2016 Polaris 120 Indy Support Question
2016 Polaris 120 Indy Support Question
Find answers below for this question about 2016 Polaris 120 Indy.Need a 2016 Polaris 120 Indy manual? We have 1 online manual for this item!
Question posted by Bampinsonneault on January 5th, 2016
Track Wobble's ?
my son new sled sometimes won't move under load? Adjusted the track tension n aligned it the best I could with the adjuster bolts but the track wobble's a lot. When I spin the track by hand it spins freely for a bit then gets hard where I could hardly move it then releases n spins freely again.track is aligned in the rear but it seems like it's off in front
Current Answers
Related Manual Pages
Owners Manual - Page 18
YOUTH SECTION
Know Your Snowmobile
Let's learn more about the parts of your snowmobile before we learn about riding. Seat and Storage Taillight Handlebar Windshield Headlight Hood Front Bumper
Snow Flap Seat Latches Track Ski Trailing Arm
16
Owners Manual - Page 19
Always make sure the latches are securely latched before riding again.
Never wear clothing that could get close to a moving and hot parts of the engine. Drive your snowmobile only in a moving track, like a long scarf or baggy clothing.
Skis The skis help you start the engine. YOUTH SECTION
Know Your Snowmobile
Hood...
Owners Manual - Page 21
... have a sticky throttle. Hood Hold-Down Straps
Check the hood hold-down straps. Track and Skis
Never check the track or skis when the engine is hard to where it was before you want to the ground. You could get hurt if the snowmobile moves unexpectedly. Make sure the engine is frozen to ride...
Owners Manual - Page 23
... ready to learn about driving your snowmobile. ŹMake sure you know where all around you could get hurt. ŹDon't ride at least six (6) years old before you can ride this snowmobile. ... ride! The adult with you don't follow the safe riding rules found on roads or over railroad tracks. You or others can see you from fences. Rules are some things you 're a beginner, ...
Owners Manual - Page 24
...attention to where you from moving part. If you ride your snowmobile. Always watch out for objects or people in the track or another moving easily. Make sure your driving area and stay a safe distance away from them .
22 Wear warm...helmet or jacket. ŹLearn if there are tied. Baggy clothing could hang down and get caught in your clothing fits properly. Never ride on frozen water.
Owners Manual - Page 27
... are outlined on the checklist for proper operation or condition before each ride. Item
Throttle Brake Steering System Throttle Safety Switch Tether Switch Track Seat Hood Straps Track and Skis Gas and Oil Lights
Description
Check for proper operation Check for proper operation Check for proper operation Check for the child before...
Owners Manual - Page 30
...recommended. WARNING
Operating the snowmobile with a damaged track will void the track warranty.
28 This could severely damage the track.
TIP: Track damage or failure caused by operation under poor ...of situations that would provide marginal lubrication and are two examples of additional track damage and/or failure. Always inspect for extended periods of control, resulting in...
Owners Manual - Page 40
... hill. Accelerate before the start of a snowmobile. Apply just enough throttle to keep the clutch engaged.This will allow engine compression to prevent the track from rolling freely downhill.
38 Stand on hills. Driving Downhill
Drive downhill slowly. Driving Uphill
Driving uphill should dismount on the snow. 3. If the snowmobile stops while...
Owners Manual - Page 42
ADULT SECTION
Component Identification
Seat and Storage Taillight Rear Bumper
Handlebar Windshield Headlight Hood Front Bumper Ski
Snow Flap Rear Suspension Track Nosepan Trailing Arm
40
Owners Manual - Page 48
...the event of each ride, park the snowmobile on a level surface.
Support the rear with an appropriate snowmobile cover.
46 The track should be suspended approximately 4" (10 cm) off the ground. SYSTEM
Engine Stop Switch Throttle Safety Switch Tether Switch Brake Choke
WHAT...throttle or less
Daily Storage
At the end of an emergency. Cover the snowmobile with an appropriate track stand.
Owners Manual - Page 53
... EXTENDED PERIOD OF OPERATION 50 HRS 100 HRS 150 HRS
Check track alignment Check track condition Check drive chain tension Check and tighten any loose suspension mounting bolts Tighten ski saddle and spindle bolts if loose Check front and rear limiter strap condition, tighten loose bolts Check slider thickness, replace when worn (see dealer) Tighten rear idler...
Owners Manual - Page 58
... has excessive wear, see your POLARIS dealer for service.
1. Perform the adjustment procedures exactly as outlined, or see your POLARIS dealer for installation of a new band. With your right hand to the adjuster as outlined below.
3/4" (19 mm)
Brake Cable Adjustment
If proper adjustment cannot be achieved using the following methods, check the brake band.
Slide...
Owners Manual - Page 62
... with aerosol chain lube or SAE 30 oil.
ADULT SECTION
Maintenance
Driveline Lubrication
TIP: Driveline noise is normal for this vehicle.
Point A Engine Carburetor Point B Track
Torque Converter (Centrifugal Clutch)
Chain
Drive Shaft
60
Owners Manual - Page 65
... outward as shown. Bolt 4. Hang a 10-pound 8" (20 cm) 10 lbs. (4.5 kg) weight 8 (4.5 kg) inches (20 cm) from the center of the track clip and the plastic slider at this point should be sure they are removed, be 3/4" (19 mm). 6.
Stop the engine. 3.
Always maintain correct tension and alignment. 1. If the track tension needs adjustment, follow the...
Owners Manual - Page 66
... idler shaft bolt. 2. TIP: Check tension more frequently when the machine is not limited to the machine while the track is rotating. This includes but is new. Tighten or loosen the track adjusting screws to stop rotating by itself (do not apply brakes). 5. Start the engine and slowly rotate the track at least five revolutions. Check and adjust track alignment.
Owners Manual - Page 67
... to the right, loosen the right idler wheel mounting bolt and tighten the right track adjusting bolt. 4. lbs. (47-54 Nm). 5. After adjustments are evenly spaced on each side. WARNING
When performing the following checks and adjustments, stay clear of track. Inspect track alignment by looking through the track Rail windows to make sure the Slider rails are complete, tighten...
Owners Manual - Page 69
...-in the periodic maintenance chart beginning on page 50. Support the rear of each track rod, bending the track and inspecting for wear or damage. 3.
WARNING
Inspecting the track while the engine is found, install a new track. Rotate the track by hand to detach from the clip area and peel off the ground with the engine running...
Owners Manual - Page 70
... faster heat build up in limited lubrication than a used slider, resulting in order to the track or rails. TIP: Track damage or failure caused by operation on POLARIS snowmobiles can cause erratic steering.
WARNING
Improper alignment or adjustment may result in serious injury or death. Replace the rail slides if they are worn to...
Owners Manual - Page 73
... the underside of the ski. Replace skags when they are approximately 6" (15 cm) off the ground. 2. Skag Replacement
1.
TIP: See the dealer track studding and skag chart for new skag installation.
71 Raise and support the front of the machine so the skis are worn to half their original diameter. Remove the...
Owners Manual - Page 79
... ground with a fabric snowmobile cover. Plastic covers can cause condensation to hang freely. ADULT SECTION
Maintenance
Storage
Track and Suspension Support the rear of the machine and place blocks securely under it to remove tension from the shocks and springs. This will allow the track to form and may damage some snowmobile components.
77
Similar Questions
Snowmobile Is Jerking Moving Forward And In Reverse
As I said in the question title, the snomobile has developed a jerking motion when moving forward an...
As I said in the question title, the snomobile has developed a jerking motion when moving forward an...
(Posted by georgesb945 2 years ago)
