Use and Care Guide
Page 1
KITCHENAID® Gas Sealed Burner Cooktop MODELS KGCR055G KGCT055G KGCS105G KGCS127G KGCS166G KGCT305G KGCT365G KGCT366G 3191828 www.kitchenaid.com Use and Care Guide Table of Contents...2 A Note to You...2 Cooktop Safety ...3 Using Your Cooktop ...5 Caring For Your Cooktop...13 Troubleshooting ...17 Requesting Assistance or Service...18 Warranty...20 For assistance or service in Canada, see page 19. For assistance or service in the U.S.A., call the Consumer Assistance Center.
KITCHENAID® Gas Sealed Burner Cooktop MODELS KGCR055G KGCT055G KGCS105G KGCS127G KGCS166G KGCT305G KGCT365G KGCT366G 3191828 www.kitchenaid.com Use and Care Guide Table of Contents...2 A Note to You...2 Cooktop Safety ...3 Using Your Cooktop ...5 Caring For Your Cooktop...13 Troubleshooting ...17 Requesting Assistance or Service...18 Warranty...20 For assistance or service in Canada, see page 19. For assistance or service in the U.S.A., call the Consumer Assistance Center.
Use and Care Guide
Page 5
... service technician. Gas Conversion Kit is factory-set for illustration) 5 NOTE: The middle grate must always face inward toward the control knobs to use with an electric ignition system. gas, an L.P. The sealed burners spread the heat evenly across the bottom of the cooktop contain grooves. Using Your Cooktop Using the surface burners Your cooktop has sealed gas burners with Natural...
... service technician. Gas Conversion Kit is factory-set for illustration) 5 NOTE: The middle grate must always face inward toward the control knobs to use with an electric ignition system. gas, an L.P. The sealed burners spread the heat evenly across the bottom of the cooktop contain grooves. Using Your Cooktop Using the surface burners Your cooktop has sealed gas burners with Natural...
Use and Care Guide
Page 15
... light properly. Cast-iron burner cap er caps. Always clean the burner caps after a spillover. Ignitor Burner base • Occasionally check the burner flames for Your Cooktop Sealed surface burners and cooktop Cleaning the surface burners • You should routinely remove and clean the burn- Gas tube opening for the burner to spill liquids through the gas tube opening 15 ALWAYS keep...
... light properly. Cast-iron burner cap er caps. Always clean the burner caps after a spillover. Ignitor Burner base • Occasionally check the burner flames for Your Cooktop Sealed surface burners and cooktop Cleaning the surface burners • You should routinely remove and clean the burn- Gas tube opening for the burner to spill liquids through the gas tube opening 15 ALWAYS keep...
Use and Care Guide
Page 16
... KitchenAid service technician. After cleaning the gas tube opening has become soiled or clogged, use a wooden toothpick. If the gas tube opening and ports, replace the burner caps. To replace the burner caps, make sure the alignment pins on the burner to be adjusted, call a qualified technician for Your Cooktop Sealed surface burners and cooktop To clean the burners: 1. If the burner...
... KitchenAid service technician. After cleaning the gas tube opening has become soiled or clogged, use a wooden toothpick. If the gas tube opening and ports, replace the burner caps. To replace the burner caps, make sure the alignment pins on the burner to be adjusted, call a qualified technician for Your Cooktop Sealed surface burners and cooktop To clean the burners: 1. If the burner...
Use and Care Guide
Page 17
...voltage. (See installation instructions.) • Contact an authorized KitchenAid service technician to reconnect the cooktop to the cooktop is not the correct type or size. • The flame size does not fit the cookware being washed. • The burner ports may be clogged. • Clean them with ...; Replace household fuse or reset circuit breaker. • Push in Canada). The burner flames lift off . • The burner needs cleaning. • The air/gas mixture is not set correctly. The burner fails to a reliable cookbook for recommended pan type and size. • Pan ...
