English Manual
Page 1
Serial Number Decal TREADMILL EXERCISER User's Manual • Assembly • Operation • Maintenance • Part List and Drawing Sears, Roebuck and Co. Save this equipment. Model No. 831.21901.0 Serial No. Hoffman Estates, IL 60179 CAUTION Read all precautions and instructions in the space above for future reference. Write the serial number in this manual before using this manual for future reference.
Serial Number Decal TREADMILL EXERCISER User's Manual • Assembly • Operation • Maintenance • Part List and Drawing Sears, Roebuck and Co. Save this equipment. Model No. 831.21901.0 Serial No. Hoffman Estates, IL 60179 CAUTION Read all precautions and instructions in the space above for future reference. Write the serial number in this manual before using this manual for future reference.
English Manual
Page 2
... 3 BEFORE YOU BEGIN 5 PART IDENTIFICATION CHART 6 ASSEMBLY 7 TREADMILL OPERATION 11 HOW TO FOLD THE TREADMILL 13 TROUBLESHOOTING 14 EXERCISE GUIDELINES 15 ORDERING REPLACEMENT PARTS Back Cover 90-DAY FULL WARRANTY Back Cover WARNING DECAL PLACEMENT This drawing shows the location(s) of ICON IP, Inc. 2 If a decal is a registered trademark of the warning decal(s). Note: The decal(s) may not be shown at actual size. WESLO is missing or...
... 3 BEFORE YOU BEGIN 5 PART IDENTIFICATION CHART 6 ASSEMBLY 7 TREADMILL OPERATION 11 HOW TO FOLD THE TREADMILL 13 TROUBLESHOOTING 14 EXERCISE GUIDELINES 15 ORDERING REPLACEMENT PARTS Back Cover 90-DAY FULL WARRANTY Back Cover WARNING DECAL PLACEMENT This drawing shows the location(s) of ICON IP, Inc. 2 If a decal is a registered trademark of the warning decal(s). Note: The decal(s) may not be shown at actual size. WESLO is missing or...
English Manual
Page 3
... treadmill if the treadmill is not working properly.) 13. Always hold the handrails while using the treadmill. Do not operate the treadmill where aerosol products are used or where oxygen is being administered. 15. When folding the treadmill, make sure that all users of this manual and all parts of the treadmill regularly. 3 Athletic support clothes are adequately informed of the owner to raise or lower the treadmill...
... treadmill if the treadmill is not working properly.) 13. Always hold the handrails while using the treadmill. Do not operate the treadmill where aerosol products are used or where oxygen is being administered. 15. When folding the treadmill, make sure that all users of this manual and all parts of the treadmill regularly. 3 Athletic support clothes are adequately informed of the owner to raise or lower the treadmill...
English Manual
Page 4
Over exercising may result in use. 19. Do not place hands or feet under the treadmill while it is in serious injury or death. If you feel faint or if you experience pain while exercising, stop immediately and cool down. The roller guards must be performed by an authorized service representative only. 22. SAVE THESE INSTRUCTIONS 4 Servicing other than the procedures in this manual should be 1/8 inch from the rear roller (see the drawing on the treadmill. 21. 18. Never drop or insert any object into any opening on page 5). Adjust the roller guards, if necessary. 20.
Over exercising may result in use. 19. Do not place hands or feet under the treadmill while it is in serious injury or death. If you feel faint or if you experience pain while exercising, stop immediately and cool down. The roller guards must be performed by an authorized service representative only. 22. SAVE THESE INSTRUCTIONS 4 Servicing other than the procedures in this manual should be 1/8 inch from the rear roller (see the drawing on the treadmill. 21. 18. Never drop or insert any object into any opening on page 5). Adjust the roller guards, if necessary. 20.
English Manual
Page 5
... model number and the location of this manual. Before reading further, please familiarize yourself with the parts that are shown on the front cover of the serial number decal are labeled in . (69 cm) Console Handrail Upright Walking Belt Roller Guards Rear Roller Rear Roller Adjustment Screws 5 Hood Pin And when you have questions after reading this manual, please see the back cover of other treadmills. If you 're not exercising, the unique treadmill can be folded...
... model number and the location of this manual. Before reading further, please familiarize yourself with the parts that are shown on the front cover of the serial number decal are labeled in . (69 cm) Console Handrail Upright Walking Belt Roller Guards Rear Roller Rear Roller Adjustment Screws 5 Hood Pin And when you have questions after reading this manual, please see the back cover of other treadmills. If you 're not exercising, the unique treadmill can be folded...
English Manual
Page 6
... the PART LIST near the end of this manual. M8 Nylon Nut (2)-4 M8 Curved Washer (3)-4 M8 Washer (8)-4 M12 Washer (6)-2 M4 x 12mm Screw (9)-2 M5 x 10mm Screw (4)-2 M8 x 15mm Screw (7)-4 M12 x 40mm Screw (5)-2 M8 x 50mm Bolt (1)-4 M10 x 40mm Screw (5)-2 M10 Washer (6)-2 6 Extra parts may be included. The number following the key number is preattached. The number in the hardware kit, check to identify small parts used for assembly. PART IDENTIFICATION CHART Use...
