Hayward W3AQR15 Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward W3AQR15 manuals!
Problems with Hayward W3AQR15?
Ask a Question
Free Hayward W3AQR15 manuals!
Problems with Hayward W3AQR15?
Ask a Question
Hayward W3AQR15 Videos
Hayward W3AQR15 AquaRite Complete Salt System for Pools up to 40,000 Review
Duration: 3:25
Total Views: 1,122
Duration: 3:25
Total Views: 1,122
Popular Hayward W3AQR15 Manual Pages
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 1
092540 RevG
AquaRite®
Electronic Chlorine Generator
Owner's Manual
Contents
Operation 2 Installation 11 Troubleshooting 15 Warranty 18
W3AQR15 W3AQR9 W3AQR3
Certified to NSF/ANSI Standard 50
Hayward Industries 400 Connell Drive, Suite 6100
Berkeley Heights, NJ 07922 Phone: (908) 355-7995 www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 2
... during installation.
• WARNING - The use of an untested, uncertified generic cells (or generic circuit boards) with a continuous copper wire equivalent in the electric supply service panel with Genuine Hayward salt chlorination products could lead to premature product failure.
• Pursuant to the terms and conditions of a non-genuine Hayward replacement salt chlorination cell...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 3
.... The actual amount of salt (sodium chloride) in the pool water. NOTE: The use of stone used around a saline pool with fresh water.
Operation
The AquaRite® is not commonly diluted with electronic chlorine generator in your chlorinator cell.
2
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The AquaRite automatically sanitizes your pool (installation and mounting requirements are low...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 4
... 0.2 or more, stains may occur.
-0.2
Corrosion
0.2
Stain
Ok
3
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS If the Si is above . If the Si is below to determine the saturation index...are using an AquaRite chlorine generator. Use the chart below -0.2, the water is an indicator of Pool and Spa Professionals (APSP). Test your water periodically. CHEMICAL Salt Free Chlorine pH Total ...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 5
... to raise the level to pile up the dissolving process--do not allow salt to 30 ppm.
4
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The ideal salt level is also acceptable to use of about 3500-4000 ppm). A high salt level can cause the AquaRite to shutdown and may begin to give a salty taste to your pool (generally...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 8
... during this position the AquaRite will produce chlorine according to the "Desired Output %" adjustment setting for the entire filtering/pumping cycle. SUPER CHLORINATE Illuminates during normal operation. A flashing LED indicates a 15-60 second time delay period.
Inspect, clean or replace if necessary.
7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
REMOTELY CONTROLLED When illuminated...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 9
... from "Auto" to "Super Chlorinate" and
back to display in Metric units. To change while the Salt Display (average salt level) may
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS The factory default display is in English units (ppm). Slide the Main Switch from "Off" to control the amount of the pool water. Your model AquaRite has been packaged with...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 10
... HAYWARD GENUINE REPLACEMENT PARTS Slide the Main Switch from "Auto" to "Super Chlorinate" and back to a pool automation control (Hayward Pro Logic, Pentair Intellitouch or Polaris Eos): The AquaRite is activated. the amount of the AquaRite chlorinator in the pool
The filter pump timer should only take minor, infrequent adjustments. NOTE: After the ideal "Desired Output %" setting...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 13
... AquaRite must be shut off at least a 12" (25cm) straight pipe run before performing any wiring. Wiring
Power must be plumbed into 2" (51mm) PVC pipe. Flow Switch
Electrolytic Cell
12" min
3 Way Valve
POOL
SPA
Flow Switch: Electrolytic Cell:
IMPORTANT: There must be properly grounded and bonded.
12 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 14
...Canadian. For Canadian models, the AquaRite shall be used for US installations and both for cell cable
Bonding lugs to pool bonding system
13 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Be sure to connect... grid in 240VAC position.
Input Power For stand alone operation:
W3AQR15, W3AQR9, W3AQR3 - The AquaRite is shipped from the factory with an insulated or bare copper conductor not smaller ...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 16
... there is connected to the proper screw termi- The AquaRite is protected by switching
the main switch to SUPER CHLORINATE.
Troubleshooting
Visit www.hayward.com for 30 seconds, the display will revert back to the standard salt display. Cell voltage (xx.x volts) 3. tion controller) 5.
"Check Salt" LED illuminated or flashing
Be sure that the arrows on...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 17
..." button for scale. AquaRite switch in
the directions on ).
- Filter pump time too short (8 hours for average size pools, more for
service.
16 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Inspect and clean cell according to
"normal" and chlorine tests will use chlorine
at recommended levels.
6. If the pool has the proper amount of salt and the "Inspect Cell...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 18
...Holder Kit Salt Cell Cleaning Stand Salt Cell Union (Tailpiece, Nut and O-Ring) Salt Cell Placeholder Handheld Digital Salt Meter Display Standoff (20 pack)
17 USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Replacement Parts
Refer to the table below as well as the product page at www.hayward-pool.com for information on the latest replacement parts and accessories for AquaRite chlorine generators.
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 19
... such costs incurred in obtaining warranty replacements or repair. Proof of these warranties is required for warranty service. This warranty gives you specific legal rights, and you may not apply to you. Each of purchase is not transferable and applies only to the original owner. Use of a non-genuine Hayward replacement salt chlorination cell on private residential swimming...
AquaRite-Electronic-Chlorine-Generator-Owners-Manual-092540RevG - Page 21
AquaRite ®
Générateur de chlore électronique
Guide d'utilisation
Contents
Fonctionnement 2 Installation 11 Dépannage 15 Warranty 18
W3AQR15 W3AQR9 W3AQR3
Certified to NSF/ANSI Standard 50
Hayward Industries 400 Connell Drive, Suite 6100
Berkeley Heights, NJ 07922 Phone: (908) 355-7995 www.hayward.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Hayward W3AQR15 Reviews
We have not received any reviews for Hayward yet.