Toro 20330 Support Question
Toro 20330 Support Question
Find answers below for this question about Toro 20330 - Low Wheel Walk Power Mower.Need a Toro 20330 manual? We have 3 online manuals for this item!
Question posted by dbergeon15 on June 18th, 2015
Will Not Stay Running
having problems keeping running. Starts up but bogs down.
Current Answers
Answer #1: Posted by BusterDoogen on June 18th, 2015 11:50 AM
BusterDoogen
Member since:
October 30th, 2011 Points: 28,565,417
Member since:
October 30th, 2011 Points: 28,565,417
Possible causes are old fuel, dirty air filter or carburetor. I suggest you replace or clean the filter, fill with fresh pumped fuel & when running use a small engine carb cleaner to break loose any debris that may be clogging the jets.
I hope this is helpful to you!
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!
Answer #2: Posted by freginold on June 18th, 2015 4:35 PM
freginold
Member since:
December 20th, 2011 Points: 23,253,885
Member since:
December 20th, 2011 Points: 23,253,885
If your mower starts but won't stay running, it's likely either a problem in the fuel tank/fuel line or carburetor. Try flushing the gas tank and carburetor, giving the carburetor a good cleaning to make sure no holes are clogged, and checking the fuel hose for burrs or blockages. Then fill the gas tank with new, fresh gas and give the mower a try.
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
One way you can test if it's the carburetor is to start the mower then pump the primer -- if the mower runs as long as you press the primer bulb but then dies as soon as you stop, there is a clog or blockage inside the carburetor.
If it's a new mower, the air filter probably isn't the culprit, but if the above solution doesn't work, check the air filter to be sure it's not dirty.
Related Toro 20330 Manual Pages
Operation Manual - Page 2
...walk-behind rotary lawn mowers and the B71.1 specifications of your footing or balance.
2 never run.
• Disengage the drive system, if so equipped, before starting the engine.
• If the machine should start...follow all slopes require extra caution. Stay behind before cleaning the machine, removing ...symbol to potential personal injury hazards. Keep clear of the discharge opening at ...
Operation Manual - Page 3
...Keep all cigarettes, cigars, pipes, and other debris build-up oil or fuel spillage and remove any adjustments or repairs with manufacturer's recommended parts, when necessary.
• Mower blades are often attracted to prevent unintended starting... before filling.
• Remove gas-powered equipment from a gasoline dispenser nozzle.
• Keep the nozzle in handling gasoline. Clean ...
Operation Manual - Page 9
...of the grass blade at a lower setting for the best lawn appearance. Replace the blade or have it is late fall when...over any object.
• If the mower strikes an object or starts to clump on the mower, remove it before leaving the operating ... walk slower; If the grass is sharp;
Side-discharging the Clippings
Use the side discharge for all local fire warnings, and keep the mower ...
Operation Manual - Page 10
... on your mowing speed if the mower does not cut leaf cover. Walk at 2-1/2 inches (64 mm).
Cutting Leaves
• After cutting the lawn, ensure that half of the lawn shows through the cut the leaves finely enough.
10 - Raise the cutting height on the lawn, set the front wheels at 2-1/8-inch (54 mm) and the...
Operation Manual - Page 14
... the engine.
8. Start the engine and run it from under the mower housing.
7. Cleaning the Mower
Service Interval: Before each use or daily
The mower may dislodge material from rusting.
10. Attach a garden hose that come out from under the mower housing. • Wear eye protection. • Stay in both the fully forward and fully rearward positions...
Operation Manual - Page 16
... & the Toro GTS Starting Guarantee:
Items and Conditions Not Covered There is liable for indirect, incidental, or consequential damages in Recycler® Walk Power Mowers
Conditions and Products Covered under... starting procedures
If you provide the routine maintenance it requires, or we will diagnose the problem and determine if it is used for residential purposes*, will start your...
Service Manual - Page 1
WALK BEHIND POWER MOWER DRIVE SYSTEMS
SERVICE MANUAL
Service Manual - Page 3
... has basic mechanical knowledge and skills. Copyright© All Rights Reserved ©2006 The Toro Company This book contains material covering the Toro and Lawn-Boy Walk Behind Mower Drive Systems models from 1990 through 2006, and may be specified for Toro servicing dealers. ABOUT THIS MANUAL
This service manual was...
Service Manual - Page 5
... Personal Pace Easy Stride (Generation 2 7-6 Lawn-Boy Sens-a-Speed 7-9
Belt Replacement Mowers with Toro Blade Brake Clutch 8-3 Mowers with Toro Blade Override System 8-3 Zone start 21" Rear Wheel Drive Toro & Lawn-Boy (except Insight 8-2 Zone start 22" Toro Rear Wheel Drive 3-10 Zone start 22" Toro Front Wheel Drive 3-5 Lawn-Boy Insight Zone Start 3-19 Lawn-Boy Insight with Blade Clutch...
Service Manual - Page 7
... Assembly 4-9
Intermediate Shaft Assembly 4-10
Installation 4-10
Special Assembly Notes for Toro Vacu Power/Lawn-Boy Medallion 4-11
TROUBLESHOOTING TIPS - 3 SPEED TRANSMISSION
Hard Shifting 4-12
Slipping Gears 4-12
WHEEL PINION CLUTCH
GEAR CASE & WHEEL ASSEMBLY, ROCKING KEY STYLE 5-2 Wheel Pinion Clutch 5-3 Component Definitions 5-3 Test for Function 5-4 Quick Test 5-4 Rear Height...
