Home » Hyundai » Other » 2005 Hyundai Sonata

2005 Hyundai Sonata Support Question

Find answers below for this question about 2005 Hyundai Sonata.
Need a 2005 Hyundai Sonata manual? We have 1 online manual for this item!

Hyundai Overview Questions Manuals Reviews Videos Research

Question posted by bigmoose1954 on February 7th, 2016

Brake Pedal Will Not Pump Up.

2005 Hyundai Sonata 2.4L 5 Speed Standard Transmission (My stepson said it had ABS, but the people at Les Schwab couldn't find the ABS. I ran the Vin. number and it said that particular one didn't have one. Even though the master cylinder had 4 ports.)My step son had to take engine out to put in new clutch. When he put it back, the brakes would not work. We put in a new master cylinder. We bench bleed the new cylinder out of the car. We installed it and bleed it again. We started at the furthest point and worked are back to closest point. The brake pedal still wouldn't pump up. We even sent it to Les Schwab and have them check to see if it was put in properly and have them do a so called power bleed. Still no brakes. Can you help.

I Know the Answer!

I have the same question
Request More Information

Current Answers

Answer #1: Posted by TommyKervz on February 7th, 2016 9:45 PM

This answer was accepted by the poster of the original question.

TommyKervz

Member since:
January 10th, 2013

Points: 17,776,813

1,100
points

See all possible reasons here http://www.popularmechanics.com/cars/how-to/a92/1272501/.

Hope that is helpful.
Kervz at www.satechhelp.co.za

Related Manual Pages

Owner's Manual - Page 5

... not meet the specifications listed on your new car. Copyright 2005 Hyundai Motor Company. The advanced engineering and high-quality construction of poor quality fuels and lubricants that may be required. Hyundai dealers are pleased to welcome you to the growing number of your new Hyundai. Thank you for their use. All rights reserved. A050A04A...

Owner's Manual - Page 16

...speed from time to time. Leaving your absence. Don't start quickly or depress the accelerator pedal fully. o Don't tow a trailer during the first 1,200 miles (2,000 km). o Determine that the engine "bucks":shift to a lower gear). Sub key Master key B030A01NF For greater convenience, your Hyundai...economical operation and durability of your Hyundai has two master keys and a sub key. ...

Owner's Manual - Page 66

... not be added. WARNING: If you should be driven at any other safe method. FEATURES OF YOUR HYUNDAI 1 53 B260H02A-AAT Parking Brake/Low Brake Fluid Level Warning Light ! Also, the car will not stop in the brake master cylinder is low and hydraulic brake fluid conforming to "ON" or "START". Driving your car with dual-diagonal...

Owner's Manual - Page 68

... 1-93. When it comes on, add washer fluid at your Hyundai dealer immediately. It may come and go or be heard when the brake pedal is pushed down firmly. The fuel capacity is given in the ...in the fuel tank. To disengage the cruise control system, refer to "To cancel the cruise speed" on the steering wheel is pushed. The indicator light turns off when the cruise control ON/OFF...

Owner's Manual - Page 107

... system: o Depress the brake pedal. While the control switch is held, the vehicle will illuminate. 2. o Shift the selector lever to desired speed and release the control switch. B660B02NF B660E01NF-GAT To Reset at a Slower Speed B660C01NF B660D01NF To disengage the cruise control system, push the control switch "CANCEL". 1FEATURES OF YOUR HYUNDAI 94 B660C01NF-AAT...

Owner's Manual - Page 108

...speed driving of the switch changes the display as follows: This delay is activated or reactivated after applying the brakes... roads. If this happens, depress the clutch pedal or release the cruise control ON/OFF switch....particular attention to keep the car at a constant speed, for instance, driving in heavy or varying traffic, or on open highways in good weather. FEATURES OF YOUR HYUNDAI...

Owner's Manual - Page 140

...of a loaded slot is ON or OFF. When a disc is loaded into a particular slot (16), the number of all selections on the CD. (The CD scans in the audio system. o ...Press and hold the EJ button to engage auto eject. After the last track has been completed, the first track of the current disc. FEATURES OF YOUR HYUNDAI...

Owner's Manual - Page 145

DRIVING YOUR HYUNDAI Engine Exhaust Can Be Dangerous! ...2-2 Before Starting the Engine ...2-3 Key Positions...2-3 Starting ...2-4 Operating the Manual Transaxle ...2-5 Automatic Transaxle ...2-8 Power Adjustable Pedals ...2-11 Anti-Lock Brake System (ABS) ...2-12 Electronic Stability Control (ESC) System ...2-13 Good Braking Practices ...2-14 Driving for Economy ...2-15 Smooth Cornering ...2-16 ...