... the PART LIST near the end of this manual. M8 Nylon Nut (2)-4 M8 Curved Washer (3)-4 M8 Washer (8)-4 M12 Washer (6)-2 M4 x 12mm Screw (9)-2 M5 x 10mm Screw (4)-2 M8 x 15mm Screw (7)-4 M12 x 40mm Screw (5)-2 M8 x 50mm Bolt (1)-4 M10 x 40mm Screw (5)-2 M10 Washer (6)-2 6 Extra parts may be included. The number following the key number is preattached. The number in the hardware kit, check to identify small parts used for assembly. PART IDENTIFICATION CHART Use...
English Manual
Page 7
...holes are on your mobile phone or smartphone. • Assembly requires two persons. • Place all assembly steps. • After shipping, there may be installed on the side shown. Attach the Right Upright (10) to the Base (12) with a soft...key one adjustable wrench To avoid damaging parts, do not use your mobile phone or smartphone to read the QR code at the right. Do not tighten the Nylon Nuts yet. 1 Attach the Left Upright (11) to the Base (12) in the same way. ASSEMBLY • To watch an assembly video, go to http://productvideo.co/ assembly/kmart/weslo or use power...
...holes are on your mobile phone or smartphone. • Assembly requires two persons. • Place all assembly steps. • After shipping, there may be installed on the side shown. Attach the Right Upright (10) to the Base (12) with a soft...key one adjustable wrench To avoid damaging parts, do not use your mobile phone or smartphone to read the QR code at the right. Do not tighten the Nylon Nuts yet. 1 Attach the Left Upright (11) to the Base (12) in the same way. ASSEMBLY • To watch an assembly video, go to http://productvideo.co/ assembly/kmart/weslo or use power...
English Manual
Page 8
Tighten an M12 x 40mm Screw (5) with two M5 x 10mm Screws (4). 34 13 14 4 4. Hold the front of the Frame (14) between the Left Upright (11) and the Right Upright (10). 2. Raise the Left Upright (11) and the Right Upright (10) to the position shown. 2 11 10 3. Attach the Hood (13) to the front of the Frame (14) with an M12 Washer (6) into each Upright and into the Frame. 5 6 10 14 6 5 8 Align the holes near the 4a front of the Frame with the upper holes shown in the 11 Uprights.
Tighten an M12 x 40mm Screw (5) with two M5 x 10mm Screws (4). 34 13 14 4 4. Hold the front of the Frame (14) between the Left Upright (11) and the Right Upright (10). 2. Raise the Left Upright (11) and the Right Upright (10) to the position shown. 2 11 10 3. Attach the Hood (13) to the front of the Frame (14) with an M12 Washer (6) into each Upright and into the Frame. 5 6 10 14 6 5 8 Align the holes near the 4a front of the Frame with the upper holes shown in the 11 Uprights.
English Manual
Page 9
.... Move the Reed Switch so that the Pin is aligned with the Reed Switch. Insert the Wires down into the Reed Switch Clip as shown. Lower the Frame (see page 13). Turn the Flywheel until the Magnet is fully inserted. Locate the Reed Switch Clip (16) attached to the Uprights (11, 10) with four M8 x 15mm Screws (7) and four M8 Washers (8). See drawing 5b. Do not fully tighten...
.... Move the Reed Switch so that the Pin is aligned with the Reed Switch. Insert the Wires down into the Reed Switch Clip as shown. Lower the Frame (see page 13). Turn the Flywheel until the Magnet is fully inserted. Locate the Reed Switch Clip (16) attached to the Uprights (11, 10) with four M8 x 15mm Screws (7) and four M8 Washers (8). See drawing 5b. Do not fully tighten...
English Manual
Page 10
... walking belt is properly tightened (see SYMPTOM 3 on page 14). 26 25 14 10. Alkaline batteries are touching the springs in the indicated location. Insert two batteries into the Adhesive Clip. Make sure that the negative (-) ends of the Frame 9 (14) in the battery clips. 7 Batteries 23 Tab 24 8. See drawing 8a. Connect the wire on the Battery Cover (24), and remove the Battery Cover. Press...
... walking belt is properly tightened (see SYMPTOM 3 on page 14). 26 25 14 10. Alkaline batteries are touching the springs in the indicated location. Insert two batteries into the Adhesive Clip. Make sure that the negative (-) ends of the Frame 9 (14) in the battery clips. 7 Batteries 23 Tab 24 8. See drawing 8a. Connect the wire on the Battery Cover (24), and remove the Battery Cover. Press...
English Manual
Page 11
The first time you use the treadmill, lubricate the walking platform (see assembly step 7 on the power, press the console button or begin walking. The console will display the SCAN Indicator Speed, Distance, Time, Odometer, and Calorie modes, for a few minutes, the power will appear. Make sure that the walking belt has moved since the batteries were changed. To select only the Speed, Distance, Time, Odometer, or Calorie mode, press the console button until only the SPEED, DIST, TIME, ODO...
