Hayward PowerFlo Matrix Support Question
Hayward PowerFlo Matrix Support Question
Find answers below for this question about Hayward PowerFlo Matrix.Need a Hayward PowerFlo Matrix manual? We have 1 online manual for this item!
Question posted by edklein5231 on June 23rd, 2013
Powerflo Matrix Pump Positioning Button
where is the positioing button physically located on the pump housing. I already took off the strainer "C" clip,
Current Answers
Related Hayward PowerFlo Matrix Manual Pages
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 1
...
The Hayward Power-Flo® Matrix™ Pump Series is specifically engineered for the demanding requirements of this product. Corporate Headquarters: 620 Division Street Elizabeth, NJ 07207
U.S.A: 1 Hayward Industrial Drive Clemmons, NC 27012
2935 Sidco Drive Nashville, TN 37204
2875 Pomona Blvd.
WARNING -
SAVE THIS INSTRUCTION MANUAL
HAYWARD POOL PRODUCTS, INC. Plaine de...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 2
...pressure wire connector provided on the motor housing and to all metal parts of swimming pool, spa, or hot tub, and to all times. Power-Flo Matrix™ Pump Series
PRODUCT REGISTRATION
(Retain For Your...used with storable pools. Bond motor to reinforcing rod or mesh.
The Power-Flo Matrix™ Pump Series is constructed in a building such that it cannot be positioned to prevent their...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 3
...trimmers and other
equipment/components of a swimming pool filtration system operate under pressure.
DANGER - Hazardous Pressure. WARNING - Locate cord to electric supply. To reduce the risk... to do all pressure tests.
Power-Flo Matrix™ Pump Series __________
NOTE: The National Electrical Code (NEC) permits use the pool or
spa if a drain cover is damaged, cracked...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 4
... for easy disengagement of strainer housing in this manual MUST be followed precisely. Power-Flo Matrix™ Pump Series
Product Specifications
Dimensions
General Information
Introduction
This manual contains information for the proper installation and operation of pump
Installation Instructions
Pump Location
For best pump performance, locate the system below the pool water line.
The...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 5
... the tape clockwise as you may cause cracking of tape. Ground motor before use a tool to local codes and regulations.
Power-Flo Matrix™ Pump Series
Installation Instructions (cont.)
Pump Location (cont.)
Install pump on electrical connections. NOTE: Do NOT use , it may cause damage. WARNING -
Plumbing
To facilitate servicing of the fitting, beginning at...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 6
...housing and to all electrical equipment, metal piping or conduit within 5 ft. (1.5 m) of inside walls of swimming pool, spa, or hot tub, and to electrical service ground. New Installation - CAUTION - Power-Flo Matrix™ Pump... electrician).
NEVER operate the pump without water. Fill strainer housing with water to prevent dirt, bugs, etc., from pump and piping system. Reset if...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 7
... positioning button located on strainer 'C' clip and remove.
(See Fig. 1) ƒ Slide strainer housing forward and remove. See filter owner's manual. ƒ When water source is higher than the pump, pump will only rotate ¼ turn.)
Figure 1
Step 4: Assemble the pump by following the above directions in the reverse manner.
Storage/Winterization
WARNING -
Small children using pool...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 8
... base. 2.
C. SAVE THESE INSTRUCTIONS
Exercise extreme care in a dry enclosure. Lift up on strainer 'C' clip and remove. Storing Pump For Winterization
WARNING - Once the pump is removed of motor opposite the impeller.
Disconnect all electrical power service to the pool. 2. Only qualified personnel should always be observed including the following. Do not use this product...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 9
... and evenly.
15. Install strainer 'C' clip by sliding strainer housing onto pump cover. Bypass it is corrected...pump to cut On/Off until the pump housing is full of the pump housing recess. Centrifugal switch stuck in OPEN position. 2. Power-Flo Matrix™ Pump Series
Shaft Seal Change Instructions (cont.)
5. Open all valves and make sure that the pump strainer housing...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 10
... - Cavitation due to ensure that skimmer weir is properly seated in pool, and
unrestricted discharge return lines.
Power-Flo Matrix™ Pump Series
Troubleshooting (cont.)
Pump Won't Prime
1. Check if all threaded connections for clogging or obstruction in pump housing. Open housing cover and check for suction leaks. Holding hand over the bottom port with water...
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 11
..., Flex 48
1
1 ½ HP Motor with Switch, Flex-48
1
2 HP Motor with Switch, Flex-48
1
2 ½ HP Motor with Lock Ring & 'O' Ring
10
Strainer Cover 'O' Ring
10
Strainer Basket
10
Strainer Retainer/ 'C' Clip
10
Strainer Housing
1
Drain Plug w/ Gasket
10
Strainer 'O' Ring
10
Screw, #14 x 1/4" Type B Pan Head
80
Pump Cover
4
Housing 'O' Ring
10
Impeller (Refer to Part No.
Models: SP1591 SP1592 SP15922S SP1592FT SP1592FTTL SP1592TL SP1593 SP15932S SP1593FT SP1593FTTL and SP1593TL - Page 12
...of freezing, negligence, improper installation, use in a safe and convenient location for cartage, removal and/or reinstallation labor or any other rights,...Pump housing/strainers which fail or become defective during the warranty period, except as the result of this pump, Hayward Pool Products, Inc. Power-Flo Matrix™ Pump Series
__________
HAYWARD® LIMITED WARRANTY
This pump...
Similar Questions
Hayward Power-flo Matrix Cant Push Positioning Button
(Posted by b5walkin 9 years ago)
Where Is Positioning Button On Hayward Matrix Pump
(Posted by solidnpeas 10 years ago)
Where Is The Positioning Button On A Hayward Power Flo Matrix Pump
(Posted by ajeefmaril 10 years ago)
Where Is The Positioning Button On The Power Flo Matrix Pump
(Posted by dijpa 10 years ago)
Positioning Button
Where in the Positioning button on the Hayward Power-Flo Matrix 1.5 HO
Where in the Positioning button on the Hayward Power-Flo Matrix 1.5 HO
(Posted by haybut 10 years ago)