Service Manual - Page 8
...
Toro 21" Front Wheel Drive 8-2 22" Front Wheel Drive 8-2 22" Rear Wheel Drive 8-2 21" Steel & Cast Deck Toro & Lawn-Boy Mowers Belt Replacement 8-2 21" Cast Deck Mowers with 3 Speed Transmission 8-2 21" Toro & Lawn-Boy Mowers with Blade Brake Clutch 8-3 21" Toro Mowers with Blade Override System & Lawn-Boy Mower
with Blade Brake Clutch System 8-3 21" Lawn-Boy Insight Mowers 8-3
iv
WPM...
Service Manual - Page 9
...the list below are codes identifying the type of the service manual for Vacu Power BOS -
one bail 2B - blade brake clutch BBC VP - blade brake clutch
for the mower being serviced. blade override system CD - Easy Stride 1st generation ES2 -... CD CD CD CD CD CD CD CD CD CD CD CD CD CD CD
Trans Internal Repair
Wheel Pinion
SB
RK
SB
RK
SB
RK
SB
RK
SB
RK
SB
RK
SB
RK
SB
RK
SB
...
Service Manual - Page 20
A spring which hooks into the tab on International 48cm rear wheel drive mowers. Spring C. The first is a clutch type and is used on the front of the worm drive transmission. When the clutch jaw engages the helical gear, power is transferred from the engine crankshaft. The axle then begins to the axle.
The...
Service Manual - Page 48
...
22" TORO & LAWN-BOY REAR WHEEL DRIVE MODELS
Transmission Removal and Belt Replacement
On rear wheel drive models, it... is not required for belt replacement.
5. Slide the door to change the drive belt.
1. Slip the belt out of the bag door spring. Fig 061
MVC-733
Fig 060
MVC-491
3-10
WPM Drive Systems Manual The blade can be removed, but it from the mower...
Service Manual - Page 69
...the black plastic transmission cover from the housing being very careful not to prevent accidental starting. Screen panel B. Slowly pull the transmission from the top rear of the housing,...6. Drain the fuel and oil.
2. Toro Vacu Power/Lawn-Boy Medallion Models
Complete transmission removal on the Toro Vacu Power/Lawn-Boy Medallion mower is quite easy and is recommended for most self-propel...
Service Manual - Page 79
...positively engages the wheel gear at the center of the clip is all times. Three it is not squeezing the handle. turns when the operator squeezes the handle to provide power to allow ...properly. causes the wheel pinion to retain the pivot arm and spring arm. This allows the wheels to turn backwards without turning the gears inside the transmission and provides low pull back forces ...
Service Manual - Page 80
... wheel individually. It is extremely important that the keys are disengaging properly, stop walking, keep your elbows at a normal pace. Walk ...gear.
To operate this time the mower can be serviced with shoulder bolt, spacers, wheel cover, and nylon locknut.
5-4
...rock the drive keys to malfunction. Start the engine and engage the drive, if both wheels turn , friction between the friction ...
Service Manual - Page 88
...clutch operates by tensioning and loosening the BBC cable. When the control is to as Lawn-Boy Medallion mowers.
Fig 146
BBC Control Box Operation
3428-0001
The BBC control mechanism's purpose is engaged...two versions which turns with the brake pad backs away from the flywheel. Refer to run. The two are free to pivot towards the brake drum releasing the belt and engaging the...
Service Manual - Page 115
...starting.
2.
We recommend carburetor side up to stop to replace the blade drive and self-propel belts.
1. On Toro it will not need to be restarted each time you stop while the engine keeps running.... This is named the Blade Clutch System. Fig 205
MVC-195
3. WPM Drive Systems Manual
Fig 206
MVC-197
6-29
On Lawn-Boy it is especially ...
Service Manual - Page 129
...).
To operate this keep your elbows at your sides, hold to go faster, walk faster. Handle Disassembly, Zone Start Models
1. The basic function is the engine stop control on zone start and blade clutch....keep the engine running. A. Do not push the Sens-a-Speed handle down and hold your hands straight out in two forms, zone start models and the blade control on blade clutch models. Lawn...
Similar Questions
Won't Stay Running
toro 6.5 briggs starts won't stay running has new air filter, new plug, new oil, new gas model no. 2...
toro 6.5 briggs starts won't stay running has new air filter, new plug, new oil, new gas model no. 2...
(Posted by wholt05 9 years ago)
Torro Lawn Mower Won't Stay Running
(Posted by scmultip 10 years ago)
My Toro Mower Starts But Won't Stay Running.acts Like It Is Starving For Fuel.
(Posted by jshilling45 11 years ago)
Toro 22 In. Low Wheel Recycler (20330) Started And Then Shut Off.
I was in the process of mowing my lawn with the Toro 22 in. Low Wheel Recycler (20330) the mower sta...
I was in the process of mowing my lawn with the Toro 22 in. Low Wheel Recycler (20330) the mower sta...
(Posted by damianbourne 12 years ago)