17 FREQUENCY*
MAINTENANCE TASK
Before each use
Fill fuel tank
X
Check engine oil level
X
Check air cleaner
X
Clean air cleaner
Change engine oil (HW1000i)
Change engine oil (HW2000i)
Check/clean spark plug
Clean spark arrestor‡
First...
Owners Manual - Page 25
... oil fill cap until warm. 4. HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
19
Remove the back maintenance cover using the Phil-
To change engine oil, you will cause the low oil protection feature to shut off the generator to engine oil, with oil by tilting or laying the
unit on its side.
Place the...
Owners Manual - Page 27
... wash with clean water and seek medical attention.
Never use , fill the fuel tank with recommended fuel.
Before using an oxygenated fuel, ensure pump octane rating is swallowed.
If you notice undesirable operating symptoms, switch to avoid spilling fuel.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
21
FIGURE 28: Oil Fill Cap Installation
NOTE...
Owners Manual - Page 28
...Use fresh gasoline with soap and water. 5. Remove the fuel cap.
5. Allow to overfill. Remove the fuel cap (A) and fuel strainer (B). Gently reinstall the fuel strainer and replace the fuel
cap.
22
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Cleaning Fuel Strainer Cleaning Fuel Strainer
Ethanol (ethyl or grain alcohol)
Gasoline containing more than...
Owners Manual - Page 32
... for long-term storage:.
Recommended Service Procedures Based on the generator. Contact authorized generator dealer for storage. Drain the fuel into a suitable container (see page 22).
26
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Remove the spark plug. At this point, the piston is stored.
1.
OFF position
2. Run the engine until it from...
Owners Manual - Page 33
..., call 1-888-494-3571 or visit www.honeywellgenerators.com. Stale fuel. Drain fuel tank;
Dirty air filter.
Add fuel (page 22). HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
27
Dirty spark arrestor screen. TABLE 9. Pump fuel in the carburetor. (HW2000i model only)
Clean or replace air filter (page 23). Clean spark arrestor screen (page 24...
Owners Manual - Page 35
... / 0.6-0.7
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
29 ...POWER OUTPUT
Rated (AC) [watts]
900
Rated (DC) [watts]
60
Frequency* [hertz]
60
Voltage (AC)* [volts]
120
Voltage (DC)* [volts]
12-18
OPERATING TEMPERATURE
Maximum [F / C]
104q / 40q
Minimum [F / C]
14q / -10q
ENGINE
Speed [rpm]
5400**
Type
OHV 4-cycle
Displacement [cc]
53
Fuel...
Owners Manual - Page 36
...
_ AC + AC
DC breaker 5A
DC winding
#18 blue
secondary
#18 black
inverter
#16 black
AC breaker 10A
5-15R G W
~120V
#18 yellow / green
white
M
step motor/ fuel control
overload indicator light
fuel economy
switch
output indicator
light
ground terminal
HW1000i / HW2000i Inverter Generator Owner's Manual
DC12V Outlet 5A
front panel assembly
on / off switch
low oil indicator...
Owners Manual - Page 40
...dealer.
34
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Purge valves
8. NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY
NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY
Honeywell Inverter Generator
WARRANTY STATEMENT
The U.S.
Northshore Power Systems, LLC (NSP), CARB, and EPA offer the following...
Similar Questions
Fuelline Diagram Honeywell 2000 I
I need a diagram for Honeywell 2000 I portable inverter generator
I need a diagram for Honeywell 2000 I portable inverter generator
(Posted by eddiegutierrez6057 1 year ago)
Need Fuel Line Diagram For 1000i Generator
(Posted by luckyballs1970 2 years ago)
How To Add A Primer Ball To Honeywell Hw2000i Inverter Generator
(Posted by jnunDragon 9 years ago)
I Have A Honeywell 2000i Inverter Generator I Need Some Information How To Putt
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
(Posted by marlon1960 10 years ago)