Hayward PowerFlo Matrix Support Question
Hayward PowerFlo Matrix Support Question
Find answers below for this question about Hayward PowerFlo Matrix.Need a Hayward PowerFlo Matrix manual? We have 1 online manual for this item!
Question posted by Bergloffbuilders on May 17th, 2014
Is There 3 Different Hp On A Sp15922s Depending On Dimension A
Ipurchased what i thought was a SP15922S 2 hp 2 speed pump when it was delivered it has a 1.0 hp tag on the box and motor,But in the instruction manual it shows 3 different hp depending on dimension A. I have tried to contact hayward numerous times but put on hold for way to long,so i havebeen trying to get info on this pump but no luck so far. My dimension ..according to the directions, "A"is 12 inches supposed to be 1 1/2 -2.0 hp .Before i connect the pump i would like to know if this is normal procedure for single tagging the pumps or if they sold me the wrong 1??
Current Answers
Related Hayward PowerFlo Matrix Manual Pages
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 1
... qualified professional install and service this product. SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS, INC. D
OWNER'S MANUAL
INSTALLATION, OPERATION, & PARTS
Power-Flo Matrix™ Pump Series
The Hayward Power-Flo® Matrix™ Pump Series is specifically engineered for the demanding requirements of this manual carefully and completely. The advanced design reduces maintenance...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 2
...INSTRUCTIONS
When installing and using this electrical equipment, basic safety precautions should always be readily disassembled for storage. The Power-Flo Matrix™ Pump Series is intended for use on permanently
installed above -ground and on-ground pools... pools. Bond motor to all electrical equipment, metal piping or conduit within 5 ft. (1.5 m) of inside walls of swimming pool, spa,...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 3
...
type receptacle protected by a Ground Fault Circuit Interrupter (GFCI). Power-Flo Matrix™ Pump Series __________
NOTE: The National Electrical Code (NEC) permits use of a... swimming pool filtration system operate under pressure. Confirm that the receptacle is intended for pools and spas require two (2) functioning suction outlets at more than 30 PSI. SAVE THESE INSTRUCTIONS If ...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 4
... for easy winterization of pump
Installation Instructions
Pump Location
For best pump performance, locate the system below the pool water line. Simply converts...manual MUST be followed precisely.
Power-Flo Matrix™ Pump Series
Product Specifications
Dimensions
General Information
Introduction
This manual contains information for the proper installation and operation of dependable...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 5
.... Do NOT ground to ground pump motor can cause serious or fatal electrical shock hazard.
Use Teflon tape to meet all local and national codes. The field supplied base or pad must be level and vibration-free. Power-Flo Matrix™ Pump Series
Installation Instructions (cont.)
Pump Location (cont.)
Install pump on pipe or hose joints. Though...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 6
... Matrix™ Pump Series
Installation Instructions (cont.)
Electrical (cont.)
Voltage
Voltage at full load, consult power company.
Bond motor to suction pipe level. Wiring
If other lights or appliances are also on end of swimming pool, spa, or hot tub.
New Installation - Start-Up & Operation
Prior to Start-Up
Fill strainer housing with water before starting motor...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 7
...freeze will not damage plastic system components;
See filter owner's manual. ƒ When water source is higher than the pump, pump will prime itself when suction and outlet valves are
opened. &#... components in your pool/spa
system.
Be sure all air from base (if applicable). Selecting Pump's Discharge Position (4 Steps)
Your Hayward Power-Flo Matrix™ pump can cause
components ...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 8
... the strainer cover. Remove the canopy or the shaft cover plate from the motor/pump assembly.
2.
Disconnect pump from bottom of injury, do NOT cover or wrap pump with a GFCI
protected receptacle or hard wire (conduit) connection for a long time (see instructions below all intake and output fittings and piping. 3.
To avoid dangerous or fatal...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 9
...motor shaft. Make certain motor shaft turns freely before restarting the pump. Hand-tighten the impeller in this manual.) 3. Re-assemble strainer by pushing clip down onto grooved pump cover coupling. Reconnect pump to the pump...the pump housing recess with the rotating portion of motor shaft. Do not use ). 3. Power-Flo Matrix™ Pump Series
Shaft Seal Change Instructions (...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 10
...'s instructions; Insure air vents are fully open and not blocked, that pool water level is at full RPM's. Check voltage to correct: Sand filters - Clogged or restricted strainer or suction line; Cartridge filters - Foreign matter in position and lubricated with water and the cover O-ring is locked firmly in pump housing. Power-Flo Matrix...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 11
...189; HP Motor with Lock Ring & 'O' Ring
10
Strainer Cover 'O' Ring
10
Strainer Basket
10
Strainer Retainer/ 'C' Clip
10
Strainer Housing
1
Drain Plug w/ Gasket
10
Strainer 'O' Ring
10
Screw, #14 x 1/4" Type B Pan Head
80
Pump Cover
4
Housing 'O' Ring
10
Impeller (Refer to Part No.
Req'd
1 1 1 1 1 1 1 8 1 1 1 1 1 1 1 1 1 1 1 2 Power-Flo Matrix™ Pump Series
Replacement...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 12
Power-Flo Matrix™ Pump Series
__________
HAYWARD® LIMITED WARRANTY
This pump was inspected before shipment from Hayward:
□ Pump □ Filter □ Automatic Pool Cleaner □ Light □ Chlorinator □ Skimmer □ Heater To original purchasers of purchase. warrants its products free from defects in materials and workmanship for a ...
Similar Questions
Where Is The Capacitor On My Hayward Matrix 1 1/2 Hp Pool Pump
(Posted by VERjhonri 9 years ago)
1 Hp Hayward Sp5500z2 Pool Pump Power Flo Matrix Motor Wont Start
(Posted by Rvesjeevi 10 years ago)
Hayward Power-flo Matrix 1.5 Hp Pool Pump Wont Start
(Posted by tbblai 10 years ago)
Dual Pool Spa System But The Settings Menu Doesn't Show Pool Heater Only Spa Hea
(Posted by Anonymous-39619 12 years ago)
Intermittent Starting Of Super Ii Pool Motor
Have a Hayward Super II 1.0 HP pool motor about 15 yars old. Sometimes it does not start - it will h...
Have a Hayward Super II 1.0 HP pool motor about 15 yars old. Sometimes it does not start - it will h...
(Posted by cmathe 12 years ago)