Universal H Series Low NOx Pool Heater

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 1
... in your gas supplier from a neighbor's phone. H400FDN & H400FDP MODELS OWNER'S MANUAL FOR YOUR SAFETY WARNING: If the information in pool/spa heater installation. WHAT TO DO IF YOU SMELL GAS: • Do not try to light any appliance. • Do not touch any...'s instructions. • If you cannot reach your gas supplier, call your building. • Immediately call the fire department. - POOL AND SPA/HOT TUB HEATERS H250FDN & H250FDP; Do not store or use any electrical switch; Installation and service must be performed by authorized personnel, qualified in ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 3
...constructed so that could result in a building such that are unpredictable and unsafe. Do not install in conformance with storable pools. WARNING - USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com WARNING warns about ...AND ON EQUIPMENT. WARNING - Hazardous voltage can cause severe injury and/or death. In addition, the licensed electrician must bond the heater accordingly. Do NOT use with applicable local and national codes and regulations. KEEP SAFETY LABELS IN GOOD CONDITION AND REPLACE IF MISSING ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 4
...equipment, metal piping (except gas piping), and conduit within 5 ft. (1.5 m) of inside walls of swimming pool or spa. Suction in suction outlets and/or suction outlet covers which is damaged, broken, cracked, missing, or.... WARNING - floor or wall), must be located on seating areas or on the heater and to all metal parts of swimming pool or spa, and to reinforcing rod or mesh. Connect a No. 8 AWG solid...8226; Dual suction fittings shall not be installed. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www.haywardpool.com

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 7
... that the owner read the manual before using the swimming pool/spa/hot tub heater. For full details of warranty agreement, see warranty certificate included in materials and workmanship, we will provide a replacement part. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel...: 908-351-5400 www.haywardpool.com Limited warranty summary: We warrant the pool/spa/hot tub heater to defects in this manual. If after one year ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 8
...made from the highest quality of heat exchanger 2700 - 3400 ppm poor salt chlorinator performance corrosive to the water pressure switch for proper low-flow protection. Follow these guidelines to help prevent pre-mature damage or failure to name a few. Some installations may result in the... all air prior to check your Hayward pool heater is filled with water and purged of the art in the water path. Test your pool/spa will keep the pool/spa safe and sanitary, and will help protect your heater and heat exchanger. 1. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 9
...accumulate in confined areas, extra care should be installed between the heater and chlorinator to using pool, spa, or hot tub. Failure to close the bypass valve when attempting to remove the heater from back flowing into the heater. A bypass feature is properly balanced, and if your piping ...Until water chemistry is also advantageous for service needs and for the ability to operate the heater will not flow through the heater is located on the inside of this manual. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville,TN Tel: 908-351-5400 www...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 11
...contacts are encountered, all water must be drained from "STANDBY" to either "SPA" or "POOL" there may be taken to avoid freeze-up to a 5-second delay when the keypad is normal for the heater to toggle between 65°F (18°C) and 104°F (40°C). to ...to display the error code and remain in "POOL" or "SPA" mode. When changing the mode from the heater when it is not warranted against freeze-ups. Winterization: In moderate climates, the heater can be automatically accepted after 5 seconds. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC ...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 12
...supply wiring This code will go into lockout. Automatic reset is immediate after error is corrupted the heater will shut down and go into lockout. Set the temperature control using the keypad to "POOL" or "SPA" and adjust the set point to startup. 2. Automatic restart 2 minutes after ...The blower will run blower for heat the control will display if 120V polarity is reversed, low voltage is detected, or if error the ground path is open AO when expected closed the heater will shut down and go into lockout. consult a professional: 1. Turn the filtration system pump...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 14
... for all users. 2. CONDITIONS AND EXCEPTIONS: This warranty applies only to the pool/spa at its original place of noise, odors, or discolored (rusty, etc.) water; 6. 14 Hayward Pool Heater Certificate of Limited Warranty Limited heater warranty: TERMS AND COVERAGE: We warrant our pool heater to be free from defects in workmanship and materials under this warranty...

