2012 Polaris Sportsman 550 EPS Support Question
2012 Polaris Sportsman 550 EPS Support Question
Find answers below for this question about 2012 Polaris Sportsman 550 EPS.Need a 2012 Polaris Sportsman 550 EPS manual? We have 1 online manual for this item!
Question posted by Anonymous-172057 on August 9th, 2022
Eps Stops Workin
when I pick up speed my battery icon comes on and I lose power steering. Can't figure out wy then when I slow down it turns off and the power steering works again
Current Answers
Answer #1: Posted by SonuKumar on August 9th, 2022 9:27 PM
SonuKumar
Member since:
May 9th, 2021 Points: 16,638,170
Member since:
May 9th, 2021 Points: 16,638,170
Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.
Regards,
Sonu
Your search handyman for all e-support needs!!
Related Manual Pages
Owners Manual - Page 16
...may result in a collision with another vehicle. Always operate at excessive speeds increases the operator's risk of losing control. Operating on Public Roads
Operating this ATV on this ATV. ...accident or overturn. In many states it 's unavoidable, travel slowly and avoid sudden turns or stops. Avoid operating the ATV on public streets, roads and highways. SAFETY
Safety Warnings
Carrying...
Owners Manual - Page 19
See page 33.
If all forward speed is lost: • Keep body weight uphill. • Apply the brakes. • Lock the parking brake when fully stopped. • Dismount on uphill side, or to either side if ATV is pointed straight uphill. • Turn the ATV around and remount, following the procedure described in the...
Owners Manual - Page 24
... or comes off, contact your skills or the conditions • on each label carefully.
passengers affect balance and steering and increase risk of the labels on hills and rough terrain and in turns •...labels have been placed on the label. Replacement safety labels are provided by POLARIS at speeds too fast for your vehicle, always read and follow the instructions on public roads - ...
Owners Manual - Page 28
...of control, which may result in reverse if the switch is equipped with a reverse speed limiter system. The vehicle automatically engages 4X4 when operating in serious injury or death. FEATURES...Switch
2x4
Mode/Reverse Override Button
4X4 Switch
Engine Stop Switch
Main Key Switch
Mode/Reverse Override Switch This vehicle is set to turn the lights on page 34. Always release the ...
Owners Manual - Page 29
... page 57 for extended periods and when operating uphill at a slow speed.
25 NOTICE: Shifting gears with the engine speed above idle or while the vehicle is Gear located on the... right side of the vehicle. When the engine is off all electrical power to the desired gear. FEATURES AND CONTROLS
Switches
Engine Stop Switch Move the stop...
Owners Manual - Page 30
... could result in an open position when the operator releases the throttle lever, engine speed will be limited, and power to idle when the lever is released. Engine speed and vehicle movement are controlled by pressing the throttle lever. Engine speed returns to the rear wheels will be reduced.
2x4
26 Always check the...
Owners Manual - Page 35
... factory-installed 18 AH battery cannot maintain a charge because of operation in a well ventilated area. Fuel Tank
Always refuel with the engine stopped, and outdoors or in extreme cold or with a minimum pump octane number of 87=(R+ M/2) octane. FEATURES AND CONTROLS
Electronic Power Steering (EPS)
Electronic power steering (EPS) engages when the ignition key is turned to allow for...
Owners Manual - Page 39
...the indicator stops flashing but remains illuminated, the overheating condition remains, and the system will automatically reduce engine power. EPS Warning This indicator illuminates when the key is turned to ...Cluster
Digital/Analog Gauge
Indicator Lamps
Lamp Indicates Vehicle Speed Over Temperature Condition When standard mode is selected, speed displays in miles per hour. Check Engine This indicator ...
Owners Manual - Page 46
... vehicle ground speed or engine speed. Gear Display 3 2 4 1 This area displays gear shifter position. H = High Gear L = Low Gear N = Neutral 5 R = Reverse Gear 13 P = Park -- = Gear Signal 6 Error (or shifter 12 between gears) 7 2. This area displays odometer, tripmeters, engine hour meter and programmable service hour interval. 3. If the instrument cluster fails to illuminate, a battery over...
Owners Manual - Page 47
...cooling fan, accessories) is activated. See your dealer.
5. All segments including the fuel icon will automatically reduce engine power. 7. See your dealer. 11. 4X4 Display - Clock Display - Service Reminder Display ... This icon displays when the 4X4 system is engaged (switch is on after starting the engine, the EPS system is operating at a higher RPM or recharge the battery to ...
Owners Manual - Page 48
... function and can be in revolutions per hour (km/h). Engine speed is locked out at any operating speed. FEATURES AND CONTROLS
Instrument Cluster
Multi-Function Display (MFD) Gauge (EPS Models)
Use the MODE button to toggle through the speed display options.
Use the SELECT button (SEL) to toggle through the information area options. Tip...
