Toro 38025 Support Question
Toro 38025 Support Question
Find answers below for this question about Toro 38025 - 18" Power Curve Electric Snow Thrower.Need a Toro 38025 manual? We have 2 online manuals for this item!
Question posted by edabar on January 27th, 2011
Circuit Breaker Blowing (15 Amp)
I have one of the first Power Curve 1800's. This year, for the first time, after 30-60 minutes of use, it tripped the circuit breaker. The breaker would not reset, it was blown. I had the breaker replaced yesterday by an electrician and today the same circuit tripped after 30-60 minutes use.. I cannot reset the breaker because the new one blew . Plug is GFI. New barker is also 15 amp. Electrician coming Friday. Please adbsie.
Current Answers
Related Toro 38025 Manual Pages
Operation Manual - Page 1
...and accessory information, help finding a dealer, or to highlight information.
Safety alert symbol
This manual uses 2 words to register your product.
You may have the model and serial numbers of the model... federal areas may contact Toro directly at www.Toro.com. This rotary-blade, walk-behind lawn mower is not equipped with Canadian ICES-002.
© 2011-The Toro® Company ...
Operation Manual - Page 2
...the discharge opening at the time of accessories. Exercise extreme caution when changing direction on a slope, do not mow it.
• Mow across the face of lawn mower will be ordered through...enters the area.
• Do not operate machine barefooted or while wearing sandals.
Improperly using or maintaining this machine.
• Clear the area of bystanders before you to vibrate ...
Operation Manual - Page 3
...truck or trailer bed with the engine running .
Do not use extreme care in an enclosed area. Do not run the ...; If you . Children are explosive.
• Extinguish all times until fueling is spilled on the ground. Gasoline is an open...devices. Allow engine to cool before filling.
• Remove gas-powered equipment from your view of children. Repair, if necessary, before ...
Operation Manual - Page 5
... the handle to a level surface. 2. Insert the dipstick fully into the oil fill tube, wait 3 minutes, and repeat steps 3 through 5 until the oil level is below the Add mark on the dipstick, ... Wipe the dipstick clean with oil. Max. Figure 3
2.
fill: 20 oz. (0.59 l), type: SAE 30 detergent oil with an API service classification of oil into the oil fill tube, then remove the dipstick.
5....
Operation Manual - Page 6
... oil and run the engine.
change it yearly thereafter. Product Overview
3
Charging the Battery
No Parts Required
Procedure
Electric-start 10. Handle
8. Fuel tank cap
11...the first 5 operating hours;
Oil fill/dipstick
12. Cutting height lever (4)
2. Ignition key (electric-start models only Refer to Changing the Engine Oil. Side-discharge deflector
models only)
4. Handle knob...
Operation Manual - Page 7
... Full.
6. Checking the Engine Oil Level
Service Interval: Before each use methanol, gasoline containing methanol, or gasoline containing more than 30 days old.
1. Move the mower to the fuel all season, ...mixing it with fresh unleaded regular gasoline (having an octane rating of oil into the oil fill tube, wait 3 minutes, and...
Operation Manual - Page 8
Hold the blade control bar against the handle (Figure 10).
Turn the ignition key (Figure 11) (electric-start models only) or pull the recoil start handle, pull it lightly until you pull the recoil start handle (Figure 12). Lower the mower
Note: ...
Operation Manual - Page 9
... recycle the grass and leaf clippings back into the lawn. Recycling the Clippings
Your mower comes from the lawn.
Bagging the Clippings
Use the grass bag when you release the blade control bar...at your sides, and the mower will automatically keep pace with you leave the mower (electric-start after self-propelling, stop the engine, release the blade control bar.
Figure 13
WARNING...
Operation Manual - Page 10
... on the bag rest in the notches on -demand lever (in serious personal injury. lever forward until the button on the lever pops up (Figure 15)
Figure 15 1. Bag-on the handle (Figure 14).
3.
contacting the blade can result in bagging position)
1.
Operation Manual - Page 11
... the side discharge chute, lift up the side deflector and install the side discharge chute (Figure 17).
1. Clean here
Figure 16
Side-discharging the Clippings
Use the side discharge for all moving parts to Operating the Bag-on -demand lever is sharp; WARNING
The blade is in serious personal injury. Stop...
Operation Manual - Page 12
....
• Mow only dry grass or leaves. This helps disperse the clippings over 6 inches (15 cm) tall, mow at a time. Cutting Grass
• Cut only about a third of dry grass and leaf debris.
•...; Clear the area of sticks, stones, wire, branches, and other debris that half of the lawn shows through the cut below the 2-1/8-inch (54 mm) setting unless the grass is late fall when...
Operation Manual - Page 13
... battery for 24 hours (electric-start models only).
