GE GG40T06PVK Support Question
GE GG40T06PVK Support Question
Find answers below for this question about GE GG40T06PVK.Need a GE GG40T06PVK manual? We have 2 online manuals for this item!
Question posted by shaloNO on August 30th, 2014
How To Reset A Ge Water Heater Lockout
The person who posted this question about this GE product did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related GE GG40T06PVK Manual Pages
Use and Care Manual - Page 1
... to explain the features, operation, safety precautions, maintenance and troubleshooting of this water heater read carefully and keep in USA
DESIGN
CERTIFIED
®
Manufactured under trademark license... professional advice. With Installation Instructions for the Installer
Gas Residential
®
Water Heaters Residential 40 and 50 Gallon
The purpose of this manual. This manual also...
Use and Care Manual - Page 2
...IF YOU NEED SERVICE
If you time and money over the life of your water heater. There are very important. A potentially hazardous situation that will result in ...or serious injury.
Recognize this manual. All safety messages will find many helpful hints on your water heater properly. WARNING
! Attention is only a phone call away. Proof of Important Safety Information!
...
Use and Care Manual - Page 3
...never operate this manual, or have problems understanding the instructions in unsafe operation of the water heater. Should you time and money.
Be sure to the Safety Instructions. Gasoline, as ... dangerous. Failure to install the blower assembly and properly vent the water heater to do so can result in this water heater unless it is properly vented and has an adequate air supply for...
Use and Care Manual - Page 4
... regulations the gas control (thermostat) was shipped from the factory. See instruction manual before setting temperature at its lowest setting before bathing or showering. Feel water before the water heater was set at water heater. DANGER: Households with small children, disabled, or elderly persons may be considered when selecting the...
Use and Care Manual - Page 5
... may not physically be safe.
5
Troubleshooting Tips
Customer Service Care and Cleaning
● Water heaters utilizing LP gas are unsure or unfamiliar with great caution. LIQUEFIED PETROLEUM (LP -
It... DANGER: If a gas leak is recommended that must be corrected. A natural gas water heater will collect first in your building. ● Leave the house immediately and make sure ...
Use and Care Manual - Page 6
... gas shut-off valve and how to shut off if necessary. SAFETY PRECAUTIONS
Have the installer show you may call 916-445-8100 or ask a water heater dealer. SAVE THESE INSTRUCTIONS
Care and Cleaning
Troubleshooting Tips
Customer Service
6
FOR INSTALLATIONS IN THE STATE OF CALIFORNIA
California Law requires that residential...
Use and Care Manual - Page 7
... restrict air flow to physical damage, for adequate inspection and servicing.
● The water heater may be installed under the water heater. Location
The water heater should be used or stored.
These kits must be used or stored.
A gas fired water heater or any water heater distributor. If the clearances stated on the Instruction/Warning Label, located on the label...
Use and Care Manual - Page 8
... gas leaks from outdoors, directly or through a gas flame corrosive elements are to the water heater requirements. DO NOT block or obstruct any obstruction. A minimum of less than 100 square...combustion air inlet openings located around the perimeter of the water heater requires air for possible damage. If the water heater is due to communicate with other debris.
Protective screening ...
Use and Care Manual - Page 9
...the resulting rapid, and repeated expansion and contraction of components in the cold water line between the water heater and the check valve (see illustration below for servicing if necessary.
Local codes... Care and Cleaning
Troubleshooting Tips
IMPORTANT: Do not apply heat to fixtures
HOT
Water Heater Jacket
COLD
Temperature and pressure relief valve
Manual gas shut-off valve: See (...
Use and Care Manual - Page 10
... working pressure of the relief valve above a suitable open the shut-off valve in the cold water supply line.
The water heater warranty does not cover damage or failure resulting from the water heater and piping. To Fill the Water Heater
Make certain that the drain valve is supplied and must be of the relief valve and...
Use and Care Manual - Page 11
...water heater.
The water heater must be installed in the gas line close to the water heater.
Safety Instructions Installation Instructions Operating Instructions
WARNING: Do not attempt to convert this water heater... for the altitude at normal operating pressures before it is intended to the water heater must be T-Handle type. At higher elevations the actual input rate may be...
Use and Care Manual - Page 12
...manual have been used should be kept in this manual before completing the installation and putting the water heater into any components in the system. Operating Instructions Installation Instructions Safety Instructions
Installing the water heater.
The water heater must be adequately supported along both vertical and horizontal runs. Do not support, pin or otherwise secure...
Use and Care Manual - Page 13
... equal to 3 feet of pipe. One 45° elbow is approximately equal to vent with a two-inch Schedule 40 PVC 45° vent terminal. This water heater is approximately equal to 2.5 feet of horizontal pipe.
Minimum vent length for both 2" and 3" vent terminals have been included. Care and Cleaning
Troubleshooting Tips
Customer...
Use and Care Manual - Page 14
Operating Instructions Installation Instructions Safety Instructions
Installing the water heater.
Caulk
Rising moisture will collect under eaves
If soffit vent is recomen
WARNING: Moisture in the flue gas will require maintenance. All painted surfaces should ...
Use and Care Manual - Page 15
...flashing where the vent pipe passes through the roof and interior ceiling to the water heater's vent connector fitting on the following minimum clearances and considerations (see illustration):
Minimum...terminal height and cut vent pipe accordingly. Mortar or Silicone Caulk Vent Pipe From Water Heater
Pipe Coupling
Horizontal Vent Installation
2' x 2' Sheet Metal Shieldon Brick or Masonry Walls...
Use and Care Manual - Page 16
...and American Society for the
motion until enough time has passed to allow primer to the water heater vent connection. NOTICE: Stir the solvent cement frequently while using. The proper brush size ...: This unit is known to the pipe end and insert
Appropriate solvent and
pipe into the water heater installing a condensate trap and drain is one inch.
Observe all dirt, grease or moisture. ...
Use and Care Manual - Page 17
... be connected to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation.
VERIFY PROPER OPERATION AFTER SERVICING!
17 The water heater must be installed on a GFCI circuit.
If local codes do not permit the use of conduit or metal-clad cable connectors. Refer to the black ...
Use and Care Manual - Page 18
...those authorized by installation, attachment or use on the exterior of the water heater or the area where the combustion air inlet openings and Flammable Vapor Sensor are not necessary... condition. CAUTION: If local codes require the application of an external insulation blanket to this water heater, pay careful attention to the following so as not to restrict combustion air flow to the...
Use and Care Manual - Page 19
... best meets your installation needs.
Blower Assembly Dilution Air Holes
Location of this water heater where
standing water may require an additional 90° 3/4" NPT elbow or a 3/4" coupling ... designed to be sealed utilizing a gasket and tamper resistant screws. See Illustration of the water heater jacket.
❑ DON'T block or restrict the Blower
Assembly Dilution Air holes.
❑...
Use and Care Manual - Page 30
...Normal operation. Ignition Failure.
ECO Failure. Lockout condition. Lockout condition. Pressure Switch Fails to Open. Refer repairs to reset control. Flammable Vapors Present.
●...Lockout condition.
Line/Neutral Polarity Failure. Lockout condition. l● Clean any scale buildup from gas line. (Refer to water heater is too high, the valve will not operate. Lockout...
