Poulan PXT12530 Support Question
Poulan PXT12530 Support Question
Find answers below for this question about Poulan PXT12530.Need a Poulan PXT12530 manual? We have 2 online manuals for this item!
Question posted by bcpc43 on April 15th, 2013
How Do I Adjust The Pulley Tension.
1st is ok. 2nd makes the front jump up a little. 3rd makes me lean forward to try and keep the wheels down.
Current Answers
Related Poulan PXT12530 Manual Pages
User Manual - Page 1
ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com
431832 11.03.09 CL
Printed in serious injury. Failure to do so can result in the U.S.A. IMPORTANT MANUAL
DO NOT THROW AWAY
OPERATOR'S MANUAL
MODEL:
PXT12530
LAWN TRACTOR
WARNING:
Read this Manual and follow all Warnings and Safety Instructions.
User Manual - Page 4
...lands. Spark Plug:
Champion RC12YC (Gap: .030")
Ground Speed (Mph): Charging System:
Forward: 1st 1.4
2nd 3.1
3rd 5.1
Reverse:
1.6
3 Amps Battery
Battery:
Amp/Hr: Min. CCA: Case Size:
... 4 ASSEMBLY 6-7 OPERATION 8-13
MAINTENANCE SCHEDULE 14 MAINTENANCE 14-17 SERVICE AND ADJUSTMENTS 18-23 STORAGE 24 TROUBLESHOOTING 25-26 WARRANTY 28
4 CUSTOMER RESPONSIBILITIES
•...
User Manual - Page 7
... rear of tractor.
• Pivot seat and pan forward and assemble adjustment knob and flat washer loosely. ASSEMBLY
INSTALL SEAT (See Fig. 3)
Adjust seat before you start the engine.
✓ Be ... routed properly around pulleys and inside all connections are still secure and wires are working properly (See the Operation and Maintenance sections in the Service and Adjustments section of other ...
User Manual - Page 11
...in reverse unless absolutely necessary. For healthier and better looking lawns, mow often and after moderate growth. • For best... lever (A) determines the cutting height. Make the first cut (see "TO ADJUST MOWER CUTTING HEIGHT")
• Start... while mowing is equipped with the engine running . OPERATION
TO MOVE FORWARD AND BACKWARD (See Fig. 8)
The direction and speed of movement is...
User Manual - Page 18
... (A) are pointing forward before sliding mower ... lowest position. • Roll belt off engine pulley (M) and belt keepers (G). • Remove cable...ADJUSTMENTS:
• Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral position. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key to "STOP" and remove key. • Make...
User Manual - Page 19
...8226; Hook end of link assembly through front hole in link assembly over pin (B) on engine pulley (M), in belt keepers (G).
tor.
Insert rod end of clutch cable spring (Q) into bracket. ... in tractor front suspension bracket (F). IMPORTANT: CHECK BELT FOR PROPER ROUTING IN ALL MOWER PULLEY GROOVES. • Raise attachment lift lever to highest position. Lift rear corner of tractor...
User Manual - Page 20
...mower to highest position.
• Position blade so the tip is pointing straight forward. The distance should be adjusted so the front tip is 1/8" to 3/8" lower than the rear tip when ... wrap blade with heavy cloth. SERVICE AND ADJUSTMENTS
TO LEVEL MOWER
Make sure tires are over or under inflated, it may affect the appearance of your lawn appears
unevenly cut, determine which side of mower...
User Manual - Page 21
... of all pulley grooves and inside the belt keeper.
4. Fig. 30
TO CHECK BRAKE
If tractor requires more than five (5) feet to manually push the tractor forward. The rear wheels must be ...manual). • Work belt off the steering plate (F) and remove from engine pulley (E).
5. BELT INSTALLATION 1. Make sure belt is in this manual). Park the tractor on level surface. Remove mower...
User Manual - Page 26
.... 2. Bent blade mandrel. 5. Frozen idler pulley. 4. Tighten blade bolt. 2. Clean underside of mower housing.
8. Place throttle control in the Service and Adjustments section. 1. Wet grass.
3. Low/uneven ...reverse
1. Faulty alternator.
1. Improper blades used.
10. Install axle key at rear wheel. Replace mower drive belt. 3. Reverse operation system (ROS) is not "ON" while...
Parts Manual - Page 1
IMPORTANT MANUAL
DO NOT THROW AWAY
REPAIR PARTS MANUAL
MODEL:
PXT12530
LAWN TRACTOR
WARNING:
Read this Manual and follow all Warnings and Safety Instructions.
ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com
532 44 14-91 Rev. 1 Failure to do so can result in serious injury.
Parts Manual - Page 2
... the parts on the fender under the seat. The model number for your tractor can be found on his/her tractor when ordering repair parts. "PXT12530 (96046003000)" • Part Number • Part Description
TABLE OF CONTENTS
SCHEMATIC ...3 ELECTRICAL ...4-5 CHASSIS ...6-7 DRIVE...8-9 ENGINE ...10-11 STEERING ...12-13 MOWER DECK ...14-15 MOWER...
