Honeywell HW2000i Support Question
Honeywell HW2000i Support Question
Find answers below for this question about Honeywell HW2000i - Portable Inverter Generator.Need a Honeywell HW2000i manual? We have 1 online manual for this item!
Current Answers
Answer #1: Posted by Bruce7194 on October 14th, 2017 5:18 AM
Bruce7194
Member since:
September 17th, 2017 Points: 95,560
Member since:
September 17th, 2017 Points: 95,560
Please refer to the link below for the fuel line diagram of your product :
Related Honeywell HW2000i Manual Pages
Owners Manual - Page 2
...owning a Honeywell inverter generator!
Please use the spaces provided below to this information should you and others , be sure to your generator. Northshore Power Systems, LLC ...generator (model number and serial number) can cause you require product service or support. Ambient Temp.: Serial Number:
HW2000i 101440A 120V/12V 2.0kW 40oC
Phase:
1
Frequency:
60Hz
Engine RPM: 5000
Fuel...
Owners Manual - Page 5
... Screen ...24 Spark Plug Service ...25 Transporting Generator ...26 Storing Generator ...26
TROUBLESHOOTING ...27
SPECIFICATIONS AND WIRING DIAGRAMS 29
WARRANTIES ...33
NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY 33 NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY 34
INDEX ...37
MAINTENANCE PARTS 39
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
i
Owners Manual - Page 8
...household depends on wet surface. • Keep the generator out of reach of power would cause you or anyone in your electrical provider ...generator OFF and allow flames or sparks near the generator or where gasoline is stored. • NEVER overfill the fuel tank (there should be sure the area is not covered under Warranty.
2
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator...
Owners Manual - Page 11
... ‰ Screwdriver Universal Bit
Inspect for Damage
Carefully inspect generator for operation. Ambient Temp.: Serial Number:
HW2000i 101440A 120V/12V 2.0kW 40oC
Phase:
1
Frequency:
60Hz
Engine RPM: 5000
Fuel:
Gasoline
Insulation Class: F
FIGURE 3: Generator Nameplate Location HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
5
Package Checklist
CAUTION...
Owners Manual - Page 12
... to emergency generator power. Before using the generator, connect a copper wire (minimum 14 AWG) from generator can feedback into utility lines. Consult a licensed electrician for Back-up Power
DANGER
Before connecting to the intended use of manual and automatic.
Electrical current can be observed.
6
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual...
Owners Manual - Page 14
.... WARNING NEVER use Honeywell DC accessory cables (sold separately) available from generator to prevent generator damage.
8
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Overload Indicator Light
Set Tripped
Illuminates red when the generator is overloaded or if there is no power at outlets, see AC "Troubleshooting" on page 27.
4. Front and Back View...
Owners Manual - Page 15
...NEVER touch hot surfaces. The HW1000i model has a vented fuel cap. Primer Bulb (HW2000i model only) Provides primer fuel to the generator. HW2000i Model
Front and Back View Front and Back View
6
8
5
4 7
3
B A
1
2
F G
C
E D
J
I - D-Case Feet Provides stability to start engine.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
9 In DC operation...
Owners Manual - Page 17
... 6. ‰ Check extension cords-be sure cords are open. WARNING
NEVER operate generator in rain or snow, or when the generator is tilted or overturned, fuel spillage may enter generator.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
11 Inhalation of generator outlet. „ Equipped with proper plugs that contain grounding
blades.
BEFORE
STARTING...
Owners Manual - Page 18
... vents in the bottom of engine oil to the ON position. Move the choke to the RUN position.
ON position
7. HW1000i Model Only: Turn the fuel cap vent to keep the engine in and turned on page 6).
FIGURE 10: Fuel Cap Vent - ON position
12
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual
Owners Manual - Page 19
... times to the OFF position.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
13
HW2000i Model Only: Depress the primer bulb 3 times to supply fuel to prime the fuel lines.
9. NOTE: If the generator has a low fuel tank or has been run to empty before being refilled, the primer bulb may need to be depressed 30-50 times to...
Owners Manual - Page 20
... gets below the safety line. FIGURE 14: Overload Indicator Light (HW2000i model)
CAUTION Substantial overloading that temporarily lights the overload indicator light may damage the generator.
