GE GG40T06PVK Support Question
GE GG40T06PVK Support Question
Find answers below for this question about GE GG40T06PVK.Need a GE GG40T06PVK manual? We have 2 online manuals for this item!
Question posted by 00alecos on July 4th, 2014
Water Heater With Power Vent And Flammable Rv Sensor Can Bypass
The person who posted this question about this GE product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related GE GG40T06PVK Manual Pages
Use and Care Manual - Page 1
... not return to the seller from a neighbor's phone. WARNING: If the information in the vicinity of this water heater read carefully and keep in manufactured (mobile) homes! Do not store or use gasoline or other flammable vapors or liquids or other combustible materials in these instructions is required, refer to install, operate or...
Use and Care Manual - Page 2
...Information Safety Precautions 3-6 LP Gas Models 5
Installation Instructions Location 7 Water Supply Connections. . . 9 Gas Supply 11 Venting 12-16 Wiring Diagram 17 Pipe Insulation 18 Heat Traps 19 ... mean:
!
Proof of your water heater properly.
Always read and obey all .
IF YOU NEED SERVICE
If you do need to use and maintain your water heater. For service call for service...
Use and Care Manual - Page 3
... result in this or any questions, STOP, and get help from carbon monoxide, never operate this water heater. INSTALL THE BLOWER ASSEMBLY AND PROPERLY VENT THE WATER HEATER... WARNING
Care and Cleaning
Troubleshooting Tips
Customer Service
FLAMMABLES
Flammable Vapors
FIRE AND EXPLOSION HAZARD
Can result in serious bodily injury or death. Safety Instructions Installation Instructions...
Use and Care Manual - Page 7
..., Quincy, MA 02269 as practical to the gas vent or chimney.
● Long hot water lines should be insulated to conserve water and energy.
● The water heater and water lines should never be stored in unprotected outdoor areas.
● Minimum clearance from where liquids which give off flammable vapors are to be protected from exposure to...
Use and Care Manual - Page 8
... supplied from outdoors, or a freely ventilated attic or crawl space. If the water heater is normally adequate for combustion and ventilation air must comply with the outdoors, each must be supplied through a flame. DO NOT obstruct or block the Flammable Vapor Sensor.
If air is due to prevent clogging by lint or other unconfined...
Use and Care Manual - Page 9
... joint union Sediment trap
Cap
Thermostatic gas valve
Jacket door
Flammable Vapor Sensor
Auxiliary catch pan Drain Pan Pipe to suitable drain.
1/4" per local codes and valve manufacturer's instructions. Typical Installation
Vent connector to chimney
Union
Heat trap 6" minimum
Hot water outlet
to fixtures
HOT
Water Heater Jacket
COLD
Temperature and pressure relief valve
Manual gas...
Use and Care Manual - Page 10
... and choose Bulletin #1402.
The Btuh rating of the relief valve must pitch downward from the valve to vent from the hot water faucet(s) indicates a full water heater.
A new combination temperature and pressure relief valve, complying with water. No valve of any type should be of any type, restriction, or reducer coupling should be installed...
Use and Care Manual - Page 12
... of these instructions.
DO NOT connect this water heater to the outdoors as outlined in these conditions are found, they must be vented separately from all other structural members to the left).
If any of this manual will result in accordance with a Flammable Vapor Sensor. DO NOT drill or punch holes in the box with...
Use and Care Manual - Page 15
... elbow and join it as a dryer or furnace area is considered to the vent pipe on the blower outlet. Mortar or Silicone Caulk Vent Pipe From Water Heater
Pipe Coupling
Horizontal Vent Installation
2' x 2' Sheet Metal Shieldon Brick or Masonry Walls
Once the vent terminal location has been determined, make a hole through the exterior wall to the...
Use and Care Manual - Page 16
...to the water heater vent connection.
Use a natural bristle brush or the dauber supplied with a Flammable Vapor Sensor. The proper brush size is known to inside surface of socket and outside of vent pipe used...: Stir the solvent cement frequently while using. Do not apply power until it bottoms out. Care and Cleaning
Troubleshooting Tips
Customer Service
16 Draining the Condensate
...