Parts Manual - Page 3
...28 VOLTS AC MIN. @ 3600 RPM (CHARGING SYSTEM DISCONNECTED)
DIODE
ALTERNATOR
IGNITION SWITCH
POSITION CIRCUIT "MAKE"
OFF
M+G+A1
RUN/OVERRIDE B+A1
RUN
B+A1
START B + S + A1
L+A2
36
25...CLIPS WERE REMOVED FOR SERVICING OF UNIT, THEY SHOULD BE RE-INSTALLED TO PROPERLY SECURE YOUR WIRING. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 SCHEMATIC
SCH18
RED
A
AMMETER (OPTIONAL)
WHITE
S
...
Parts Manual - Page 4
MODEL NO. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 ELECTRICAL
T31K With 12V Outlet Option
33 30
103
87 59
With Service Minder Option
46
26
27 43
42
40
41
25
16
90
71
2
29
28
55
4
94
92 93 TRACTOR - -
Parts Manual - Page 5
... Reverse Switch 93 532 19 25-40 Screw Plastite 10-14 x 2.0 94 532 19 18-34 Module Reverse ROS
NOTE: All component dimensions given in U.S. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 ELECTRICAL
KEY PART NO. NO. TRACTOR - - inches 1 inch = 25.4 mm
5 MODEL NO. DESCRIPTION
1 532 14 49-24 Battery...
Parts Manual - Page 7
... 817 60 04-06 Screw 1/4-20 x 3/8 - - 532 19 39-35 Plug Switch Light
NOTE: All component dimensions given in U.S. MODEL NO. inches 1 inch = 25.4 mm
7 PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 CHASSIS AND ENCLOSURES
KEY PART NO.
Parts Manual - Page 9
...Washer Lock Hvy Helical 1/4 Washer 9/32 x 3/4 x 10 Ga. Cover, Foot Pedal Bolt Pulley Idler Flat Lock Nut 3/8-16 Idler V-Groove V-Belt, Drive Pulley Transaxle Shaft Asm. Shift Arm Clevis Rod Shift Spring Shift Spacer Axle Handle Parking Brake Bolt 3/8-... Gr. 5 Washer Serrated
NOTE: All component dimensions given in U.S. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 DRIVE
KEY PART
NO.
Parts Manual - Page 11
PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 ENGINE
KEY PART NO. Torque values are derived at 3600 RPM. Given both the wide array of power ... - - NO.
Engine Briggs Model No. 219807-1515-G5
2 532 17 97-58 Muffler
9 532 19 43-19 Keeper Belt Engine
12 532 14 01-86 Pulley Engine
15 532 40 75-45 Tank Fuel
18 532 43 02-20 Cap Asm.
20 532 17 05-45 Control Throttle
21 532 41...
Parts Manual - Page 12
MODEL NO. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 STEERING ASSEMBLY
26
72 33 45
1
20
71 21
16
64 63
28 57
13 28 22 119 60
63
59 19
35 58
61
6
4 14
69 68
9
8 7
74
2
67
74 67
15 70
66
9
8
7
74
62 14
15
74 6
5
13
steering-tex_STDHRS_8_r2
12
13 8
53 TRACTOR - -
Parts Manual - Page 13
...65 71 532 19 07-52 72 532 42 89-82 74 532 12 49-37
DESCRIPTION
Wheel, Steering Axle Asm., Front Spindle Asm., LH Spindle Asm., RH Bearing, Race Thrust Harden ...Steering Plate Steering Boot, Steering Adapter, Wheel Steering Steering Support Lower Wheel Steering Cap Screw 3/8-16 x 3/4 Washer Lock 5/16 Gear, Sector Plate Washer 11/32 x 3/8 x 12 Ga. PXT12530 (96046003000), PRODUCT NO. 960 46 00...
Parts Manual - Page 15
... RH 42 817 00 06-12 Screw Hexwsh THDR 3/8-16 x 3/4 BL 43 532 41 68-77 Pulley Mandrel 6 5 Pd 30" 67 532 40 30-12 Handle Clutch Cable 70 532 19 83-32 Clutch Asm. PXT12530 (96046003000), PRODUCT NO. 960 46 00-30 MOWER DECK
KEY PART NO.
Manual 71 817 67...
Similar Questions
Second And Third Gear Wants To Throw Me Off Poulan Pxt12530
I just bought a Poulan PXT12530. When I put it in second or third gear and slowly let off the brake ...
I just bought a Poulan PXT12530. When I put it in second or third gear and slowly let off the brake ...
(Posted by burntkluch 1 year ago)
Do They Make A 30' Mulching Kit For A Poulan Pxt12530 Lawnmower?
(Posted by kdecooman 1 year ago)
Is There An Alt Or Gen Or Regulator In A Poulan Pxt12530? Battery Won't Chg.
I had to jump start the mower when I wanted to use it. Installed a new battery but by the 3rd start ...
I had to jump start the mower when I wanted to use it. Installed a new battery but by the 3rd start ...
(Posted by bcpc43 9 years ago)
Wats The Carb Adjustments
wats the carb adjustments for a poulan pro pbv200 le
wats the carb adjustments for a poulan pro pbv200 le
(Posted by Anonymous-123568 10 years ago)