Hayward Universal H-Series Low NOx Support Question
Hayward Universal H-Series Low NOx Support Question
Find answers below for this question about Hayward Universal H-Series Low NOx.Need a Hayward Universal H-Series Low NOx manual? We have 4 online manuals for this item!
Question posted by richbousson on May 21st, 2014
Have A Hayward 200 Heater With A Bad Heat Exchanger. Will A 250 Heat Exchr Fit?
Is a heat exchanger from a 250 compatible with a 200?
Current Answers
Related Hayward Universal H-Series Low NOx Manual Pages
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 1
... gas supplier, call the fire department. - Do not store or use
any phone in pool/spa heater installation. Follow the gas supplier's instructions. • If you cannot reach your gas supplier from a
neighbor's phone.
H350FDN & H350FDP; POOL AND SPA/HOT TUB HEATERS H250FDN & H250FDP; H400FDN & H400FDP MODELS
OWNER'S MANUAL
FOR YOUR SAFETY
WARNING: If the information...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 4
...backrest for all applicable National, State, and Local codes.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville,TN Tel: 908...Pool or Spa if any listed (per pump in an entrapment.
floor or wall), must be located on seating areas or on the heater and to all metal parts of swimming pool or spa, and to avoid "dual blockage" by a user. • Dual suction fittings...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 6
...pool/spa to the 100°F [38°C] maximum rule.
4. The symptoms of Hyperthermia include: drowsiness, lethargy, dizziness, fainting, and an increase in the birth of water that provide a means for therapy, it should adhere to mix in regulating water temperatures by the U.S. Failure to recognize the need to perceive heat... HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville,TN...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 7
...pool/spa/hot tub heater to defects in this manual. We further warrant that the owner read the manual before using the swimming pool/spa/hot tub heater. Hayward strongly recommends that if the heat exchanger or exchanger... for all users, for the safe use of the swimming pool/spa/hot tub heaters. General Information
7
Introduction:
This manual contains instructions for installation...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 8
....
8 Section II. Consumer Operation & Maintenance
MAINTAINING PROPER WATER CHEMISTRY
WARNING:
Failure to heat exchanger
3. Yet, it remains vital that
the pump is operating and the system is state of sun - Heat exchanger damage or failure resulting from the highest quality of your Hayward pool heater is NOT covered under the terms of copper and nickel (Cupronickel) materials...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 9
... 25 in drowning. Refer to the heat exchanger. Heater operation: Full lighting and shutdown instructions are included on page 26.
5.
Ingestion of such intoxicants can cause drowsiness, which can accumulate in the installation manual on the lighting & operating instructions label affixed
to using pool, spa, or hot tub. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 14
...repair any part or parts of the pool/spa heater which the serial numbers have been ...pool/spa heater is misused, damaged by an external source of energy; 10. There are limited in workmanship and materials under this warranty. We shall not pay, nor be free from the date of original installation for all users.
2. 14 Hayward Pool Heater Certificate of Limited Warranty
Limited heater...
Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 15
... have our representatives make any claimed defect. SAFETY WARNING: Pool heaters are heat producing appliances and to avoid damage or injury in the event of possible overheating of purchase either address:
Hayward Pool Products, Inc. 620 Division St. 15
of the service life of the defective heater or part, as a legally binding obligation of excess gas...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 4
...spa, and to the following entrapment hazards:
Hair Entrapment- Run a continuous wire from near point to near point. • Dual suction outlets shall be located on seating areas or on the heater...an opening of swimming pool or spa. A differential pressure ...8226; Dual suction fittings shall not be placed... evisceration (disembowelment). USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 6
...Special caution is a fitting, fitting assembly, cover/grate...HAYWARD GENUINE REPLACEMENT ...heat. 3.
Consumer Product Safety Commission should check the water temperature with controls, because scalding can cause fetal damage during spa or hot tub use spas or hot tubs.
6.
Spa or hot tub water temperatures should obtain a physicians advice before entering the pool/spa to exit the pool...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 7
... pool/spa/hot tub heater is state of all users, for proper low-flow protection.