• Empty the fuel tank before repairs as directed and before performing any additional yearly maintenance
procedures. Preparing for ...side, with a hand pump;
Figure 18
3.
Maintenance
Note: Determine the left and right sides of fuel, use or daily
Every 25 hours Before storage
Yearly
Maintenance Procedure
• Change the engine...
Operation Manual - Page 15
...
Service Interval: Every 25 hours
Electric-start models only
If the battery does not charge or the engine does not run with a 40-amp plug-in type fuse.
1.
Wipe... Always use the charger in the battery compartment area.
3. This state lasts only a few minutes until the battery is charging the
battery.
2. Note: Your battery charger may be blown. Replace it with the electric starter,...
Operation Manual - Page 16
....
1. Refer to hold the blade steady
(Figure 25). Use a block of the blade to 60 ft-lb (82 N-m). Figure 26
Important: Position the curved ends of wood to Preparing for Maintenance. 2. Fuse
Figure ..., saving all mounting hardware (Figure 26). Replacing the Blade
Service Interval: Yearly
Important: You will need a torque wrench to 60 ft-lb (82 N-m) is dull or nicked, have a torque wrench ...
Operation Manual - Page 18
...it in your automobile.
Dispose of the year, add fuel stabilizer to cool before ... engine to local codes, or use it stops.
Storage
Folding the Handle...must charge the battery every 90 days (electric-start model only). 2. Charge the ...30 ml) of oil through the spark plug hole, and pull the starter rope slowly several times to distribute oil throughout the cylinder to the spark plug.
18...
Operation Manual - Page 20
...use warranty would apply.
374-0254 Rev C
first time starts after extended period of the product on the first or second pull, provided the routine maintenance required in the fuel system
-
year full warranty
Limited Warranty for Commercial Use*
Gas-powered Toro Products used... difficulties due to the Yellow Pages of repairs under "Lawn Mowers") or access our web site at www.Toro....
Parts Catalog - Page 1
Original Instructions (EN) Form No. 3362-566 Rev A
1800 Power Curve® Snowthrower
Model No. 38025-Serial No. 310000001 and Up
Parts Catalog
Register at www.Toro.com.
Parts Catalog - Page 2
... symbol, and the y represents the reference number. For example, in parts lists. This catalog uses two special reference number formats, one part, the reference number has the form nX y. For example... phillips pan head thread forming PRH: phillips round head PTH: phillips truss head
PTO: power-take-off RH: right hand ROPS: roll-over protection system SFH: slotted fillister head SHH...
Parts Catalog - Page 4
... Qty. Description
30 73-3530
1...
1 Bushing
14 73-0280
1 Tube-Lower Handle
15 73-3630
1 Wire Harness
17 73-1800
1 Filter-Foam
18 32144-88
4 Screw-Pan Head
19 73-0120
...1 Strap-Motor
20 73-3520
1 Motor
21 73-8680
1 Motor Plate ASM
23 32144-100
2 Screw-Hex Washer Hd.
24 73-3660
1 Pulley-Driver
25 73-0160
1 Belt-Timing...
Parts Catalog - Page 5
... 33-8951
1 Sleeve-Crank, Chute 2 Screw-HH
13 3296-12 14 98-1822
2 Nut-Lock, NI 1 Decal-Escutcheon
15 73-0240 16 73-0230
1 Rod-Crank, Chute 1 Gear-Crank, Chute
17 73-0310 18 256-306
1 Plate-Escutcheon 1 Bushing-Nyliner
20 73-3450
2 Spring
21 73-3710
1 Brake-Gear
22 114-8986...
Similar Questions
Small Belt On 1800 Power Curve Snowthrower Model 38025 Keeps Shredding
The small belt on the small pulley on my Toro 1800 Power curve snowthrower model 38025 shreds after ...
The small belt on the small pulley on my Toro 1800 Power curve snowthrower model 38025 shreds after ...
(Posted by yebos 8 years ago)
Toro Power Shovel 38360 Manual
While using my unit today for snow removal from a deck, the snow-thrower rotor quit rotating. The el...
While using my unit today for snow removal from a deck, the snow-thrower rotor quit rotating. The el...
(Posted by jimfmuir 10 years ago)
Should The Large Pulley On A Power Shovel Be Lubed An What Lube Should Be Used
(Posted by efschwanz 11 years ago)
Rpm Drops Down
When using on higher speed the rpm's drop after a few minutes of use. If you let it rest for a while...
When using on higher speed the rpm's drop after a few minutes of use. If you let it rest for a while...
(Posted by streipcpd 11 years ago)
15 Amp Circuit Breaker Blowing
I have one of the early Power Curve 1800’s. It has run flawlessly until this week. Yesterday, ...
I have one of the early Power Curve 1800’s. It has run flawlessly until this week. Yesterday, ...
(Posted by edabar 13 years ago)