Use and Care Manual - Page 18
... and property. This could result in conjunction with storage tank heaters.
The use on the exterior of the water heater or the area where the combustion air inlet openings and Flammable Vapor Sensor are not necessary. Do not apply insulation to relocate them on gas water heaters are located.
WARNING: If local codes require external application of...
Use and Care Manual - Page 19
...power to
combustibles as specified on the rating plate.
❑ DO provide adequate air for combustion
and ventilation as discussed in the Use and Care Manual and the National Fuel Gas Code.
❑ DO maintain proper clearances to the water heater...or the Flammable Vapor Sensor located around the lower portion of the water heater is within the range specified on the rating plate.
Use and Care Manual - Page 20
... observed
❑ Flammable vapor sensor is not blocked. Operating Instructions Installation Instructions Safety Instructions
Installation Checklist
A.
Venting
❑ Flue baffle properly hung in top of heater's
flue.
❑ Blower assembly properly installed.
❑ Vent connector(s) pitched upward to check all
connections and fittings for proper
operation of water heater.
❑...
Use and Care Manual - Page 23
... this manual and on the label located on the water heater near the gas control thermostat. Households with HOT water.
HYDROGEN GAS IS EXTREMELY FLAMMABLE!! There is no main burner flame is recommended that the hot water faucet be considered when selecting the water temperature setting of this water heater that a qualified person or serviceman perform the work...
Use and Care Manual - Page 25
... solenoid valves in automatic water using appliances can act as the presence of flammable vapors or blockage of the water heater. proper operation of these...sensors from the water heater's tank every month to operate erratically. It is turned off gas to accumulate in the water pipe system or water hammer arresting devices can cover the gas control (thermostat) sensors, causing the sensors...
Use and Care Manual - Page 26
... gas piping and leak testing..
Inspect the gas venting system and the chimney. If any maintenance or cleaning. DO NOT obstruct or block the Flammable Vapor Sensor.
Reinstall the blower assembly. A vacuum cleaner can be used on the burner and floor shield inside the water heater.The burner can be performed only by scrubbing with...
Use and Care Manual - Page 28
...gas control (thermostat), burners, vent connectors or other safety devices. Proper operation of the water heater down if undesirable combustion conditions ...water heater size that shuts the operation of the water heater requires air for the first time.
Care and Cleaning
Troubleshooting Tips
Customer Service
28 Review the charts on water heater jacket. Such as the presence of flammable...
Use and Care Manual - Page 29
...
The gas control (thermostat) may be corrected.
Low gas pressure. See the "Water Temperature Setting" of The Water Heater section of gas piping, gas control (thermostat), burners, vent connectors or other safety devices.
CAUTION: Make certain power to recover after an abnormal demand.
Water is "OFF" before removing protective cover FOR ANY REASON. Care and Cleaning...
Use and Care Manual - Page 30
... service agent. CAUTION: Make certain power to water heater is too high, the valve will not operate. Heat Mode.
● No problem. ● No problem.
Pressure Switch Fails to qualified service personnel.
30
Troubleshooting Tips
Customer Service Wiring errors can cause improper and dangerous operation. Normal operation. Lockout condition.
Flammable Vapors Present.
● Third...
Use and Care Manual - Page 31
...)
Care and Cleaning
Troubleshooting Tips
Customer Service
*Burner
Flammable Vapor Sensor *Burner Access Door Gasket
*Burner orifice *Spark Igniter... repair of parts desired. Specify type of the water heater from the rating plate.
Instructions For Placing a ...vent connectors or other safety devices. Safety Instructions Installation Instructions Operating Instructions
Replacement Parts...
Similar Questions
How Can I Reset My Propane Ge Smart Water Heater Power Vent
(Posted by lpattpero 10 years ago)
Ge Power Vent Heater Doesnt Turn On
I HAVE A GE POWER VENT HEATER MODEL # GG40T06PVK00 WITH THE INTELLI-VENT THERMESTAT. THE HEATER DOES...
I HAVE A GE POWER VENT HEATER MODEL # GG40T06PVK00 WITH THE INTELLI-VENT THERMESTAT. THE HEATER DOES...
(Posted by ccaballero 12 years ago)