The first time you use the treadmill, lubricate the walking platform (see assembly step 7 on the power, press the console button or begin walking. The console will display the SCAN Indicator Speed, Distance, Time, Odometer, and Calorie modes, for a few minutes, the power will appear. Make sure that the walking belt has moved since the batteries were changed. To select only the Speed, Distance, Time, Odometer, or Calorie mode, press the console button until only the SPEED, DIST, TIME, ODO...
English Manual
Page 12
Apply lubricant here Apply lubricant here 12 After you can, and apply half of the lubricant to spread the lubricant. Open the included lubricant packet. Reach under the other side of the walking belt as far as you have applied the lubricant, walk on the treadmill for a few minutes to the walking platform. Then, reach under one side of the walking belt and apply the remaining lubricant. LUBRICATING THE WALKING PLATFORM Before the treadmill is used, the walking platform should be lubricated.
Apply lubricant here Apply lubricant here 12 After you can, and apply half of the lubricant to spread the lubricant. Open the included lubricant packet. Reach under the other side of the walking belt as far as you have applied the lubricant, walk on the treadmill for a few minutes to the walking platform. Then, reach under one side of the walking belt and apply the remaining lubricant. LUBRICATING THE WALKING PLATFORM Before the treadmill is used, the walking platform should be lubricated.
English Manual
Page 13
... Pull out the Pin and pivot the treadmill downward a few inches. 2. Hold the treadmill firmly with both hands, and lower the treadmill to lift with 2 your left hand as shown. Then, reinsert the pin and reattach the spring clip. 1 15 14 2. Hold the treadmill securely with your legs rather than your ... Right Upright (10) and into the Frame (14) as far as it can be able to safely lift 25 pounds (11 kg) to raise or lower the treadmill. 1. Remove the Pin (15) from the right side of the treadmill. CAUTION: You must be folded to the compact storage position. Press the ...
... Pull out the Pin and pivot the treadmill downward a few inches. 2. Hold the treadmill firmly with both hands, and lower the treadmill to lift with 2 your left hand as shown. Then, reinsert the pin and reattach the spring clip. 1 15 14 2. Hold the treadmill securely with your legs rather than your ... Right Upright (10) and into the Frame (14) as far as it can be able to safely lift 25 pounds (11 kg) to raise or lower the treadmill. 1. Remove the Pin (15) from the right side of the treadmill. CAUTION: You must be folded to the compact storage position. Press the ...
English Manual
Page 14
... console (see assembly step 5 on page 10). ing belt is properly tightened. Walk on page 10). Repeat until the walking belt is overtightened, Walking Belt performance may be reduced and the walking belt may be able to turn both rear roller adjustment screws counterclockwise 1/4 of a turn . If the walk- R eplace the batteries in . Using the Screws hex key, turn both adjustment screws clockwise, 1/4 of a turn . Repeat until the walking belt is properly adjusted (see assembly step 7 on the treadmill for a few minutes. c. If the walking belt...
... console (see assembly step 5 on page 10). ing belt is properly tightened. Walk on page 10). Repeat until the walking belt is overtightened, Walking Belt performance may be reduced and the walking belt may be able to turn both rear roller adjustment screws counterclockwise 1/4 of a turn . If the walk- R eplace the batteries in . Using the Screws hex key, turn both adjustment screws clockwise, 1/4 of a turn . Repeat until the walking belt is properly adjusted (see assembly step 7 on the treadmill for a few minutes. c. If the walking belt...
English Manual
Page 15
... your exercise program. The three numbers listed above your age define your physician. Cooling Down-Finish with pre-existing health problems. These guidelines will help you may complete up increases your body temperature, heart rate, and circulation in your heart rate is near the highest number in your training zone for exercise. After a few minutes of your exercise until your heart rate is near the lowest number in...
... your exercise program. The three numbers listed above your age define your physician. Cooling Down-Finish with pre-existing health problems. These guidelines will help you may complete up increases your body temperature, heart rate, and circulation in your heart rate is near the highest number in your training zone for exercise. After a few minutes of your exercise until your heart rate is near the lowest number in...
English Manual
Page 16
... -yourself. This warranty gives you specific legal rights, and you need to state. only) www.sears.com To purchase a protection agreement (U.S.A.) or maintenance agreement (Canada) on -line for the location of purchase. This warranty does not apply when the Treadmill Exerciser is used commercially or for five (5) years from state to do-it ! For the replacement parts, accessories, and user's manuals that you may...
... -yourself. This warranty gives you specific legal rights, and you need to state. only) www.sears.com To purchase a protection agreement (U.S.A.) or maintenance agreement (Canada) on -line for the location of purchase. This warranty does not apply when the Treadmill Exerciser is used commercially or for five (5) years from state to do-it ! For the replacement parts, accessories, and user's manuals that you may...