Home » Dodge » Technical Support » 2004 Dodge Ram 2500 Pickup

Get support for 2004 Dodge Ram 2500 Pickup

2004 Dodge Ram 2500 Pickup Support Question

Find answers below for this question about 2004 Dodge Ram 2500 Pickup.
Need a 2004 Dodge Ram 2500 Pickup manual? We have 2 online manuals for this item!

Dodge Overview Questions Manuals Reviews Videos Research

Question posted by bdnutts on March 2nd, 2014

How Do I Replace A Clutch For A Dodge 2500 New Venture 6 Spd Manual Transmission

How do I replace a clutch for a Dodge 2500 new venture 6 speed manual transmission?

I Know the Answer!

I have the same question
Request More Information

Current Answers

There are currently no answers that have been posted for this question.
Be the first to post an answer!

Remember that you can earn up to 1,100 points for every answer you submit. The better the quality of your answer, the better chance it has to be accepted.

Related Manual Pages

Owner's Manual - Page 150

...Distance To Empty [DTE] = 0 on the overhead console if so equipped) there is excessive transmission fluid temperature that there is reserve fuel capacity, which corresponds to toggle between "E" and 1/8 indication ... - 1500 short box models • 34 gallons (129L) - 2500/3500 short box models • 35 gallons (132L) - 1500/2500/3500 long box models 28. Ram fuel tank volumes are as trailer...

Owner's Manual - Page 205

... to remind you if the key is left in NEUTRAL and depress the clutch pedal to remove the ignition key. Manual Transmission Key Release Button Key Reminder An alarm will protect the starter from overheating. This vehicle is not running. Manual Transmission Apply the parking brake, place the gearshift control lever in the ignition and...

Owner's Manual - Page 213

Manual Transmission - 5-Speed NOTE: The parking brake should be fully depressed to the fluid partially draining from Park into and out of driving]. Pressing the "TOW/HAUL" button, when the transmission is sufficiently warm, will refill within five seconds of shifting from the torque converter into the transmission. This condition is not shifting into gear may...

Owner's Manual - Page 214

... clutch can result from starting from 5th to use only 1st through 4th gear ranges. Earlier upshifts during cruise conditions (steady speeds) will cause abnormal wear on a hill with your manual transmission efficiently for acceleration. To shift into Reverse. For steady highway driving with the NV3500 manual transmission. 214 STARTING AND OPERATING Manual Transmission - 5-Speed...

Owner's Manual - Page 215

..., move the shift lever to the clutch can result from a standing position when carrying a payload or towing a trailer. STARTING AND OPERATING 215 Manual Transmission Shift Speeds in MPH (KPH) Engine Model Axle...All ACCEL 15 (24) 25 (40) 40 (65) 45 (72) & CRUISE Manual Transmission - 5-Speed (NV4500) 2500 and 3500 models are equipped with light accelerations, 5th gear is recommended. For most ...

Owner's Manual - Page 216

.../h), 2nd gear is recommended to preserve brakes when driving down to a lower gear is recommended. Manual Transmission Shift Speed in the following chart. DRIVE OPERATION - IF EQUIPPED • Four-Wheel-Drive Dodge Ram Trucks are equipped with the clutch pedal partially engaged, as this section. See the operating instructions for acceleration. Shift at the right...

Owner's Manual - Page 220

... used to N (Neutral), hold foot on a manual transmission. If difficulty occurs, shift automatic transmission to alert the driver that the front axle is engaged. Several attempts may occur due to 5 km/h). Transfer Case Reminder Light The four-wheel-drive operating light (4WD), located in gear or clutch is fully engaged and all four wheels...

Owner's Manual - Page 227

... case control switch to the desired position. 4. Bring the vehicle to 5 km/h). 2. NOTE: If steps 1 or 2 of either OFF or RUNNING, shift the transmission into NEUTRAL (depress clutch on manual transmissions). Alternate Procedure 1. If the key is not ON then the shift will flash continuously while the original position indicator light is ON (not...

Owner's Manual - Page 285

... transfer case Neutral shifting procedure for your vehicle for recreational towing. Shut OFF the engine and place the ignition key to N (NEUTRAL), or depress the clutch on manual transmissions. 5. Shift automatic transmission into N (NEUTRAL). 6. It is necessary to follow these steps to be certain that there is fully in Drive (D). 10. Shift automatic...

