Honeywell HM509VPIAQ - TrueSTEAM 9 GPD Humidifier PRO IAQ Support and Manuals
Get Help and Manuals for this Honeywell item
View All Support Options Below
Free Honeywell HM509VPIAQ manuals!
Problems with Honeywell HM509VPIAQ?
Ask a Question
Free Honeywell HM509VPIAQ manuals!
Problems with Honeywell HM509VPIAQ?
Ask a Question
Most Recent Honeywell HM509VPIAQ Questions
Two Red Blinking Lights On Service Button For Hm509 What Does This Mean
(Posted by Anonymous-146860 9 years ago)
Popular Honeywell HM509VPIAQ Manual Pages
Owners Guide - Page 3
..., press the Reset button.
• Mount the provided yellow tank service sticker on , indicating steam is being generated.
• Test the drain by addressing these commonly...install a 6 gallon device in a home larger than 2000 square feet.
Check that the main water supply line is critical: The table below illustrates the square footage a TrueSTEAM humidifier can serve. True 6 Gallons...
Owners Guide - Page 4
... are not achieved, then a larger capacity model may be blinking due to a low voltage condition in the home, depending on heating costs.
69-2036EFS-07
If the homeowner sees that TrueSTEAM is not humidifying but there is a call service light may be needed. Installation Guide
Installation Recommendations
Setting Homeowner Expectations for the TrueSTEAM Experience: It may take up to...
Owners Guide - Page 6
... humidifier where the ambient temperature is not possible, the steam nozzle should be very hot. Installation Guide
Safety Precautions
CAUTION: Voltage Hazard. If that is designed to allow clearance if the top of 12 in a level position for safe, reliable operation. x 6 in.) with a duct board adapter kit (part #32005530-001).
• Do not install in completely...
Owners Guide - Page 7
.... Model HM506 HM509 HM512
M24745
Required Minimum Circuit Capacity 7 Amps 10 Amps 12 Amps
CAUTION Hot water temperature above 120°F (49°C) can cause burns from the duct, follow steps on pages 7-18. Continuous downslope
Draining water may be hot.
Ensure o-ring gasket is properly seated in . TrueSTEAM Humidification System
If installing the humidifier...
Owners Guide - Page 9
... ./ft. When remote mounting, also follow these critical steps in back pressure on page 10). ID x 1/2 in . The 6-gallon model (HM506) can result in sizing the proper TrueSTEAM:
If the steam distribution tube is going into the humidifier. TrueSTEAM Humidification System
Remote mount installation
Use for mounting to prevent sagging or low spots.
uphill
6 in. 8 in.
1/2 in .
Owners Guide - Page 15
...T-fitting
Manual shutoff valve (sold separately)
Saddle valve (provided)
Piercing pin
To humidifier
M24852
To humidifier
Water supply line
Check all water line connections to ensure no leaks once TrueSTEAM is ... valve (included) (required)
Part Number 50028044-001
50030142-001
To water supply
A
B
1/4-in .
Water line tapping options. See instructions provided with hose clamp. copper...
Owners Guide - Page 19
...humidifier.
If not pushed, TrueSTEAM will take about 10-15 minutes upon call for 10-15 minutes, check the integrity of the remote hose to ready the TrueSTEAM. If the "Test" position is applied. Add or adjust clamps if necessary to ready after five minutes. Important for Remote Installation:
After TrueSTEAM has produced steam...POWER
HUMIDIFYING
CLEAN TANK SEE LABEL BELOW ! CALL SERVICE
...
Owners Guide - Page 20
...4 and 5 can be allowed to humidify ON without airflow.
it is time to manually clean the
OFF
water tank.
it is time to manually clean the
OFF
water tank. Empty light...4 OFF, DIP 5 OFF: TrueSTEAM will shut down OFF steam output and activate a service light.
*Requires installation of DIP switches. ON DIP 4 ON, DIP 5 either setting: TrueSTEAM will blink, indicating
ON from tank...
Owners Guide - Page 21
... Call Service LED light will attempt to recover itself up to Fix To be Performed by itself 5 times the metal is cool).
• Follow tank cleaning instructions on ...button to clear the Service Timer light (i.e. exists in and press the RESET button.
• If fault reappears, replace sensor assembly. TrueSTEAM Humidification System
Troubleshooting
TrueSTEAM has internal system diagnostics...
Owners Guide - Page 22
...Installation Guide
Troubleshooting
No.
exists in 1 hour.
• Follow tank cleaning steps (pages 23-26). • Reassemble tank and press the RESET button. • If fault returns, replace with a new one (field
service... EMPTY button to drain tank. • Set humidistat RH setpoint to Test mode. • If fault returns, unplug TrueSTEAM. • Loosen cover screw and remove cover...
Owners Guide - Page 23
...humidity call starts by HUMIDIFYING light turning on. ...steam is installed and wired
correctly. Yes
• Replace the unit.
• Ensure ventilation holes in the cover are set correctly. • If fault persists, replace AFS and/or unit.
21
69-2036EFS-07 Temperature of Red Light Blinks 8-11 12
13
14 15
Fault Description AutoRecoverable?
TrueSTEAM Humidification System
Troubleshooting...
Owners Guide - Page 24
...hours of the Canadian Electrical Code (CEC), Part 1, C22.1.
69-2036EFS-07
22 HM509: 1200W at 120VAC at 24VAC...186;C) before draining.
• During manual flush (performed by pressing the EMPTY button...Installation Guide
Specifications
Capacity: HM512: 12 gallons per day (gpd) (45 liters per day [lpd]) HM509: 9 gpd (34 lpd) HM506: 6 gpd (23 lpd)
Humidified Area:
House
Air Changes HM512 HM509...
Owners Guide - Page 25
... before draining. • During manual flush (performed by pressing the EMPTY button) initial water temperature may
be above 140°F (60°C).
TrueSTEAM Humidification System
Cleaning and Seasonal or...the EMPTY button, and do NOT attempt to remove the humidifier from the mounting bracket during operation, or when the humidifier's water tank when full of operational time (heating element
...
Owners Guide - Page 26
...M24777
M24779
4.
Turn the manual shut-off humidifier with tank.
5. Push... down the cover's safety button and pull the latch forward to disengage from the tank.
Tank is removable. Scouring pads suitable for non-stick pots or pans are suitable for cleaning the TrueSTEAM... grip the tank bottom. Installation Guide
Cleaning and Seasonal or Vacation...
Owners Guide - Page 28
Installation Guide
Cleaning and Seasonal or Vacation Maintenance
Automatic End of inactivity, TrueSTEAM will refill with water upon next humidity call. The tank will drain and remain ... on page 23 at peak efficiency: 1. After 48 hours of Season Shutdown Your TrueSTEAM humidifier has the built-in the humidifier's cover. 3. Extended Vacation When you turn off the humidity control.
Honeywell HM509VPIAQ Reviews
We have not received any reviews for Honeywell yet.