Honeywell HW1000i Support Question
Honeywell HW1000i Support Question
Find answers below for this question about Honeywell HW1000i - Portable Inverter Generator.Need a Honeywell HW1000i manual? We have 2 online manuals for this item!
Question posted by rotodisc on September 2nd, 2014
The Procedure For Adjusting Valves On The Hw1000i
Where can I find details on the procedure for adjusting valves on the HW1000i engine?
Current Answers
Related Honeywell HW1000i Manual Pages
Owners Manual - Page 2
... a Honeywell inverter generator!
Please use in a weather protected area only GROUNDED SYSTEM
Pour materiel electrique seulement Employez uniquement dans un emplacement a labri des intemperies
FIGURE 1: Generator Nameplate Location
Date of others to provide this manual thoroughly before operating the generator.
Ambient Temp.: Serial Number:
HW1000i
120V
Continuous 40oC
Power Output...
Owners Manual - Page 5
... ...23 Spark Plug Service ...25 Transporting Generator ...26 Storing Generator ...26
TROUBLESHOOTING ...29
SPECIFICATIONS AND WIRING DIAGRAMS 31
WARRANTIES ...35
NORTHSHORE POWER SYSTEMS CONSUMER LIMITED WARRANTY 35 NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY 36
INDEX ...39
MAINTENANCE PARTS 41
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
i
Owners Manual - Page 8
... while the engine is running at least 6 feet (2 meters) away from vibration.
Do not use plugs or cords that show signs of damage such as extension cords and power supply cords connected to it for use with gasoline / ethanol blends with over 15% ethanol.
2
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Generator sup- plies...
Owners Manual - Page 15
... filter, fuel filter, and oil fill cap. E-Recoil Starter Handle Starts engine. F-Back Maintenance Cover Provides access to the generator.
Engine Control Switch Turns the engine ON or OFF.
8.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
9 Efficiency Mode Switch When Efficiency Mode is ON, the engine speed will automatically adjust based on fuel tank.
Owners Manual - Page 19
... connecting any
connected power cords. 2.
Start the generator (see "Starting Generator" on . Monitor the overload indicator light. In normal use: 1. Turn the fuel cap vent to run for 2-3 minutes. 3. Connecting Appliances
Connecting Appliances
10. Allow the engine to the OFF position (HW1000i
model only). HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators...
Owners Manual - Page 21
...Furnace*
600-1200
Garage Door Opener
500-750
Hair Dryer
1200-1875
Heater, Portable
750-1500
Iron, Clothes
1000-1800
Light, Incandescent
15-100
Light, Compact ...power needed to start appliances with electric motors require additional power when starting wattage for starting watts. WORKSHEET
Appliance
Running Watts
Additional Starting Watts
HW1000i / HW2000i Inverter Generator...
Owners Manual - Page 23
... cause severe injury or death. If you cannot see Table 3).
If engine must be run, be performed by a service dealer. NOTICE
Maintenance, replacement... operate generator under severe conditions, such as sustained high-load or high-temperature, or use
X**
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
17 NEVER use
X
X X
Check/adjust valve clearance...
Owners Manual - Page 32
... cause the fuel to Table 8 for storage. Turn the fuel valve to turn engine and distribute oil. 6. Place rag over spark plug hole and pull recoil starter
handle slowly to the OFF position.
3. Storing Generator
NOTICE
Follow service procedures for preparing generator for recommended preparation procedures. Remove spark plug (see page 19). 3. Drain fuel into spark...
Owners Manual - Page 35
... monoxide.
No or low engine oil. Faulty/bad spark plug. Fuel cap vent closed. Clean spark arrestor screen (page 26). Restart the generator and wait for the output ready indicator light to illuminate green and stay on . No power at receptacle
Circuit breaker defective. Dirty spark arrestor screen.
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators...
Owners Manual - Page 38
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
32
ENGINE step motor / M
fuel control oil alert sensor spark plug
ignition coil
ENGINE BLOCK
GENERATOR
primary
#18 black
INVERTER
ALTERNATOR secondary
STEEL BASE
white
run / stop switch
efficiency mode switch
oil alert indicator output light indicator light
overload indicator
light
CONTROL PANEL
#16 ...
Owners Manual - Page 42
...emission control system. Where a warrantable condition exists, Northshore Power Systems will be designed, built, and equipped to ...valve
7. In the United States and California, new small off-road engines must warrant the emission control system on your small off -road engines (SORE) to the original retail customer.
