Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps Support and Manuals
Get Help and Manuals for this Pentair item
View All Support Options Below
Free Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps manuals!
Problems with Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps?
Ask a Question
Free Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps manuals!
Problems with Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps?
Ask a Question
Popular Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps Manual Pages
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 2
... shut-down before connecting to freeze. To avoid burns when servicing pump, allow pump or any component. Pump water only with this manual, look for one of the product. Keep work areas. Release all safety instructions in death or serious injury.
Pump body may be followed during installation, operation, and maintenance of the following signal words and be...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 3
... warranty will not apply to any product that STA-RITE repair or replace defective products (at STA-RITE's choice). This warranty gives You specific legal rights and You may not apply to You. Product
Water Systems Products -
Your only remedy, and STA-RITE's only duty, is that , in material and workmanship for service will be accepted if received after the...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 4
... can air lock the pump). Support the pipe so that there...Installation
4
To Household Water System
Pump Priming Tee and Plug
Priming Tee and Plug
Check Valve
Replacing An Old Pump
Hazardous voltage. If the suction pipe can suck air, the pump cannot pull water from the well to the well as the suction port on the pump (include a check valve if your new shallow well jet pump. Typical pump...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 5
... just completed the suction piping for sprinkler applications.
1. Installation
5
To Household Water System
Pump Priming Tee and Plug
Suction Pipe From Water Source
Check Valve
Priming Tee and Plug
4. especially elbows - The installation shown could be used for your new shallow well jet pump. The pump should also be installed as close to the water as fittings increase...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 6
...be 2 PSI less than the cut-in setting of air in pump components. Adjust the tank pre-charge pressure to 28 PSI for a model CJ90F pump (40/60 pressure switch).
Congratulations! If the...hose from one arm of the discharge tee to 38 PSI for a model CJ90E pump (30/50 pressure switch), or to your jet pump.
Figure 4: Pre-charged Tank C18o6n4 0n7e95cItNiTons
Sealing Pipe Joints
Use only ...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 7
... the plug will line up with the 115 V arrow on pump, motor, pressure switch, or wiring.
If there are other wires, they should be capped. 6. The motor terminal board (located under the motor end cover) should be capped. 7. Use the instructions to set to match your power source. Move the voltage change plug...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 8
...motor for code information. Please go to Page 9 for your pump. Load Amp...10 (21/5.5) Connect the ground wire to a grounded lead in a service panel, to a metal underground water pipe, to a metal well ...set for 115 V or 230 V. If necessary, reset the motor to the pressure switch as the power supply wires. 2. Consult your pump in Figure 5. Connection Procedure: 1. Install...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 9
... water before starting.
1. Remove
this and let the pump drain. This will remain in the well is full. Replace all piping in the pump.
Drain the pump. A pump lifting water 25' may have a separate drain plug. Open a faucet and let it drain until you don't have also installed a priming tee in order to 30 PSI and...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 10
... or capacitor terminals. If in the well. Check with new steel pipe. Install heavier wiring if wire size is in setting (30-50 PSI), pump air into water and re-prime. In new installation: 1. Re-prime according to air volume control port. Check all wiring. Replace foot valve or check valve. Check all connections for leaks...
Sta-Rite Series CJ Shallow Well Jet Pumps/Tank Systems Manual - Page 11
Repair Parts
19 20 21
18 17
16 15
11
1
CJ90E
CJ90F
2
3 4 5A 5B 6
7
8
9
10 14
Ref. Description
Qty.
1 Motor
1
2 Slinger
1
3 Seal Plate
1
4 O-Ring
1
5A Shaft Seal Seat
1
5B Shaft Seal Rotating
1
6 Impeller
1
7 Venturi
1
8 O-Ring
1
9 90° Hose Barb
1
10 Pump Body
1
11 Plug, Stainless Steel
1
12 Washer
1
13 Screw, Socket Head
8
14 Base
1
15 Bolt...
Sta-Rite CJ Series Data Sheet - Page 1
...HP 1 1-1/2
SWITCH SETTING
30-50
40-60
DESCRIPTION Shallow Well Jet Shallow Well Jet
PIPE TAPPIPNG SIZES
SUCTION...STA-RITE® CJ Series
Self-priming shallow well jet pumps, stainless steel body
CJ models provide excellent performance with water. UL778/CSA108
SPECIFICATIONS Maximum Liquid Temperature Limits: 122°F (50°C) Max. for wells to 25' deep. Body: 304 Stainless steel Jet...
Sta-Rite CJ Series Data Sheet - Page 2
...
HP
DISCH. Relief valve must be capable of relieving entire flow of pump at relief pressure.
2
S5185WS Pumps installed with a Pro-Source® tank require a 100 PSI relief valve. TOTAL HEAD IN FEET TOTAL HEAD IN METERS
STA-RITE® CJ Series
Self-priming shallow well jet pumps, stainless steel body
PUMP PERFORMANCE
0 200
CAPACITY LITERS PER MINUTE
25
50
75 60
175...
Sta-Rite CJ Series Data Sheet - Page 3
STA-RITE® CJ Series
Self-priming shallow well jet pumps, stainless steel body
OUTLINE DIMENSIONS
1 NPT DISCHARGE
L
3.84
1-1/4 NPT
SUCTION
8.19 5.41
6.52 (2) Ø.44 MOUNTING BOLT HOLES Dimensions (in inches) are for estimating purposes only.
9.72
CATALOG NUMBER
CJ9E
CJ90F
L 18.19 19.25
10.31
8.38
1.00 1.25 2.50
3
S5185WS
Sta-Rite CJ Series Data Sheet - Page 4
... STREET, DELAVAN, WI 53115 WWW.STA-RITE.COM PH: 888-782-7483 ORDERS FAX: 800-426-9446 CANADA: 490 PINEBUSH ROAD, UNIT 4, CAMBRIDGE, ONTARIO N1T 0A5 PH: 800-363-7867 ORDERS FAX: 888-606-5484
Because we are continuously improving our products and services, Pentair reserves the right to change specifications without prior notice.
©...
Pentair Pentair Sta-Rite CJ Series Stainless Steel Shallow Well Jet Pumps Reviews
We have not received any reviews for Pentair yet.