Owners Manual - Page 49
... displayed. 2. Release the button. 4. FEATURES AND CONTROLS
Instrument Cluster
Multi-Function Display (MFD) Gauge (EPS Models)
Display Units (Standard/Metric) The display can be viewed in operation.
45 Press and hold the MODE button until vehicle speed is displayed. 3. Press and hold the MODE button until the clock displays the new clock...
Owners Manual - Page 50
.... While still holding the MODE button, turn the key to change the service interval. 1. Press and hold the MODE button. 2. When the digits stop flashing, the interval has been set ,...Multi-Function Display (MFD) Gauge (EPS Models)
Programmable Service Interval When the hours of engine operation equal the programmed service interval setting, the wrench icon will flash for 5 seconds each...
Owners Manual - Page 54
...
Instrument Cluster
Diagnostic Display Code Definitions
SPORTSMAN 850 XP/850 XP EPS Diagnostic Codes
Component Throttle Position Sensor Engine Temperature Sensor Condition Voltage ... Voltage Too Low Voltage Too High Voltage Too Low Signal Out of Range Circuit Fault Plausibility Fault Speed Too High Plausibility Fault Voltage Too Low Voltage too high Signal fault Driver Circuit Open/Grounded Driver ...
Owners Manual - Page 55
... Wheel Drive Control
System Power Throttle Safety Signal
Active Descent Control System
Idle Speed
51 FEATURES AND CONTROLS
Instrument Cluster
Diagnostic Display Code Definitions
SPORTSMAN 850 XP/850 XP EPS Diagnostic Codes
Component Chassis ... Circuit Grounded Speed Too High Speed Too Low EPS Models Only Steering Over Current Shutdown Steering Excessive Current Error Steering Torque Sensor ...
Owners Manual - Page 57
...drive components. Drive slowly at 20 hours, one month or 500 miles (800 km), whichever comes first.
PVT Break-in (Clutches/Belt)
A proper break-in
1. OPERATION
WARNING
Failure to...belt by operating at sustained idle. 5.
See page 31. Avoid aggressive acceleration and high speed operation during the first three hours of operation will result in more efficient performance and longer...
Owners Manual - Page 100
...SPORTSMAN 550
SPORTSMAN 850 XP
SPORTSMAN 550 EPS 96
SPORTSMAN 850 XP EPS Reinstall the fuse box cover. 5. Spare... fuses are provided in the fuse box. 1. If the fuse is blown, install a new fuse with the same amperage rating. 4. Remove the suspect fuse from the fuse panel. Reinstall the front rack. MAINTENANCE
Fuse Replacement
If the engine stops...
Owners Manual - Page 118
... sealed and the sealing strip cannot be disconnected from a load or charger for recharging.
114 Stop charging if the battery becomes very warm to the charger manufacturer's instructions for recharging. The battery should be removed, you must use the guidelines on the next page for at least two hours before checking voltage. When...
Owners Manual - Page 127
...ignition connections Water present in fuel Low battery voltage Kinked or plugged fuel tank vent line Incorrect fuel Clogged air filter Reverse speed limiter malfunction Electronic throttle control malfunction Other... Replace with recommended fuel
Possible Rich Fuel Cause
Fuel is very high octane Stopping/starting without adequate warm-up Incorrect fuel Clogged air filter
Solution
Replace with ...
Owners Manual - Page 128
... the radiator fins and reduce cooling efficiency.
124 TROUBLESHOOTING
Engine Stops or Loses Power
Possible Cause
Out of fuel Kinked or plugged fuel vent line...Incorrect spark plug gap or heat range Loose ignition connections Low battery voltage Incorrect fuel Clogged air filter Reverse speed limiter malfunction Electronic throttle control malfunction Other mechanical failure Overheated engine...
Similar Questions
Carburator
overflow line from carburator will not stop dripping even when fuel line is shut off!
overflow line from carburator will not stop dripping even when fuel line is shut off!
(Posted by najjjbest 11 months ago)
2010 Polaris Ranger Ev
What would cause utv too work sometimes and just not work sometimes?? Was driving and just stop let ...
What would cause utv too work sometimes and just not work sometimes?? Was driving and just stop let ...
(Posted by gjarvis72 1 year ago)
Will Not Find Satellites
About a week ago my interactive display stopped finding satellites. It gives a message that saus it ...
About a week ago my interactive display stopped finding satellites. It gives a message that saus it ...
(Posted by acjonesmd 7 years ago)
Spedd Sensor
Hellowhere is the location speed sensor Polaris RMK 2012
Hellowhere is the location speed sensor Polaris RMK 2012
(Posted by vidar28436 8 years ago)
How Do I Begin The Polaris Warranty Claim Process?
My Polaris ATV just stopped working and I would like to know if it is under warranty.
My Polaris ATV just stopped working and I would like to know if it is under warranty.
(Posted by Anonymous-151447 12 years ago)