Hayward Pool Vac Classic™ Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward Pool Vac Classic™ manuals!
Problems with Hayward Pool Vac Classic™?
Ask a Question
Free Hayward Pool Vac Classic™ manuals!
Problems with Hayward Pool Vac Classic™?
Ask a Question
Popular Hayward Pool Vac Classic™ Manual Pages
Pool Vac Classic - Page 2
... Date
2) Serial Number
Pool Vac XL Navigator Pro
LIMITED
WARRANTY
Pool Vac Classic
LIMITED
WARRANTY
Note
Hayward Turbine Cleaners should be relative to that a "service call Hayward at the consumer's expense. Hayward Turbine Cleaners are powered by your in your pool will be necessary to your Cleaner.
On those occasions, where your pool is an installation related call, it...
Pool Vac Classic - Page 3
To prepare your Cleaner will walk you some maintenance and trouble-shooting hints. After reading these instructions, the "How To" installation DVD (included with a hose cuff are connector hoses (9 with PV XL & NAV PRO, 7 with PV Classic) and one leader hose with Pool Vac XL & Navigator Pro only) will not operate properly. Make sure that the water...
Pool Vac Classic - Page 4
... connecting the hose to Important Tips for PV Classic. Then, insert the cone into the suction port of the vacuum hose if you are using the cone. (Refer to your Hayward dealer. Step 4 The hose should reach from your skimmer. Installation
INSTALLING YOUR HAYWARD CLEANER IS SIMPLE... Make sure the Flow Gauge is more specific skimmer information.)
2
Pool Vac Classic - Page 6
... the cleaner is too low to meet the water flow setting necessary to mark the valve gauge, or if replacement of the leader hose to the Cleaner and submerge the hose to "sink" the Cleaner hose, as when vacuuming the pool with the cleaner. Installation
INSTALLING YOUR HAYWARD CLEANER IS SIMPLE...
If you are ready to INCREASE...
Pool Vac Classic - Page 7
... the return line water flow downward.
Your Cleaner will be on the walls. Installation
INSTALLING YOUR HAYWARD CLEANER IS SIMPLE... This is at least a seven inch (7") radius where the walls and floor meet. Step 9 Observe your Cleaner in concrete and fiberglass swimming pools if there is to allow the Cleaner to move about the...
Pool Vac Classic - Page 8
...the filter system and most likely will still climb the walls. Three basic types are not covered under the Hayward warranty. There might be sure to these walls. Due to the shape (severe angles) of in-ground or... holes in the skimmer, exposing the holes. Turbine Suction Cleaners
IMPORTANT TIPS
Pool Vac XL/Navigator Pro In one hole in the bottom. DO NOT COIL HOSE When storing your...
Pool Vac Classic - Page 9
... Flow Gauge by turning the valve toward main drain suction. Skimmer, Skimmer Vac Plate Vac Lock, etc.) 4. Remember, too much vacuum is securely attached to its hose are going to super chlorinate, shock, ...in handle. Do not carry it by the molded-in the bottom of the pool, always disconnect the leader hose from the water. 9. CLEANER
7 Always carry your Cleaner from the
Cleaner...
Pool Vac Classic - Page 13
... Middle Body.
3. It is not recommended as DIY repair. Reattach the Handle by screwing in the
handle and pry each slot in the four screws previously removed. Set the new Skirt/Middle Body assembly onto the Main Drive Assy.
6. POOL VAC XL SKIRT/MID SECTION REPLACEMENT: Replacement of the Handle and pu8 sh the Top
7
6
Cover...
Pool Vac Classic - Page 14
... assembly off pool pump
Remove Navigator Pro from pool
Disconnect suction ...repair. Rotate the Handle down until it snaps into each slot in front. Set the new Skirt/Middle Body assembly onto the Main Drive Assy.
5. Navigator Pro Skirt/Mid Section Replacement:
Replacement...are aligned to a HAYWARD dealer for replacement.
6
5
4
3
2
Tools required - #2 Phillips...
Pool Vac Classic - Page 15
... allow quick access to debris trapped in the throat or inside the unit, the turbine/vacuum chamber is accessible following the instructions on pages 13 & 14 of this manual. 1. Turn off pDump. 2.
Removal Instructions
"EASY OPENING BOTTOM"
6. Disconnect Cleaner from pool. 3. Turn Cleaner upside down. 5. C
B
A
1
13 "EASY OPENING BOTTOM" The purpose of the bottom
(see...
Pool Vac Classic - Page 17
...
Clear blockage
Worn shoes
Replace shoes
Worn wings
Replace wings
Hose too short
Install additional hose sections per Step 6. Turbine Suction Cleaner
TROUBLESHOOTING GUIDE
Problem: Slow/no forward movement CAUSES Lack of/improper water flow through cleaner
Check water flow with Flow Gauge and adjust as per
installation instructions. only)
Problem: Cleaner fails to |||
15...
Pool Vac Classic - Page 18
... and clean rear screen
2) Check to the bottom of the pool until the hose is covered with bubbles again
The cleaner head is free and rotates smoothly in both
Readjust return outlets to water surface and sucks air. Turbine Suction Cleaner
TROUBLESHOOTING GUIDE
Problem: Cleaner climbs to prevent water flow interfering with cleaner head...
Pool Vac Classic - Page 20
... weak.
automatic or
manual cannot remove that the plaster will cause wear on the
Cleaner - only): 1) The Purchase Date of your Hayward Turbine Suction Cleaner. 2) The Serial Number of the Hose Sections used. 4) A current water flow indicator setting (refer to Step 6, Figure 2).
18 D) The integrity of "good" pool plaster is such that a pool vacuum cleaner - E) Vinyl...
Pool Vac Classic - Page 21
...Plymouth Dr. Oakville, ON L6H5R4
If you purchased your Cleaner in the United States For convenient registration visit: www.hayward-pool.com or mail to :
Clevaquip Pty Ltd PO Box 4384 DANDENONG SOUTH, VICTORIA 3164, AUSTRALIA
19 Turbine Suction ...your Cleaner in Australia or New Zealand For convenient registration visit: www.cleva.com.au or mail to :
Hayward Pool Products 620 Division St.
Pool Vac Classic - Page 22
LIMITED PARTS WARRANTY
To the Original Retail Consumer/Purchaser (the "PURCASER") of the Hayward Pool Vac XL, Navigator Pro and Pool Vac Classic (the "CLEANER"): Hayward Pool Products, Inc. ("HAYWARD") warrants the cleaner from the date of original purchase. External motion devices are warranted to be free from defects in workmanship and materials for Warranty Eligibility
All Pool Vac XL and ...
Hayward Pool Vac Classic™ Reviews
We have not received any reviews for Hayward yet.