The premium materials and the exacting processes used in the manufacture of the swimming pool/spa/hot tub heaters. Follow these guidelines to help prevent pre-mature damage or failure to heat exchanger protection. Hayward strongly recommends that the heat exchanger be flowing through the heater...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 8
...your heater's heat exchanger:
Chlorine Bromine
pH
Total Alkalinity Calcium Hardness
Salt
Recommended Level
1 - 3 ppm 2 - 4 ppm
7.4 - 7.6
80 - 120 ppm
200 - 400 ppm
Effect of Low Levels
hazy water, algea growth, bacteria causing infections
corrosive to heat exchanger, swimmer irritation
corrosive to heat exchanger, large fluctuations in extensive damage to heat exchanger
3. Changing spa water...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 11
... install the heater where water spray from the heater:
Figure 1
1. USE ONLY HAYWARD GENUINE REPLACEMENT ...heater. It is located in damage to the area adjacent to the heater or to the ground.
Outdoor installation and service clearances:
The heater must be installed outdoors such that the location of the heat exchanger.... Locating the heater: Locate the pool/spa/hot tub heater in Figure ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 24
...propane gas tank is shipped from pool/spa structure and in accordance with BTUH capacity (which must have an I.D. 24
gas supply installation:
The heater is installed underground, the discharge of...for heaters that soot up due to Hayward Technical Service. If doubt exists as to provide adequate vaporization for correct sizing. Insert the pipe to or
Low voltage
greater than the heater ...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 25
... water only, as any other element of water flow from the pool
or spa. The fittings will maintain proper flow through the heat exchanger if the flow rate is to be installed on the heater inlet pipe. On plastic headers, the fit- See Figure 19.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN Tel...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 27
... three (3) feet above the surface of the pool/spa water, install eyeball fittings or directional flow fittings on the end of the return water line to the pool/spa to create adequate back pressure at a lower elevation than the heater as shown in Figure 24 to prevent drainage of the pool/spa water, install a loop as shown in the...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 28
...All electrical wiring MUST be used for this purpose (see Figure 36 for non-ASME pool/spa heaters. If necessary, connect a pipe (of the same size as the valve outlet) ...The heater must include a definite means of Electric Shock. If desired, you may order the pressure relief valve from Hayward; A suitable drain valve is included separately with National Electric
USE ONLY HAYWARD GENUINE...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 34
.... USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com Heat exchanger soots up. ...the range of those in the "OFF" position when the nipple is more than one pool/spa heater
6. If
the pressure is needed . 7. Improper gas pressure or gas bv.oTluurmn tehewreiglullactorreaadtjuesttmheentfsocrlelwowcloicnkgwisceotonidnictreioasne...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 58
... (rusty, etc.) water; 6. 58 Hayward Pool Heater Certificate of Limited Warranty
Limited heater warranty: TERMS AND COVERAGE: We warrant our pool heater to be free from course of dealing or usage of trade imposed on which the serial numbers have been altered, defaced, or removed. 4.
Damage caused substantially or contributed to the pool/spa at some time due...
Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN - Page 59
...SUCH DAMAGE. Elizabeth, NJ 07207
or
Hayward Pool Products, Inc. 2875 Pomona Boulevard Pomona, CA 91768
Upon receipt of excess gas in the heater. LIMITATION ON LIABILITY:
All intended ... or to repair or replacement of the defective heater or part, as a legally binding obligation of the heater. SAFETY WARNING: Pool heaters are heat producing appliances and to avoid damage or injury in...
Similar Questions
Hayward H400fdn Low Now Heater Won't Start
started heater when i opened my pool this week. it started right up, i let it run for about half an ...
started heater when i opened my pool this week. it started right up, i let it run for about half an ...
(Posted by krez 11 years ago)
Heater Won't Shut Off.
my hayward h150 heater wont shut off,i tryed shutting the switch n turning down the thermostat,it ev...
my hayward h150 heater wont shut off,i tryed shutting the switch n turning down the thermostat,it ev...
(Posted by jvzx6r 11 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)