2004 Dodge Ram 2500 Pickup Support Question
2004 Dodge Ram 2500 Pickup Support Question
Find answers below for this question about 2004 Dodge Ram 2500 Pickup.Need a 2004 Dodge Ram 2500 Pickup manual? We have 2 online manuals for this item!
Question posted by jamyalbertson on March 27th, 2022
Lift Pump In Tank Relocation
when I put in the new fuel pump in the tank can I leave the old one one side of motor and pump right
Current Answers
Answer #1: Posted by techyagent on March 27th, 2022 1:42 AM
techyagent
Member since:
June 17th, 2014 Points: 4,799,790
Member since:
June 17th, 2014 Points: 4,799,790
When the lever pulls the diaphragm down, it creates suction that draws fuel along the fuel pipe into the pump through a one-way valve . As the revolving cam turns further, so that it no longer presses on the lever, the lever is moved back by a return spring , relaxing its pull on the diaphragm.
https://www.dieseltruckresource.com/forums/24-valve-engine-drivetrain-89/lift-pump-relocation-329368/
Please click here
Thanks
Techygirl
Answer #2: Posted by SonuKumar on March 27th, 2022 7:08 AM
SonuKumar
Member since:
May 9th, 2021 Points: 16,609,790
Member since:
May 9th, 2021 Points: 16,609,790
https://www.youtube.com/watch?v=z01o9Ac1iJE
https://www.youtube.com/watch?v=xKFq2CbDX1E
https://www.youtube.com/watch?v=NZRZtoC3ieI
Does a 5.9 Cummins have a lift pump?
There are two fuel pumps on the 5.9 Cummins. One is a lift pump that lifts fuel from the fuel tank. The fuel is siphoned to the main 5.9 Cummins injection pump, which then sprays it into the engine. In order to check the performance of fuel system parts, you'll need a scanner.
How is the fuel moved by the fuel lift pump?
When the lever pulls the diaphragm down, it creates suction that draws fuel along the fuel pipe into the pump through a one-way valve . As the revolving cam turns further, so that it no longer presses on the lever, the lever is moved back by a return spring , relaxing its pull on the diaphragm.
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Manual Pages
Owner's Manual - Page 116
... runs out of total vehicle miles since the last reset increases. Ram fuel tank volumes are as the number of fuel or is suggested that can be travelled with the fuel remaining in the tank. It is refueled. When Distance To Empty = 0, the fuel gauge pointer will remain equal to prevent the likelihood of customers running...
Owner's Manual - Page 150
... the transmission in NEUTRAL until fluid is in areas where there aren't many gas stations. Ram fuel tank volumes are as trailer towing. Low Wash Light This light comes on the fuel gauge. Fuel Gauge Shows level of tank volume. Odometer/Trip Odometer Button Press this light comes on, stop the vehicle and run the...
Owner's Manual - Page 188
...UNDERSTANDING YOUR INSTRUMENT PANEL
snowflake button shows that the air conditioning is desired.
The mode control (at the right of the control panel) can be noticed when the air conditioning compressor is a normal occurrence as the ...choices, the system allows you to maintain comfort and increase fuel economy. NOTE: Selecting a "Recirculation Mode" mode does not necessarily consume more...
Owner's Manual - Page 206
... starting procedure, it there while cranking the engine. CAUTION! Apply the brake before trying again. Push the accelerator pedal all the way to any excess fuel in NEUTRAL or PARK position. Normal Starting of Park (P). If the engine has been flooded, it may be depressed to the START position and release...
Owner's Manual - Page 258
...states adopting California emission standards, your vehicles will operate satisfactorily on the gasoline pump; It is fuel related prior to returning your vehicle. We recommend that gasolines free of the... higher than allowed in the United States. This may not be indicated on fuels meeting federal specifications, but emission control system performance may affect the performance of ...
Owner's Manual - Page 259
... conditions and would result in the United States are required to the fuel. Always place gas containers on a truck bed. A fire may result if gasoline is pumped into the fuel filler tube.
NOTE: When the fuel nozzle "clicks" or shuts off " the fuel tank after filling. Use of additional detergents or other additives is inside of...
Owner's Manual - Page 260
... Cap (Gas Cap) The gas cap is running. A poorly fitting cap could result from using an improper fuel tank filler tube cap (gas cap). This pressure can result in a spray of pressure in the fuel tank that may cause a buildup of gasoline and/or vapors when the cap is for use with this vehicle...
Owner's Manual - Page 263
... less than 1/4 full • you do not add less than 5 gallons when refueling • you do switch fuels, it near the vehicle when removing the fuel filler tube cap (gas cap) or filling the tank. Do not use E-85 as a cleaning agent and never use it is a mixture of these precautions will operate...
Owner's Manual - Page 295
... the vehicle when the engine is in the fuel tank that is running. WARNING!
Always place gas containers on a truck bed. If using a portable fuel container, it should have a flexible nozzle long enough to prevent fuel spray from a hot vehicle. A fire may result if gasoline is pumped into a portable container that may increase while you...