36
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator...
Owners Manual - Page 8
... such as broken or cracked insulation or damaged blades.
• For power outages, permanently installed stationary generators are worn, frayed, bare, or otherwise damaged.
• NEVER operate generator in any way. • NEVER tamper with over 15% ethanol.
2
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Spilled fuel or fuel vapor may result in your...
Owners Manual - Page 15
...Efficiency Mode is ON, the engine speed will automatically adjust based on fuel tank. NEVER touch hot surfaces. HW2000i Model
Front and Back View
Front and Back View
6
8
5
4 7
B A
2000 RATED WATTS
3
2100 MAXIMUM WATTS
NEUTRAL FLOATING NEUTRE FLOTTANT
1
2
F
G C
I - HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
9 Choke Control Controls choke valve.
Owners Manual - Page 19
...If appliance begins to the OFF position (HW1000i
model only). HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
13
Press the engine control switch to the OFF position.
11. After the engine starts, let run continuously and warm up before connecting any
connected power cords. 2. Do not restart generator until the reason for 2-5 seconds and then...
Owners Manual - Page 21
... to verify the selected appliances can be powered without exceeding the generator capacity. Appliance
Running Watts
Air Conditioner, ...Garage Door Opener
500-750
Hair Dryer
1200-1875
Heater, Portable
750-1500
Iron, Clothes
1000-1800
Light, Incandescent
15-...
Appliance
Running Watts
Additional Starting Watts
HW1000i / HW2000i Inverter Generator Owner's Manual
Total Running Watts Highest...
Owners Manual - Page 23
...engine repair establishment or individual. NOTICE
The maintenance schedule applies to your individual needs and use
X
X X
Check/adjust valve clearance
Check fuel line
Every 2 years (replace if necessary)**
TABLE 3. Generator...• Shut off engine before operation, can cause severe injury or death.
Only use
X**
HW1000i / HW2000i Inverter Generator Owner's Manual
www....
Owners Manual - Page 32
... control switch to the OFF position.
3.
Change engine oil (see page 25). 4. Reinstall spark plug.
26
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual Transporting Generator
Transporting Generator
Transporting Generator
WARNING
• Hot engine or exhaust system can result in a vehicle. Turn the fuel valve to the STOP position.
2. Remove spark plug...
Owners Manual - Page 35
.... Check electrical appliance/equipment for "tripped' position. HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
29 NEVER use OUTSIDE and far away from the generator. PROBLEM Engine will not start or starts and runs rough
Engine suddenly stops
PROBABLE CAUSE Engine switch or fuel valve off . No or low engine oil. Spark plug wire (cap) disconnected. Dirty...
Owners Manual - Page 38
HW1000i / HW2000i Inverter Generator Owner's Manual
www.honeywellgenerators.com
32
ENGINE step motor / M
fuel control oil alert sensor spark plug
ignition coil
ENGINE BLOCK
GENERATOR
primary
#18 black
INVERTER
ALTERNATOR secondary
STEEL BASE
white
run / stop switch
efficiency mode switch
oil alert indicator output light indicator light
overload indicator
light
CONTROL PANEL
#16 ...
Owners Manual - Page 42
... your small off -road engines (SORE) to the original retail customer.
36
www.honeywellgenerators.com
HW1000i / HW2000i Inverter Generator Owner's Manual You are specified as defined in above systems
A. Clamps C. Gasoline carburetor and internal components (if equipped)
2. Fuel cap C. Fuel tank D. Ignition coil B. Exclusions. Exhaust System
A. Northshore Power Systems, LLC, CARB...
Similar Questions
Need Fuel Line Diagram For 1000i Generator
(Posted by luckyballs1970 2 years ago)
Honeywell Hw1000i Generator 144f 10070149 Engine Parts
I am trying to find the engine cylinder valve retainer that holds the spring in place for the valve....
I am trying to find the engine cylinder valve retainer that holds the spring in place for the valve....
(Posted by eric83489 2 years ago)
Gas Tank Hw 1000i
are new tanks available the one I have is rusted inside
are new tanks available the one I have is rusted inside
(Posted by tgidd 4 years ago)
How To Add A Primer Ball To Honeywell Hw2000i Inverter Generator
(Posted by jnunDragon 9 years ago)
I Have A Honeywell 2000i Inverter Generator I Need Some Information How To Putt
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
someone take it appart i manage to put it togeather but have on idea where all the fuel and vent lin...
(Posted by marlon1960 10 years ago)