Owner's Manual - Page 147

...HYUNDAI 2 3 BEFORE STARTING THE ENGINE C020A01A-AAT TO START THE ENGINE C030A01E-AAT KEY POSITIONS C040A01A-AAT Before you start the engine, you should not be turned off all bulbs when key is in neutral and depress the clutch pedal... it to be turned from the ignition key cylinder while the car is equipped with a manual ...brake is locked by removing the key. When you release the key.

Owner's Manual - Page 150

... in neutral for at high speed (5,000 RPM or higher). HNF3020 When shifting into reverse gear, pull the misshift prevention tab and shift into 1st or R(Reverse) gear position. The clutch pedal should always be difficult until the transaxle lubricant has warmed up. Use the foot brake or parking brake to the transaxle. WARNING...

Owner's Manual - Page 152

... the brake pedal when shifting. The selector lever has 2 gates; CAUTION: Never place the selector lever in the "P" (Park) position unless the vehicle is a normal condition, and the shifting sequence will cause severe damage to hold the vehicle in the numeral indicator. The highly efficient Hyundai automatic transaxle has four/five forward speeds and...

Owner's Manual - Page 153

...no gears are engaged. To return to keep the engine speed below the red zone. Since sudden engine braking and/or rapid acceleration can be made automatically when the engine... stops, 1st gear is in accordance with the accelerator pedal depressed. The transaxle will automatically shift through a four/five gear sequence. DRIVING YOUR HYUNDAI 2 9 C090C01A-AAT C090F02L-GAT o R (Reverse):...

Owner's Manual - Page 154

... the -(DOWN) side to shift back to any of the forward positions with the brake pedal depressed, move the shift lever from a stop on a slippery road. o Always apply the footbrake when shifting from "R", "N", or "D" position to "P" position. 2 DRIVING YOUR HYUNDAI 10 o To maintain the required levels of vehicle performance and safety, the system...

Owner's Manual - Page 155

... the position of the accelerater pedal in motion. o In the event your vehicle at highway speeds. o Excessive depressing of the accelerator and brake pedals, turn the ignition key to...lose control of the switch, the pedals move rearward. o Never move the gear selector lever into "R". DRIVING YOUR HYUNDAI 2 11 POWER ADJUSTABLE PEDALS C090N03O-AAT C100A01NF-AAT Good Driving ...

Owner's Manual - Page 156

... these conditions the vehicle should not be able to hold down the brake pedal firmly in increasing the engine speed and acceleration. 2 DRIVING YOUR HYUNDAI 12 ANTI-LOCK BRAKE SYSTEM (ABS) Setting the driver's position 1) Be sure the parking brake is engaged. 2) Move the accelerator and brake pedals to the front most position by pushing the " " portion of the...

Owner's Manual - Page 158

... a safe speed. o If your car is equipped with the car out of the brake components. WARNING: Nothing should be any unusual operation of the shelf panel behind the rear seat. o After being parked, check to a lower gear so that the parking brake indicator light is out before driving away. o Don't "ride" the brake pedal. o Use...

Owner's Manual - Page 159

... DRIVING FOR ECONOMY o Under some conditions your Hyundai should be allowed to go. o Take care of your car in increased fuel consumption and also contribute to reduce fuel consumption. Check the tire pressures at a moderate speed, especially on the brake pedal may cause the brakes to overheat, which reduces their effectiveness and may freeze, apply...

Owner's Manual - Page 166

...sharp turns and rapid lane changes. 13.Avoid holding the brake pedal down a hill, shift into the curb, set the parking brake firmly, and put the transaxle in park or neutral ...the engine braking effect. When ascending a long grade, downshift the transaxle to a lower gear and reduce speed to be sure the brakes are still working . Use the parking brake or footbrake. 2 DRIVING YOUR HYUNDAI 22 8....

Owner's Manual - Page 197

... ATF SP III, DIAMOND ATF SP III, SK ATF SP III or other brands meeting the SP III specification approved by Hyundai Motor Co. Use only hydraulic brake fluid conforming to the maintenance schedule. F070E06A-AAT o Automatic Transaxle Fluid The fluid level should be inspected at those intervals specified in the maintenance...

Owner's Manual - Page 222

... is not, have it inspected by your Hyundai dealer and adjusted or repaired if necessary. 6 DO-IT-YOURSELFMAINTENANCE 24 G170A01A-AAT CHECKING BRAKE PEDAL CLEARANCE G180A01A-AAT CHECKING DRIVE BELTS G190A02NF-GAT BRAKE PEDAL (2.4L) Power steering Auto tensioner Generator 2.95 in. (75 mm) 0.12 ~ 0.31 in. (3 ~ 8 mm) Water pump pully Damper pulley G180A01L G160A01HR COMP G140D01NF...