2008 Polaris Supersport Problems and Repair Information
Get Help and Support for Polaris
View All Support Options Below
Free 2008 Polaris Supersport manuals!
Problems with 2008 Polaris Supersport?
Ask a Question
Other Models
Free 2008 Polaris Supersport manuals!
Problems with 2008 Polaris Supersport?
Ask a Question
Other Models
Popular 2008 Polaris Supersport Manual Pages
Owners Manual - Page 3
Failure to cause cancer, birth defects or other reproductive harm. WARNING
The engine exhaust from this manual and on all of the instructions and safety precautions in serious injury or death.
WARNING
Read, understand, and follow the safety precautions could result in this product contains chemicals known to the State of California to follow all product labels.
Owners Manual - Page 4
... Service Manual and should be sure to our worldwide family of your total satisfaction.
Have your accessories and clothing delivered right to visit us online at www.polarisindustries.com for minor maintenance, but information about major repairs is interested in your service needs during, and after, the warranty period. Thank you for all utility and recreational vehicles...
Owners Manual - Page 6
... safe vehicle operation and identifies warning decals and their locations. Operation ...52
This section explains proper engine break-...manual.
Pre-Ride Inspections ...45
This section explains procedures that should be performed before riding.
Introduction ...4
This section contains helpful information for an optimum riding experience. Polaris Products...Troubleshooting ...Warranty...
Owners Manual - Page 7
...them in this manual, store it to ride, ...Vehicle Model Number: _____ Tunnel VIN:_____ (lower right side of the tunnel) Engine Serial Number: _____ (right front side of your existing keys, so if both keys are inspected by mating a Polaris key blank with your dealer at specific mileage intervals. Teach them proper snowmobile courtesy, and enroll them to ensure warranty...
Owners Manual - Page 24
...service clutches yourself --
If any decal becomes illegible or comes off, contact your protection. Clutch Cover Warning
This warning decal is found under the hood on the clutch cover:
WARNING Do not operate engine... Do not operate engine with hood-to purchase a replacement. Never run engine with engine running. Air Box... to -air box foam removed or engine failure will result.
21 Read and ...
Owners Manual - Page 26
Setting will remain until changed.
23
SAFETY
+
NOTE: For more information, see Owner's Manual. If electric reverse: • Machine stopped and engine at low speeds, can cause loss of control resulting in serious injury or death. Let go of control, always: • Look behind before and while ...
Owners Manual - Page 27
.... Do not leave brake engaged for more than five minutes. • Before starting engine, check throttle, brake, and steering for age requirements. • When operating with limited...the Owner's Manual before or while operating this vehicle. • This vehicle is latched. Oil injection system: Use unmixed fuel only. A passenger reduces your ability to control the vehicle. •...
Owners Manual - Page 29
... models come with special features such as a reverse indicator light, electronic fuel gauge, temperature light and electric shock control gauge. Refer to your Owner's Manual Supplement for the features on your model.
2 3
4 1 5
6
10 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. Brake Lever Speedometer Tachometer (Accessory) Engine Stop Switch Throttle Control Hood Hold Down Straps Choke Recoil Starter Handle...
Owners Manual - Page 49
...Have the throttle serviced immediately.
The manual is operated. PRE-RIDE INSPECTIONS
Before Starting the Engine
Before starting the engine, always refer to all safety warnings pertaining to it compresses evenly and smoothly. Read and Understand Your Owner's Manual
Read the Owner's Manual completely and refer to snowmobile operation. WARNING
Operating the vehicle with worn, damaged...
Owners Manual - Page 65
...engine doesn't start the engine. Excessive freeplay in serious injury or death. If this occurs, return the machine to an authorized Polaris dealer for service as soon as possible.
62 Return the machine to an authorized Polaris dealer for service... 5. If an emergency exists and it several times. If the engine stops abruptly when the throttle lever is released: 1. When these ...