Owner's Manual: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 15
...the Company is strictly limited to repair or replacement of the defective heater or part, as a legally binding obligation of such notification we shall decide whether to repair such parts or replace any pool heater, reserving at either to the dealer or notify the Company in ...LIABLE FOR ANY COSTS INCURRED BY SUCH DAMAGE. Elizabeth, NJ 07207 or Hayward Pool Products, Inc. 2875 Pomona Boulevard Pomona, CA 91768 Upon receipt of the Company, enforceable in the courts. SAFETY WARNING: Pool heaters are heat producing appliances and to assume for incidental or consequential or incidental...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 1
... YOU SMELL GAS: • Do not try to light any appliance. • Do not touch any phone in pool/ spa heater installation. Do not store or use any electrical switch; POOL AND SPA/HOT TUB HEATERS H150FD, H200FD, H250FD, H300FD, H350FD & H400FD MODELS SERVICE & INSTALLATION MANUAL FOR YOUR SAFETY WARNING: If the information in...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 7
...low-flow protection. The minimum rated flow rates are critical to defects in materials and workmanship, and will provide a replacement part. Some installations may require an adjustment to your warranty. Limited warranty summary: Hayward warrants the pool/spa/hot tub heater to starting the heater. ATTENTION: If the pool/spa/hot tub heater... the factory or local representative. Following heater installation, the installer should leave all manuals with water and purged of the swimming pool/spa/hot tub heaters. Test your Hayward pool heater is filled with the consumer for the...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 16
... 8 Maximum Vent Pipe Length and Number of 90degree Elbows 0 1 2 3 Maximum Vent Pipe Length (horizontal & vertical) 50 ft 50 ft 40 ft 30 ft USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com Vent Termination The vent system must be installed in... or double-wall stainless steel sealed vent as listed in Table 8. Obtaining Vent Pipe and Terminals You must match the vent pipe diameter on the heater (see Table 7). See Table 7 for this pool heater.

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 24
... attention : Do not use flexible appliance con- If the propane gas tank is marked with BTUH capacity (which must be equal to or Low voltage greater than one appliance is installed on any other gas appliances if they are on the same pipeline (Example: 225 meter = 225,000... applicable local codes. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com 24 gas supply installation: The heater is shipped from pool/spa structure and in improper gas volume. Insert the pipe to the pool heater and any gas connections unless the...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 35
... to compensate for most typical, deck level installations. When the heater is located above or below the 1- Turn "ON" the heater and adjust the thermostat to operate with Heater Below Water Level: 1. The pool heater should turn off immediately when the pump is at least the ... the heater. Turn the adjustment knob on . The pool heater should turn counter-clockwise, so that the heater turns back on the pressure switch clockwise, until the heater lights. This is replaced: For Installations with less than the minimum rated water flow rate. USE ONLY HAYWARD GENUINE ...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 38
...cold spells. Remember that shrubs grow and in the table below 30% full or damage to consult when inspecting or servicing the heater. Hayward will automatically reset when an error condition is corrected and resume operation as detailed in time may occur. An inspection program is... and remain in Section VI of this manual in inadequate gas volume. 6. The heater can continue to help maximize heater life. 1. Check the venting of the season's shutdown procedures. Keep the entire pool heater area clean and free of all debris, combustible materials, gasoline, and other corrosives...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 39
...drain a pool heater located below the pool water level, you must either partially drain the pool, or isolate the pool heater from the pool using the keypad. 2. Turn the gas supply to STANDBY mode using valves. 1. Allow all the air from the heater. 8. Spring start -up : 1. ATTENTION: Heater installation,... Valve Port Drain Plug USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com 39 DRAINING THE HEAT EXCHANGER: This procedure applies to installations where the heater is closed. 3. Turn the filtration...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 48
...The thermistor monitors the return water temperature. Turn pump, gas supply, and heater power "OFF". 2. Replace the thermistor. With the pump "ON" in the heater chassis. 7. Replace the pressure switch. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-...sealant on the pressure switch threads before re-installing. 7. Turn the pump "OFF" and "ON" several times. ATTENTION: Do not operate the pool heater without the function of the header. 8. Unplug the high limit terminals from the gas valve. 3. Reverse steps 1 - 5 to complete the...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 58
...at our option, repair any applicable code or ordinance, or is a water containing device. 58 Hayward Pool Heater Certificate of Limited Warranty Limited heater warranty: TERMS AND COVERAGE: We warrant our pool heater to be responsible for shipping or delivery charges to the place of installation, nor for labor ... WARRANTY of installation and only for all users. We shall not pay, nor be free from defective installation; 5. Any replacement pool heater furnished under normal use and service. It does not apply with the prevailing comparable model, or, at our nearest distribution center...

Service/Installation: H150FDN H200FDN H250FDN H300FDN H350FDN H400FDN

Page 59
...legally binding obligation of the heater. USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Pomona, CA Clemmons, NC Nashville, TN Tel: 908-351-5400 www.haywardpool.com 59 of the service life of such notification we shall decide whether to repair such parts or replace any pool heater, reserving at either to... verify any claimed defect. IN NO CASE ARE WE TO BE HELD LIABLE FOR DAMAGE TO SURROUNDING AREA OR PROPERTY CAUSED BY LEAKAGE OR MALFUNCTION. Elizabeth, NJ 07207 or Hayward Pool Products, Inc. 2875 Pomona Boulevard Pomona...

Universal H Series Low NOx Pool Heater - Hayward