2012 Ford F550 Cab Support Question
2012 Ford F550 Cab Support Question
Find answers below for this question about 2012 Ford F550 Cab.Need a 2012 Ford F550 Cab manual? We have 2 online manuals for this item!
Question posted by llaqjolsza on February 26th, 2014
How Many Miles On A 2012 Ford F550 Before Need To Feel Up Diesel Exhaust Fluid
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
... protection, and corrosion protection using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Refer... additive can cause severe engine damage. Vehicle speed will need to be replenished at certain intervals. button after the ... cooling loop to help reduce emission levels of oxides of diesel exhaust fluid (DEF) which must be energized decreases as determined by ...
Diesel Supplement 3rd Printing - Page 7
...the light illuminates when the engine is contaminated and/or low. Low/contaminated diesel exhaust fluid: With the key in the on position, this supplement for more information. ...or failure of manifold air pressure in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) See Diesel exhaust fluid in the Maintenance and Specifications chapter for the drain procedure....
Diesel Supplement 3rd Printing - Page 9
...allow it to low or contaminated diesel exhaust fluid (DEF). If the engine fails to start the turns off ) and wait 30 seconds before the glow plug activation time ends, the glow plugs will need to be reset by turning the ...may occur. engine until the oil pressure gauge indicates normal pressure. 9
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) This is -10°F (-23°C) or colder.
Diesel Supplement 3rd Printing - Page 11
... has not been properly formulated for the ambient conditions. For best results in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Your vehicle is installed correctly in ...Diesel fuel which uses diesel exhaust fluid (DEF) to operate properly. To avoid engine fuel starvation during cold weather operation of 32°F (0°C) or below 32°F (0°C), the engine may need...
Diesel Supplement 3rd Printing - Page 17
...enter into an idle-only mode. Roadside Emergencies
JUMP STARTING YOUR VEHICLE The 6.7 diesel engine can also enter into a speed limited mode and can be jump started...until DEF is refilled. RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your vehicle runs out of jump starting procedure and refer to your Owner's Guide for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)...
Diesel Supplement 3rd Printing - Page 26
...in this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The system automatically injects diesel exhaust fluid (DEF) into the exhaust system to be filled ...fuel tank or fuel system if the correct genuine Ford or Motorcraft fuel filler cap is venting ...equipped with a fuel filler cap that is low and needs to enable proper SCR function.
When you see Filling the...
Diesel Supplement 3rd Printing - Page 27
...miles (805 km) remaining before DEF is not replaced, the vehicle will become limited to this occurring a message will result in the message center.
27
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Environmental Protection Agency (EPA): • Within a certain number of your vehicle's exhaust...operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low ...
Diesel Supplement 3rd Printing - Page 35
... when the tank is full. Filling the DEF tank in the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Additionally, if the message center indicates EXHAUST FLUID UNDER 1/2 FULL, you should only add a MAXIMUM of 2 gallons (6.7L) of miles (kilometers) to overfilling. Maintenance and Specifications
• DEF filling station nozzle fill: Filling...
Diesel Supplement 3rd Printing - Page 37
...)
Driving style DEF usage
Steady highway driving 7300 miles (11748 km) - 8900 miles (14323 km)
37
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Your usage may vary depending on: driving style, trailer towing, loaded vehicle weight, weather, idle time, PTO usage, etc. Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate...
Diesel Supplement 3rd Printing - Page 57
... the filter needs to be cleaned in the system it begins to a diesel oxidation catalyst, that reduces the amount of harmful exhaust emitted from ...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The frequency and duration of regeneration will then be reduced or oxidized (burned) thus cleaning the filter. Maintenance and Specifications
DIESEL EXHAUST SYSTEM: OXIDATION CATALYST/DIESEL...
Diesel Supplement 3rd Printing - Page 63
... with emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after...Ford recommends against any part of the exhaust system until it and the metal floor of the vehicle from the engine and exhaust...result in elevated exhaust gas temperatures which ... holes, in the tailpipe section of the exhaust, clean and free of debris or foreign ...
Diesel Supplement 3rd Printing - Page 67
..., although a fuse may result in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If this fuse... dealer for a circuit check. MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre-filter FA-...event of a higher rating. Failure to low or contaminated diesel exhaust fluid (DEF). Higher rated fuses or circuit breakers could allow...
Diesel Supplement 3rd Printing - Page 68
... / WSS-M99C130-A
5 gallons (18.9L) 6 gallons (22.7L)
Diesel Exhaust Fluid (DEF) - 68 MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES Item Motorcraft Specialty Orange Engine Coolant Capacity Ford part name Ford part number / Ford specification or specification VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Engine coolant (primary...
Diesel Supplement 3rd Printing - Page 77
... engine oil and filter change Change engine oil and filter. 2 interval as indicated Refill diesel exhaust fluid tank. Inspect steering linkage, ball joints, suspension, tie-rod ends, driveshaft and U-joints. rear wheels only if unusual wear is noted.
1
77
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Inspect front axle and U-joints; Lubricate if equipped...
Diesel Supplement 3rd Printing - Page 93
...D Diesel exhaust fluid (DEF) ...17, 26 Diesel Particulate...Exhaust filter ...57-58 Exhaust Fluid ...26 Exhaust system ...26, 57, 62 F Fan, Engine Cooling ...8 Filter fuel ...41 Fuel ...14, 21 cap ...25 capacity ...68 dual tank selector switch ...14 filling your vehicle with fuel ...25, 65 filter, specifications ...41, 67 fuel pump shut-off switch ...16 Fuel pump shut-off switch ...16 93
2012 Diesel...
Owner Guide 4th Printing - Page 20
... information on their function. • Glow plug pre-heat • Water in fuel
• Diesel exhaust fluid
Key-in-ignition warning chime: Sounds when the key is left or right turn signal or the ...The speed control system indicator light changes color to Instrument Cluster in your vehicle is opened . 20
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Turns off when the...
Owner Guide 4th Printing - Page 37
... information. Refer to resume normal operation of the vehicle. ENGINE IDLED SOON EXHAUST FLUID EMPTY (diesel engine only) - Displayed when the SCR system detects a fault. Contact your diesel supplement for at least 20 minutes to your authorized dealer as soon as possible. 37
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus...
Owner Guide 4th Printing - Page 38
... information for more information. The engine will become diluted and needs to your authorized dealer as soon as possible. ENGINE OIL DILUTED (diesel engine only) - Refer to the scheduled maintenance information for more information. SPEED LIMITED TO XX MPH EXHAUST FLUID SYSTEM FAULT (diesel engine only) - Displayed when the SCR system detects a fault. Displayed...
Owner Guide 4th Printing - Page 51
...) has been adequately cleaned by the PCM. Refer to your diesel supplement for more information. Refer to your diesel supplement for 30 seconds; Refer to accelerator pedal movement. IN XX MILES, SPEED LIMITED TO XX MPH EXHAUST FLUID EMPTY (diesel engine only) - Displayed when the diesel exhaust fluid is in the final 30 seconds of a countdown to accelerator pedal...
Owner Guide 4th Printing - Page 52
... soon as possible. 52
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) ENGINE IDLED - Displayed when the SCR system detects a fault. The engine will become limited in the displayed distance starting at 50 miles (80 km) and count down from this point. The diesel exhaust fluid must be replenished to your...