Owner's Manual - Page 286

... OFF the engine. 3. Shift automatic transmission into P (PARK) Returning to Normal Operation - Manual Shift Transfer Case Use the following procedure to shifting the transmission into P (Park). Depress the brake pedal. 4. Shift automatic transmission to a complete stop. 2. Bring the vehicle to N (NEUTRAL), or depress the clutch on manual transmissions. 5. WARNING! You or others could...

Owner's Manual - Page 287

...key in Neutral (N) before recreational towing to prevent damage to internal parts. 1. Shift automatic transmission to be damaged. • Do not disconnect the rear driveshaft because fluid will leak from ... CAUTION! • Do not use a bumper mounted clamp-on tow bar on manual transmission. 6. The bumper face bar will be certain that the transfer case is necessary to follow these steps to...

Owner's Manual - Page 289

... (N) button. 8. key ON) are not met prior to be met until 1 second elapses and the shift has been completed. Bring vehicle to Neutral (N) or depress clutch on manual transmission. 6. Depress the brake pedal. 5. After the Neutral (N) button has been released the transfer case will shift to prepare your vehicle for 1 second. 7. If any...

Owner's Manual - Page 320

... Vacuum/Vapor Harnesses ...347 ▫ Brake System ...348 ▫ Clutch Hydraulic System ...349 ▫ Clutch Linkage ...350 ▫ Propeller Shaft Universal Joints ...350 ▫ Rear Axle And 4X4 Front Driving Axle Fluid Level ...350 ▫ Transfer Case ...351 ▫ Manual Transmission ...351 ▫ Automatic Transmission ...352 ▫ Front Wheel Bearings ...355 ▫ Selection Of...

Owner's Manual - Page 351

...added to bring the level to the bottom of the filler hole. 7 Ram 2500/3500 Model Axles DO NOT REQUIRE any limited slip oil additive (friction modifiers)....Refer to the gear lubricant. Limited-Slip Differentials in some off-highway types of differential components. Manual Transmission Fluid Level Check This fluid level can be added to Recommended Fluids, Lubricants and Genuine Parts ...

Owner's Manual - Page 382

...118 ml (4 oz.) Mopar limited slip additive. 2500/3500 Model Front and Rear Synthetic, GL-5 SAE, 75W-90. Power Steering Reservoir Mopar ATF+4, Automatic Transmission Fluid Automatic Transmission Mopar ATF+4, Automatic Transmission Fluid Transfer Case Mopar ATF+4, Automatic Transmission Fluid Manual Transmission Fluid NV 3500 Mopar "Manual Transmission Fluid" P/N 4874464. Limited-Slip 10.5/11.5 inch...

Owner Manual Diesel - Page 111

... is on the accelerator pedal to the set speed. Vehicles equipped with a 5-speed manual transmission should be set speed will result in a 1 mph (2 km/h) speed decrease. If the vehicle speed drops below the SET speed. If this happens, you would normally. Each time the button is reached, and the new speed will be operated in 4th gear under the above...

Owner Manual Diesel - Page 150

... as follows: • 34 gallons - 2500/3500 short box models • 35 gallons - 2500/3500 long box models 28. Ram fuel tank volumes are as trailer towing. Transmission Oil Temperature Warning Light (Automatic Transmissions Only) This light indicates that there is excessive transmission fluid temperature that might occur with the transmission in areas where there aren...

Owner Manual Diesel - Page 206

...crank the engine. After the bulb check is first turned to last for a manual transmission. Do not press the accelerator during starting the engine. 1. Turn the ignition key...the parking brake. 2. Shift into NEUTRAL for approximately 3 seconds. Models with manual transmission are equipped with a clutch interlocking cranking system. 206 STARTING AND OPERATING • A heated intake air...

Owner Manual Diesel - Page 222

... draining from Park into gear may result in the automatic transmission on an incline. Manual Transmission - 5-Speed (NV- 4500) - If Equipped NOTE: The parking brake should be engaged before leaving the vehicle, especially on your vehicle. 222 STARTING AND OPERATING occurs, press the "TOW/HAUL" button. A clutch within five seconds of driving]. Because the engine...

Owner Manual Diesel - Page 381

... SAE J1703 should be used. If DOT 3 brake fluid is not available, then DOT 4 is acceptable. MAINTAINING YOUR VEHICLE 381 Chassis Component Automatic Transmission Transfer Case Manual Transmission Fluid NV 4500 Manual Transmission Fluid NV 5600 Clutch Linkage Front and Rear Axle Fluid 2500/3500 Models Brake Master Cylinder Power Steering Reservoir Fluids, Lubricants and Genuine Parts.