...voltage. (See installation instructions.) • Contact an authorized KitchenAid service technician to reconnect the cooktop to the cooktop is not the correct type or size. • The flame size does not fit the cookware being washed. • The burner ports may be clogged. • Clean them with ...; Replace household fuse or reset circuit breaker. • Push in Canada). The burner flames lift off . • The burner needs cleaning. • The air/gas mixture is not set correctly. The burner fails to a reliable cookbook for recommended pan type and size. • Pan ...
Use and Care Guide
Page 20
...the exclusion or limitation of incidental or consequential damages, so this book. KitchenAid Canada licensee in Canada 8/98 Printed in materials or workmanship. Replacement parts for any gas burner to province. Correct the installation of God, improper installation, or installation not...Troubleshooting," additional help can be repaired in remote areas. In the U.S.A., call KitchenAid Canada at 1-800-422-1230. In Canada, call our Consumer Assistance Center at one of KitchenAid, U.S.A. Gas Cooktop Warranty LENGTH OF WARRANTY: ONE-YEAR FULL WARRANTY FROM DATE OF PURCHASE. E....
...the exclusion or limitation of incidental or consequential damages, so this book. KitchenAid Canada licensee in Canada 8/98 Printed in materials or workmanship. Replacement parts for any gas burner to province. Correct the installation of God, improper installation, or installation not...Troubleshooting," additional help can be repaired in remote areas. In the U.S.A., call KitchenAid Canada at 1-800-422-1230. In Canada, call our Consumer Assistance Center at one of KitchenAid, U.S.A. Gas Cooktop Warranty LENGTH OF WARRANTY: ONE-YEAR FULL WARRANTY FROM DATE OF PURCHASE. E....
Installation Instructions
Page 1
Homeowner: Keep Installation Instructions for local electrical inspector's use. Installation Instructions Gas Built-in Cooktops 15" (38.1 cm) 15" (38.1 cm) 30" (76.2 cm) 30" (76.2 cm) 21" (53.3 cm) 2-7/8" (7.3 cm) 21" (53.3 cm) 2-7/8" (7.3 cm) 36" (91.4 cm) 36" (91.4 cm) 21" (53.3 ...and serial numbers before installing cooktop. Save Installation Instructions for future reference. B IMPORTANT: Installer: Leave Installation Instructions with the homeowner. Both numbers are on the model/serial rating plate, located on the underside of the cooktop burner box. Model Serial Part No...
Homeowner: Keep Installation Instructions for local electrical inspector's use. Installation Instructions Gas Built-in Cooktops 15" (38.1 cm) 15" (38.1 cm) 30" (76.2 cm) 30" (76.2 cm) 21" (53.3 cm) 2-7/8" (7.3 cm) 21" (53.3 cm) 2-7/8" (7.3 cm) 36" (91.4 cm) 36" (91.4 cm) 21" (53.3 ...and serial numbers before installing cooktop. Save Installation Instructions for future reference. B IMPORTANT: Installer: Leave Installation Instructions with the homeowner. Both numbers are on the model/serial rating plate, located on the underside of the cooktop burner box. Model Serial Part No...
Installation Instructions
Page 2
... or use any other appliance. - WHAT TO DO IF YOU SMELL GAS • Do not try to be installed must be sealed. Note: This cooktop is not followed exactly, a fire or explosion may be available. See "Gas supply requirements," Page 4. Make sure you don't follow instructions. When installing... manual and on the underside of the installer to potential hazards that electrical installation is required. It is the responsibility of the cooktop burner box. These words mean: DANGER You can be killed or seriously injured if you and others are not followed. To convert ...
... or use any other appliance. - WHAT TO DO IF YOU SMELL GAS • Do not try to be installed must be sealed. Note: This cooktop is not followed exactly, a fire or explosion may be available. See "Gas supply requirements," Page 4. Make sure you don't follow instructions. When installing... manual and on the underside of the installer to potential hazards that electrical installation is required. It is the responsibility of the cooktop burner box. These words mean: DANGER You can be killed or seriously injured if you and others are not followed. To convert ...