HW1000i / HW2000i Inverter Generator Owner's Manual AC Operation AC Operation
AC Operation
NOTE: DC power and AC power can be improved by installing a smaller diameter main fuel jet in the...
Owners Manual - Page 21
... appliance, or if rated load capacity of power would cause you will need to run appliances using drying feature greatly increases energy consumption) 1800-5000
60 / 100
65-175 55-250 750* 1200-1875 750-1500
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
15
Powering Appliances Powering Appliances
Powering Appliances
NOTE: In this manual, the term...
Owners Manual - Page 22
..., Deep Well* 250-1100
TABLE 2. Examples of the generator.
NOTE: Appliances in grey require a higher wattage output than the inverter generator will produce.
Typical Appliance Running Wattages
*Allow up or cord damage may go unnoticed.
16
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Be sure the appliance power rating does not exceed that have motors...
Owners Manual - Page 23
... home Only use
X X
X** X**
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
17
WARNING
Improper maintenance, or failure to your servicing dealer for recommendations applicable to correct a problem before performing any non-road engine repair establishment or individual. FREQUENCY*
MAINTENANCE TASK
Before each use
Fill fuel tank
X
Check engine oil...
Owners Manual - Page 33
...Faulty/bad spark plug. Dirty spark arrestor screen. No power at receptacles
PROBABLE CAUSE Engine switch or fuel valve off. TABLE 9.
Check/replace spark plug (page ...generator.
Add engine oil (page 19). Add engine oil (page 19).
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
27 fill with fresh fuel (page 22). vents. Troubleshooting - Drain fuel...
Owners Manual - Page 35
....6 58 / 26.3
2000 100 60 120 12-18
104q / 40q 14q / -10q
5000** OHV 4-cycle
125 1.5 / 5.7 0.48 / 450 0.024-0.028 / 0.6-0.7
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
29 SPECIFICATIONS AND WIRING DIAGRAMS
Model
HW1000i
DIMENSIONS
Length [in / mm]
18.1 / 459.7
Height [in / mm]
15.1 / 383.5
Width [in / mm]
9.6 / 243.8
Dry Weight [lb...
Owners Manual - Page 36
... DIAGRAMS WIRING DIAGRAMS
WIRING DIAGRAMS
HW1000i Model
30
www.honeywellgenerators.com
primary
_ AC + AC
DC breaker 5A
DC winding
#18 blue
secondary
#18 black
inverter
#16 black
AC breaker 10A
5-15R G W
~120V
#18 yellow / green
white
M
step motor/ fuel control
overload indicator light
fuel economy
switch
output indicator
light
ground terminal
HW1000i / HW2000i Inverter Generator...
Owners Manual - Page 37
31
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual
#16 black
_
AC + AC
primary
DC breaker 10A
DC winding
#16 blue
secondary
DC12V Outlet
front panel assembly
inverter
#14 black
AC breaker 20A
white
M
step motor/ fuel control
fuel economy
switch
overload indicator light
output indicator
light
on / off switch
Duplex 5-20RA
low oil indicator light...
Owners Manual - Page 39
... also available by a retail customer. Repair or replacement pursuant to this product intended to :
Northshore Power Systems, LLC Attention: Product Warranty and Service Dept. 4425 N Port Washington Road Suite 105 Milwaukee WI 53212-1082
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
33 This warranty excludes any repaired product shall be warranted for...
Owners Manual - Page 40
... shall be repaired or replaced by NSP. Repair or Replacement Cost. Northshore Power Systems, LLC (NSP), CARB, and EPA offer the following explanation of ... be performed at an authorized NSP Honeywell generator dealer.
34
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Fuel Tank Evaporative Emissions Control System
A. The ...Fuel line and fittings E.
Similar Questions
Need Fuel Line Diagram For 1000i Generator
(Posted by luckyballs1970 2 years ago)
I Am Looking For A Fuel Line Diagram For The Hw2000i
I have purchased a hw2000i and it looks as if the fuel lines are not connected at all. mostlikely th...
I have purchased a hw2000i and it looks as if the fuel lines are not connected at all. mostlikely th...
(Posted by markjohnson403 8 years ago)
How To Add A Primer Ball To Honeywell Hw2000i Inverter Generator
(Posted by jnunDragon 9 years ago)
I Have A Honeywell 2000i Inverter Generator I Need Some Information How To Putt
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
(Posted by marlon1960 10 years ago)