Home » Hayward » Pool & Spa » Hayward Aqua Solar GL-235

Hayward Aqua Solar GL-235 Support Question

Find answers below for this question about Hayward Aqua Solar GL-235.
Need a Hayward Aqua Solar GL-235 manual? We have 1 online manual for this item!

Hayward Overview Questions Manuals Reviews Videos Research

Question posted by Mdivalentin on July 4th, 2022

Automatic Not Working Correct

My controller with turn valve to turn on solar but doesn't turn off when the solar is in sha

I Know the Answer!

I have the same question
Request More Information

Current Answers

Answer #1: Posted by SonuKumar on July 10th, 2022 5:32 AM

This answer was accepted by the poster of the original question.

SonuKumar

Member since:
May 9th, 2021

Points: 16,622,390

1,100
points

https://www.youtube.com/watch?v=Svio-_Bc1Gc

https://www.youtube.com/watch?v=9a6RTJvblcg

https://www.youtube.com/watch?v=aNFVt7qWQdg

Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful.

Regards,
Sonu
Your search handyman for all e-support needs!!

Answer #2: Posted by Odin on July 4th, 2022 5:13 PM

Odin

Member since:
April 10th, 2010

Points: 41,236,680

100
points

See https://www.manualslib.com/manual/383249/Hayward-Aqua-Solar-Gl-235.html?page=3#manual. The answer may be prvided by the second multi-line paragraph on the page.

Hope this is useful. Please don't forget to click the Accept This Answer button if you do accept it. My aim is to provide reliable helpful answers, not just a lot of them. See https://www.helpowl.com/profile/Odin.

Related Hayward Aqua Solar GL-235 Manual Pages

Model: GL-235 - Page 1

..., test, and return freight for warranty repair replacement. 620 Division St. Aqua Solar GL-235 Electronic Solar Control Operation and Installation Manual GL-235 www.haywardnet.com No wholesaler, agent, dealer, contractor, or other person... warranty service or repair, please contact the place of Hayward Pool Products with Hayward. Hayward will be included) unless you already have an open...

Model: GL-235 - Page 2

... and activate freeze protection. The output controls a 24VAC automatic valve actuator. Power input Turn off at 1.5ºF Desired Pool Temp.: 70-104ºF calibrated scale or Solar Off, 75 (24ºC) 104ºF (40ºC) on next page. Low Voltage (LV) output: Solar Valve The GL-235 controls a single valve. Refer to the chart below for pools that overheat in hot climates) and...

Model: GL-235 - Page 3

.... Also check that the control circuitry is an internal failure and the GL-235 will have to be a possible open circuit or short circuit with silicon to minimize wind cooling. Reconnect the pool sensor and verify that the actual pool temperature, and the solar sensor is an internal failure and the GL-235 will require replacing the fuse...

Model: GL-235 - Page 4

... is unprotected in the event of Pool Sensor (Use the same method to measure the Solar Sensor) Figure 5 9 Hayward strongly recommends the use a non-positive seal valve or drill a hole (1/8"--1/4") in the diverter of the main circuit board. The GL-235 is shipped from the pool to be used on a GL-235, either : • The filter pump must...

Model: GL-235 - Page 5

... the pool/spa temperature is being used for approximately 10 seconds while it stabilizes temperature readings). In the "AUTO" position, the GL-235 will show when the system is collecting solar heat. Move the switch to "MANUAL TEST" and verify that both the "Heating" and "Cooling" indicators light and that the valve(s) are off to correct. To...

Model: GL-235 - Page 6