Installation Instructions
Page 3
...The drawer depth may need to be used. or when such standard is required Gas line opening dimensions that are shown must be shortened to avoid interfering with the regulator. 3 Cooktop width 15" (38.1 cm) 30" (76.2 cm) 36" (91.4 cm) 43" (109.2 cm) ... recommended upper cabinet depth Ấ ạ Do not seal cooktop to combustible surface above countertop Ấ 2-7/8" (7.3 cm) ấ 5-5/8" (14.3 cm) 2-7/8" 5-5/8" (7.3 cm) (14.3 cm) 2-7/8" 5-5/8" (7.3 cm) (14.3 cm) 2-7/8" 11-1/2" (7.3 cm) (28.4 cm) Base cabinet size: Cooktop Size 15" (38.1 cm) 30" (76.2 cm) 36" (91.4 cm) 43"...
...The drawer depth may need to be used. or when such standard is required Gas line opening dimensions that are shown must be shortened to avoid interfering with the regulator. 3 Cooktop width 15" (38.1 cm) 30" (76.2 cm) 36" (91.4 cm) 43" (109.2 cm) ... recommended upper cabinet depth Ấ ạ Do not seal cooktop to combustible surface above countertop Ấ 2-7/8" (7.3 cm) ấ 5-5/8" (14.3 cm) 2-7/8" 5-5/8" (7.3 cm) (14.3 cm) 2-7/8" 5-5/8" (7.3 cm) (14.3 cm) 2-7/8" 11-1/2" (7.3 cm) (28.4 cm) Base cabinet size: Cooktop Size 15" (38.1 cm) 30" (76.2 cm) 36" (91.4 cm) 43"...
Installation Instructions
Page 4
...Do Not block access to do so can be used to obtain an in the same room as the cooktop and should be as a gas supply line, a combination of the burner box, has information on or shutting off valve. G.If rigid pipe is for operation and checking the ...regulator setting: NATURAL GAS: Set pressure 4 inches (10.2 cm). H.The regulator must be used . Supply pressure 7-14 inches (17.8 cm to cooktop gas supply F. Do not use with the local gas supplier. A ...
...Do Not block access to do so can be used to obtain an in the same room as the cooktop and should be as a gas supply line, a combination of the burner box, has information on or shutting off valve. G.If rigid pipe is for operation and checking the ...regulator setting: NATURAL GAS: Set pressure 4 inches (10.2 cm). H.The regulator must be used . Supply pressure 7-14 inches (17.8 cm to cooktop gas supply F. Do not use with the local gas supplier. A ...
Installation Instructions
Page 6
...into the hollow valve stem and engage the slotted screw. You will indicate a leak. initial lighting Cooktop burners use electronic igniters in place of cooktop pressure regulator gas-flow arrow pointing up toward unit and in a position where you can quickly turn each control knob.... 10.Use pipe-joint compound made for gas to tighten clamping screws against the underside of the cooktop burners. Install the pressure regulator with NATURAL and L.P. Leak testing of each burner base. Bubbles around connections will need to cooktop gas supply line 11.Open shutoff valve in the...
...into the hollow valve stem and engage the slotted screw. You will indicate a leak. initial lighting Cooktop burners use electronic igniters in place of cooktop pressure regulator gas-flow arrow pointing up toward unit and in a position where you can quickly turn each control knob.... 10.Use pipe-joint compound made for gas to tighten clamping screws against the underside of the cooktop burners. Install the pressure regulator with NATURAL and L.P. Leak testing of each burner base. Bubbles around connections will need to cooktop gas supply line 11.Open shutoff valve in the...
Installation Instructions
Page 7
... from whom you will need service: Maintain the quality built into the outlet. Check that gas valves are listed on the model/serial rating plate located on the right and left side of cooktop burner box. Household - If cooktop does not operate: Check that the circuit breaker is not tripped or the house fuse...
... from whom you will need service: Maintain the quality built into the outlet. Check that gas valves are listed on the model/serial rating plate located on the right and left side of cooktop burner box. Household - If cooktop does not operate: Check that the circuit breaker is not tripped or the house fuse...