Hayward RFK-C5000-WIFI Support and Manuals
Get Help and Manuals for this Hayward item
View All Support Options Below
Free Hayward RFK-C5000-WIFI manuals!
Problems with Hayward RFK-C5000-WIFI?
Ask a Question
Free Hayward RFK-C5000-WIFI manuals!
Problems with Hayward RFK-C5000-WIFI?
Ask a Question
Popular Hayward RFK-C5000-WIFI Manual Pages
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 1
...hazard. Hayward Commercial Pool Products 10101 Molecular Drive, Suite 200 Rockville, MD 20850
www.haywardcommercialpool.com
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
This...manual, look for personal injury. CAUTION warns about hazards that are unpredictable and unsafe. When you Begin 2 Installation 3 Activation 9 Returning Original Parts.......13
RFK-C5000-WIFI
IMPORTANT SAFETY INSTRUCTIONS...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 2
... Antenna Cable. The numbers below are necessary for activation and will not be accessible after the retrofit kit is a retrofit kit used to connect with WiFi components. Introduction
The RFK-C5000-WIFI is installed. Communications and Assembly Instructions not shown. 2
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
Before You Begin
Write down the following information BEFORE...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 3
... board, NOT the smaller one. 3
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Unplug the ribbon cable where shown, and set aside.
2) Remove (4) screws holding the "Riser Board Assembly" (Display screen). Be sure to stress the ribbon cable attached. Installation
CAUTION: Disconnect power to the C5000 before attempting to install the RFK-C5000-WIFI retrofit kit.
1) Unscrew and slowly remove the...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 4
...the chip puller supplied, remove old processor chips. (These must be return-shipped to Hayward along with both chips.
5) Remove old antenna cable from housing.
6) NOTE: BEFORE...adhesive dot on the bottom of enclosure (2 configurations shown). This unit must also be return-shipped to Hayward in supplied anti-static case).
7) Place old chips in the anti-static case provided for shipment.
8)...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 5
... motherboard making sure all pins align with antenna cable socket when assembled.
14) Insert cut off one edge of screw head as shown.
5
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 6
... to motherboard. Do not overtighten.
16) Repeat at opposite corner of housing. 20) Install lock washer and nut and tighten with solder joints as shown.
18) Apply ribbon cable to NOT interfere with pliers.
6
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Note orientation of red wire and notch/tab in connector.
19) Insert cable antenna...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 7
installation.
25) Adhere the motherboard assembly to the inside of double-stick tape, and fold tape in half.
23) Apply tape where shown and remove backing ... backing from one side of the enclosure.
26) Attach antenna cable to transceiver by pushing cable connector onto pc board socket where shown. 7
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 8
27) Approximate location shown here.
28) Thread nut on to antenna cable completely. Then insert cable fitting through mounting hole.
29) Re-fasten with (4) screws.
30) Plug in faceplate ribbon cable.
31) Re-attach faceplate.
8
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 9
... Cat Serial Number Wifi Transceiver Serial Number (refer to page 1) Wifi Transceiver Model Number (refer to page 1) Wifi Transceiver Node ID (refer to page 1)
1) Register Controller to your Poolcomm.com account. (You may do this before or after set up of unit).
9
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Activation
After installing the RFK-C5000-WIFI retrofit kit, contact Hayward for activation...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 10
WiFi Connectivity Checklist
Specific information about your wireless connection have MAC filtering?____ *If network is unsecured and does not have a password, you may skip steps 2 thru 3. To aid in installation, fill out the information below and then proceed to the following wireless LAN security specifications... ONLY HAYWARD GENUINE REPLACEMENT PARTS Firewalls/rules that block any character. Unit ...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 11
...", then please allow an additional 5 minutes for unit to try to find networks.
11
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Press ENTER to select. 2) Plug in controller and wait at least 5 minutes after powering up to "WLAN Setup" and press ENTER.
4) Press ENTER under the "Network" selection.
5) Scroll down to find your wireless network...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 12
... press ENTER.
9) Using the UP and DOWN buttons, input the password to your wireless network speed.
12
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Security setting types are as follows, and can be found on your router or by contacting your internet service provider.* -WPA -WPA2 -WEP-64 -WEP-128 *If your network is unsecured, meaning it...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 13
... Attn: Patti Eads 61 Whitecap Drive N. Returning Original Parts
Pack the original Microprocessor chip in the provided anti-static box and the original Transceiver in 30 days to receive $100.00 credit.
13
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Kingstown, RI 02852 Note: Parts must be returned with in the provided anti-static bag and...
CAT 5000 WiFi Retro Fit Kit Water Quality Controllers Owners Manual - Page 16
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS Hayward is not in any way affiliated with or endorsed by Hayward are registered trademarks of their respective owners.
For further information, visit our website at www.haywardcommercialpool.com
Hayward, CAT Controllers and CAT 1000 are the property of Hayward Industries, Inc. © 2012 Hayward Industries, Inc. All other trademarks not owned by...
Hayward RFK-C5000-WIFI Reviews
We have not received any reviews for Hayward yet.