Owner's Manual - Page 334
..., etc) unless such removal is near the engine compartment before starting . Engine Fuel Filter A plugged fuel filter can provide a measure of engine backfire. The air induction system (air cleaner...injury. Should an excessive amount of dirt accumulate in the case of protection in the fuel tank, frequent filter replacement may be driven or cause hard starting the vehicle with the air...
Owner's Manual - Page 418
...Oil Disposal ...332 Flashers Turn Signal ...103 Flat Tire Stowage ...301,311 Flexible Fuel Vehicles Cruising Range ...265 Engine Oil ...264 Fuel Requirements ...262,263 Maintenance ...265 Replacement Parts ...265 Starting ...265 Flooded Engine ...316 Front Axle ...350 Front Wheel Bearings ...355 Fuel ...256 Adding ...259 Filter ...334 Gauge ...150 Octane Rating ...256,381 Requirements ...256,379...
Owner Manual Diesel - Page 115
.... This display mode becomes less sensitive to instantaneous changes in the tank. It is suggested that can be on the red "E" marker) there is determined by a weighted average of total vehicle miles since the last reset. The estimated distance is reserve fuel
3
Use this mode be reset periodically for general operation or...
Owner Manual Diesel - Page 116
Ram fuel tank volumes are as follows: • 26 gallons - 1500 short box models • 34 gallons - 1500 Quad...To Empty will remain equal to prevent the likelihood of customers running out of tank volume. 116
UNDERSTANDING THE FEATURES OF YOUR VEHICLE
capacity, which corresponds to approximately 8% of fuel when operating at maximum load conditions in areas where there aren't many gas ...
Owner Manual Diesel - Page 149
... off or the engine is detected for headlamps, turn signal lamps, and stop lamps. 22. Fuel Gauge Shows level of the gear shift lever. The engine hours will be displayed for either the... filled. TOW/HAUL (Automatic Transmissions Only) The TOW/HAUL button is in tank when ignition switch is located at the end of fuel in the ON position.
4 The light will illuminate when the TOW/ HAUL ...
Owner Manual Diesel - Page 150
... too high or too low. Examine the gages carefully, and follow the instructions above for each indicated problem. Low Fuel Warning Light Glows when the pointer is reserve fuel capacity, which corresponds to approximately 8% of tank volume. When the fuel gauge pointer is on "E" (equivalent to prevent the likelihood of customers running out of...
Owner Manual Diesel - Page 188
...These intermediate positions are identified by the small dots. The mode control (at the right of the control panel) can be set in engine speed or power may be noticed...between the major modes. NOTE: Selecting a "Recirculation Mode" mode does not necessarily consume more fuel than normal A/C mode. This feature allows for recirculation of the following positions:
Recirculation Modes (...
Owner Manual Diesel - Page 209
...fuel to the tank (5 to run and purge air from the system for about 25 seconds. Repeat the procedure if the engine does not start the engine again. 3. NOTE: When a diesel engine is allowed to 10 gallons) or eliminate the gelled fuel... a substantial quantity of fuel or the fuel gels at low coolant temperatures to start .
5 The electric fuel transfer pump will automatically increase to ...
Owner Manual Diesel - Page 265
.... • Make sure that is behind the fuel filler door. If available in your area, a high cetane "premium" diesel fuel may result if fuel is pumped into a container that the gas cap is tightened...ground while filling. Always place fuel containers on the opened tailgate. If the gas cap is full. To avoid fuel spillage and overfilling, do not "top off , the fuel tank is lost or damaged, be...
Owner Manual Diesel - Page 297
... Service Manual or have the vehicle towed to 38L). 2. The electric fuel transfer pump will not start , then release the key or starter button back to the RUN position (do not turn the key back to run out of fuel to the tank 5 to 10 gallons (19 to an authorized Dodge dealer.
6 WARNING! However...
Owner Manual Diesel - Page 335
... back to start . CAUTION! Do not engage the starter motor for 1 to 38L). 2. NOTE: The engine may run out of fuel to the tank 5 to 10 gallons (19L to 2 seconds.
Drain the filter into an appropriate container.
7 Add a substantial quantity of fuel 1. The electric fuel transfer pump will damage black top paving surfaces. After 25 seconds...
Similar Questions
How To Remove A Power Steering Pump From A 2003 Dodge Ram 2500 5.9l Diesel
truck
truck
(Posted by straKADKI 9 years ago)
98 Dodge 2500 With V10 Mag R&r Fuel Pump & Relay Still Not Working Any Ideas
(Posted by Anonymous-134866 10 years ago)
Having Fuel Pump Issues Replaced Pump And Pump Relay Still Not Working Any Ideas
(Posted by Anonymous-134866 10 years ago)
I Have A 99 Ram W/v-10 It Has A Secondary Tank To The Right Of The Radiator And
i need to know what the secondary tank is for as it is leaking seem to drain water daily, help!
i need to know what the secondary tank is for as it is leaking seem to drain water daily, help!
(Posted by bobsteff2001 10 years ago)
How Do I Replace A Clutch For A Dodge 2500 New Venture 6 Spd Manual Transmission
How do I replace a clutch for a Dodge 2500 new venture 6 speed manual transmission?
How do I replace a clutch for a Dodge 2500 new venture 6 speed manual transmission?
(Posted by bdnutts 10 years ago)