Hayward 700 SF HCF CARTRIDGE FILTER Support and Manuals
Get Help and Manuals for this Hayward item
This item is in your list!
View All Support Options Below
Free Hayward 700 SF HCF CARTRIDGE FILTER manuals!
Problems with Hayward 700 SF HCF CARTRIDGE FILTER?
Ask a Question
Free Hayward 700 SF HCF CARTRIDGE FILTER manuals!
Problems with Hayward 700 SF HCF CARTRIDGE FILTER?
Ask a Question
Popular Hayward 700 SF HCF CARTRIDGE FILTER Manual Pages
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 1
ISC7031HCF
HCF CARTRIDGE FILTER
MODEL
HCF7030C
EFFECTIVE FILTRATION RATE
DESIGN FLOW RATE Commercial
FT2
M2
GPM
LPM
700
63.2
150
568
MAXIMUM WORKING PRESSURE 50 PSI (3.45 BAR)
ATTENTION INSTALLER: THIS MANUAL CONTAINS IMPORTANT INFORMATION ON THE OPERATION, AND SAFE USE OF THIS EQUIPMENT.
THIS MANUAL IS INTENDED FOR THE END USER OF THIS PRODUCT. Model: HCF7030C
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 2
...Product Registration
13. Service and Repairs
10. General
2.1 Installation
3. Vacuuming Pool
7. Warranty Card Registration
5 3
6 a b c d e
8 7 9 25
10 a b
14
15 a b c d e
18
19
20
21
4 1 2
11 12
13 a b c d e
16
17
22 23 24
25 26
HCF Cartridge Filter
Model: HCF7030C
2 Table of the Manual Air Relief Valve
8. Important Safety Instructions
2. Replacement Part Drawings and...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 3
...system valves are set in severe ... consumers aware of the upper filter body if safety and operation instructions are unpredictable and unsafe. Using...installed and serviced only by young children. To reduce risk of the pump and filter system in severe personal injury or death.
3 This product should be alert to hazards. Non-Hayward components may fail in
OFF position and filter manual...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 4
...conformance with applicable local codes, regulations and the
National Electrical Code (NEC). • Before performing any service or maintenance on electrical equipment turn off all electrical power. • Contact a licensed electrician or building inspector for information on local electrical codes for
bonding requirements. • Verify water discharge from the filter manual air relief valve...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 5
... should be installed and serviced only by gravity.
DRAIN PLUG
4. F
TO THE POOL (OUTLET) 12.5"
LOWER FILTER BODY
5. The filter system should be installed on a level concrete slab or other rigid base.
A
2. Connect the pump discharge (pump OUTLET) to the pool return plumbing lines.
8. General Information
Your Hayward HCF cartridge filter combines superior water...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 6
... that the filter manual air relief body is discharged from the filter to return to the clamp bolt. Using a ¾" socket on a torque wrench, torque clamp nut to clamp bolt to stop leak.
2.
Non-Hayward clamp components may fail in OPEN position. (See Fig 2)
3.2 Starting the Pump
1. Reassemble the clamp system per the instructions on...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 7
...
the flow decreases below the desired rate, clean or replace the
Figure 3
filter cartridge elements. As
the filter removes dirt from filter. Set all
electric power on the equipment pad.
2. Figure 4
5. Lift off all system circulation pumps and all system valves in the
OPEN position. (Fig 6)
4. FILTER DISASSEMBLY INSTRUCTIONS
LOWER BODY SEAL SURFACE
1. Do not to drop the...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 8
Clean filter cartridge elements.
4.4 Cleaning Cartridges
The Cartridge filter element can damage the filter element. Do not pressure wash as it can be cleaned by using slight rocking motion and lifting up. 3. You may find some debris on the cartridge pleats, which is exposed when the upper filter body is removed. (Fig 4) 2. OPERATION
8 After hosing cartridge, for best results, ...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 9
Carefully replace the cartridges over the hubs on top of the lower filter body.
2.
WARNING
WARNING: This product should be installed and serviced only by a qualified pool professional.
9 Flush and drain any dirt or debris from around the manual air relief area.
3. With a clean cloth, wipe the lower filter body seal
surface and clean seal of all dirt...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 11
...
WARNING
This product should be installed and serviced only by a qualified pool professional.
Verify the MAR discharge points away from flowing to be disassembled and the filter cartridges elements cleaned or replaced. 2. Rotate counterclockwise to avoid cracking the filter body.
11 The manual air relief valve must be installed and serviced only by a qualified pool professional...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 12
... (adjust as required. 2.
Be sure flow rate through filter is sufficient. 3. No returns may be made directly to 80 ppm
(Cyanuric Acid)
PROBLEM SOLVING LIST
LOW WATER FLOW 1.
Operate filter for debris. 2. POOL WATER WON'T CLEAR UP 1. Service and Repairs
Consult your local authorized Hayward dealer or service center. Check for algae in intake
line (indicated by...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 13
...Replacement Part Drawing and Numbers
Model HCF7303C
# Description
Hayward Part #
1 Pressure Gauge
ECX2712B1
2 O-Ring Kit (Set of 2)
DEX2420Z8A
3 Air Relief Valve Nut
CCX1000N
4 Manual Air Relief w/O-Ring
CCX1000V
5 Manual Air Relief Assembly
DE2420MAR2
6 Upper Filter... Filter 12 Air Relief Tube
CX5030C CX3000J1 CX2030Z3
Cartridge Element (8 required) CX591XRE
13 Cartridge Elements...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 14
... states do not allow a limitation on your nearest Hayward Authorized Service Center please visit us at our option, within 90 days of the receipt of all previous publications.
14 WARRANTY
11. Hayward shall not be repaired or replaced, at www.haywardcommercialpool.com. This warranty gives you specific legal rights, and you may not apply to be...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 15
... Vinyl ___ Fiberglass ___ Other New Installation ___ Replacement ___ Installation for your warranty online at http://www.haywardcommercialpool.com Please Print Clearly:
HCF Cartridge Filter
First Name Last Name Street Address City State___________ Zip Phone Number Purchase Date E-Mail Address Serial Number (10-17 digit number Model Number Pool Capacity U.S. WARRANTY CARD REGISTRATION...
HCF Series Cartridge Filter Operation Manual ISC7031HCF - Page 16
... Heating I Cleaners I Sanitization I Automation I Lighting I Safety I White Goods I Flow Control
Hayward is ready to serve you in :
1-800-657-2287
Our toll-free line will put you .
ISC7031HCF HCF CARTRIDGE FILTER
Hayward Commercial is a registered trademark of Hayward Industries, Inc. © 2012 Hayward Industries, Inc. We're here to jump in direct contact with an experienced technical...
Hayward 700 SF HCF CARTRIDGE FILTER Reviews
Do you have an experience with the Hayward 700 SF HCF CARTRIDGE FILTER that you would like to share?
Earn 750 points for your review!
We have not received any reviews for Hayward yet.
Earn 750 points for your review!