Owners Manual - Page 68
... Reverse (PERCt)
OPERATION
Electronic reverse will activate only if the engine RPM is below . If your vehicle is in forward gear when it's restarted.
65 The engine will indicate that the transmission is clear. 3. Apply the throttle slowly to reverse. Always make sure the transmission is running , the snowmobile will be in reverse. 4. Push the...
Owners Manual - Page 72
...
Please read the Snowmobile Engine Emissions Limited Warranty on page 128, and read the maintenance section of the manual. Polaris considers the specified maintenance for the spark plugs, oil changes, air intake system and exhaust valves to perform any service that the specified maintenance is recommended additional emissionrelated maintenance. Any qualified repair shop or qualified...
Owners Manual - Page 110
... lower the machine to an approved fuel container using a siphon pump. Transfer unused fuel from the fuel tank to the floor.
107 Wait one to drain the fuel system. Extended Storage
Engine and Carburetor Protection
MAINTENANCE
Using a fuel stabilizer and topping off the fuel tank eliminates the need to two minutes and perform steps 3-5 on remaining cylinders. 7. Do not...
Owners Manual - Page 117
... Troubleshooting
Unless you have experience and training in two-cycle engine repair, see your dealer if technical problems arise. Problem
Erratic engine operating RPM during acceleration or load variations
Probable Cause Solution
Drive clutch binding • Disassemble drive clutch to lack of spec Engine mount broken or loose • Adjust alignment offset. SEE YOUR DEALER. • Clean...
Owners Manual - Page 122
...manual. Your dealer is also familiar with Polaris policies and procedures and will be happy to record the identification numbers of your snowmobile and its engine...service or warranty. Service and Warranty Information
WARRANTY
Obtaining Service and Warranty Assistance
Read and understand the service data and the Polaris warranty information contained in this manual. Polaris Customer Service...
Owners Manual - Page 125
... repair Polaris snowmobiles. How to Obtain Warranty Service
If your snowmobile requires warranty service, you must present your copy of the Warranty Registration...warranty.
122 This warranty gives you specific legal rights, and you must take it to a Polaris dealer authorized to resolve any of Polaris engine oil. 2. Engine Oil
1. Damage resulting from state to perform warranty service...
Owners Manual - Page 126
... coverage. surface imperfections caused by a Polaris Dealer (if applicable). improper component alignment, tension, adjustment or altitude compensation; modified components; unauthorized repairs; Warranty will not apply to perform the required vehicle Pre-Delivery Inspection, perform all applicable service bulletins and have been properly set up /delivery Loss of completing an effective...
Owners Manual - Page 128
... free Second Year Engine Service Contract is covered. • Clutches and related clutch parts, including but not limited to a $50 deductible per visit. Regular, documented service maintenance visits are covered, as required in the owner's manual or Polaris updates. This includes off-season storage as listed in its sole discretion. The fuel pump is subject to...
Owners Manual - Page 131
...,WHETHER ARISING OUT OF EXPRESS OR IMPLIED WARRANTY OR ANY OTHER CONTRACT, NEGLIGENCE OR OTHER TORT OR OTHERWISE. Replacing or repairing other components not covered by this emissions certified snowmobile engine starts on your snowmobile engine, this warranty is first purchased and continues for 4000 kilometers (2485 miles) of vehicle travel, 200 hours of the snowmobile owner...
Owners Manual - Page 132
... failures not caused by an aftermarket parts manufacturer reduces the effectiveness of the vehicle's emission controls. It is not performed. Polaris can deny an emissions warranty claim if any engine that may result in the owner's manual. Snowmobile Engine Emissions Limited Warranty
WARRANTY
Some states do not allow limitations on your snowmobile. Owners are responsible for...
2008 Polaris Supersport Reviews
Do you have an experience with the 2008 Polaris Supersport that you would like to share?
Earn 750 points for your review!
We have not received any reviews for the 2008 Polaris Supersport yet.
Earn 750 points for your review!