Honeywell HE220 Support Question
Honeywell HE220 Support Question
Find answers below for this question about Honeywell HE220.Need a Honeywell HE220 manual? We have 1 online manual for this item!
Question posted by jedberg on February 1st, 2012
Installing New Honeywell He220 Humidifier And Can't Get Unit To Run
I have intstalled a new HE220 humidifier and am trying to troubleshoot why I can't get it to run... I think the solenoid is bad. If I bypass both the humidistat and pressure switch and wire both ends of the transformer to the humifier should the unit run ?
Current Answers
Related Honeywell HE220 Manual Pages
Owner's Manual - Page 1
... new Honeywell HE220 or HE260 Humidifier, H8908 Humidistat and all the accessories required for the Installation
Be sure to identify all the required (Table 1) accessories (included) and make sure the appropriate tools are steadily improving. INSTALLATION
Preparing for installation.
Quantity 3 ft (0.93m)
20 ft (6.2m) 20 ft (6.2m) 10 ft (3.1m)
1 bag
1 1 1 bag
1
Accessory
Bypass ducting...
Owner's Manual - Page 2
... furnace body to the humidistat.
69-1645EF
2 Make sure that the 20 ft (6.2m) of thermostat wire is adequate to reach from the humidifier solenoid, to the sail switch, to allow operation of the sail without affecting the smooth flow of air in front of and above the
humidifier so you install the Honeywell Whole House Drum or...
Owner's Manual - Page 3
... and closed positions. remove the cover and take out the humidifier pad assembly. Installing humidifier on the plenum in the location chosen for a 6 in . (155 mm) starter collar as necessary, to mark the opening .
6.
For the HE220 model, cut the rectangular opening for the bypass.
10. Use a drill, punch or awl to assist in the...
Owner's Manual - Page 4
... foam adhesive. Repeat steps a. SUMMER WINTER
M20173
Fig. 6. Connecting bypass ducting.
15. The valve is not designed to tap into the humidifier port and secure with clamps provided.
69-1645EF
4 SCREW DRIVER
WATER LINE
HUMIDIFIER PORT PLAIN COLLAR
M20175
M20785
Fig. 7. HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
1. CAUTION
Chemical Hazard. f. c. If tapping into galvanized...
Owner's Manual - Page 5
... tubing to the switch as shown in place that is attached to the bracket marked Up. These springs offset the effect of gravity for installation. UP
M3014
Fig. 11. For horizontal mounting, level the long dimension shown on the template.
BRASS COMPRESSION NUT PLASTIC COMPRESSION RING
BRASS INSERT
HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
IMPORTANT...
Owner's Manual - Page 6
...the wire loop. Humidistat base and rear view. After wiring, snap on the duct with the H8908 Humidistat Installation Instructions) to the duct using the sheet metal screws provided.
7. Remove the H8908 case from the base. 4. INSERT SAIL -
Attaching sail to the leads and replace the H8908 case.
Wire the humidifier solenoid valve, sail switch, humidistat and transformer...
Owner's Manual - Page 7
... continuously down and ends at both black conductors to the sail switch.
2. At the humidifier, connect the black and white conductors to the two yellow humidifier wires. (The red wires from the humidistat to the two humidistat terminals. As the vapor circulates, the relative humidity rises. HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
1. TESTING HUMIDIFIER OPERATION
Checklist
❑...
Owner's Manual - Page 8
...with pressurized water (a running to clean than soft water deposits. Replace the humidifier cover. 18. Verify the humidifier operation by grasping the top of the tray and pulling it toward you . 4.
Turn the humidistat to its highest setting and set
the thermostat to check your humidifier operation:
1. able setting for Correct Operation section. HE220, HE260 HUMIDIFIER AND INSTALLATION...
Owner's Manual - Page 9
... rubber pad is needed.
9
69-1645EF Drain tubing
Verify no obstructions.
HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
TROUBLESHOOTING YOUR HUMIDIFIER
Problem Water leakage No water to click.
Furnace blower not operating.
• Reset circuit breaker or check for solenoid to trim sail, if necessary.
Humidifier power
Verify that sail can move freely in use. • Keep...
Owner's Manual - Page 10
... FOR A PARTICULAR PURPOSE, IS HEREBY LIMITED TO THE ONE YEAR DURATION OF THIS WARRANTY. HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
LIMITED ONE-YEAR WARRANTY
Honeywell warrants this limitation may not apply to you.
THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON THIS PRODUCT. If you may have any time during the warranty period...
Owner's Manual - Page 11
HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
11
69-1645EF
Owner's Manual - Page 12
www.honeywell.com/yourhome
HE220, HE260 HUMIDIFIER AND INSTALLATION KIT
Automation and Control Solutions
Honeywell
Honeywell Limited-Honeywell Limitée
1985 Douglas Drive North
35 Dynamic Drive
Golden Valley, MN 55422
Scarborough, Ontario
M1V 4Z9
69-1645EF G.H. 9-02
Printed in U.S.A. on recycled paper containing at least 10% post-consumer paper fibers.
Similar Questions
Was Working Great Last Winter. Cleaned Unit And Plugged In And Won't Turn On.
Have Model HVM 250 series. Depressing power button produces clicking sound and lite goes amber on le...
Have Model HVM 250 series. Depressing power button produces clicking sound and lite goes amber on le...
(Posted by mary64808 10 years ago)
Wireing To The Power Supply
How do i wire the transformer to the power source so the drum only rotates when the blower is runnin...
How do i wire the transformer to the power source so the drum only rotates when the blower is runnin...
(Posted by laptop12345 11 years ago)
He220a - Noisy.
Just installed a HE220 A. It is working fine but is quite noisy! Is this typical for this unit or is...
Just installed a HE220 A. It is working fine but is quite noisy! Is this typical for this unit or is...
(Posted by tedkapp 13 years ago)