2012 Ford F550 Cab Support Question
2012 Ford F550 Cab Support Question
Find answers below for this question about 2012 Ford F550 Cab.Need a 2012 Ford F550 Cab manual? We have 2 online manuals for this item!
Question posted by kagpc on December 23rd, 2013
How Do I Drain Water From Fuel Filter On 2012 F-550 6.7l
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 3
...(1,600 km) of : • a frame-mounted diesel fuel conditioner module (DFCM) / primary filter with an electric fuel pump and water drain, • an engine-mounted secondary fuel filter, • a fuel injector for each cylinder (8 total), • a high-pressure fuel pump, • a high-pressure fuel rail for more information. 3
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) DIESEL...
Diesel Supplement 3rd Printing - Page 4
... to Engine oil in the Maintenance and Specifications chapter. See Fuel filter/water separator in the Maintenance and Specifications chapter. The fuel injection system is important to change interval beyond the recommended interval... for overpressure protection in fuel indicator light. Introduction
The DFCM should be drained at the recommended service intervals to maintain oil viscosity.
Diesel Supplement 3rd Printing - Page 7
... the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Allowing water to stay in the system could result in extensive damage to Fuel filter/water separator in the Maintenance and Specifications chapter of , the fuel injection system. Low/contaminated diesel exhaust fluid: With the key in the on position, this supplement for the drain procedure. If...
Diesel Supplement 3rd Printing - Page 11
... need to operate properly. If you may become partially clogged with a an SCR system which recirculates fuel from inside the air filter assembly. Remove the air cleaner cover and the pleated paper filter, leaving the foam filter in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) At temperatures below 20°F (-7°C), if the...
Diesel Supplement 3rd Printing - Page 25
... refueling at least once. 25
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Repeat this several times. The engine may result in the system. Pumping fuel at greater flow rates may run rough and produce white smoke while air is allowed to enter the fuel system (during fuel filter change or if you run through...
Diesel Supplement 3rd Printing - Page 38
... - 9300 miles (14967 km)
FUEL FILTER/WATER SEPARATOR Diesel Fuel Conditioner Module (DFCM) The vehicle is allowed to exceed this level, the water may be drained from the module assembly whenever the warning... light comes on and the message center directs you to the engine and may cause fuel injection equipment damage. 38
2012 ...
Diesel Supplement 3rd Printing - Page 41
.... 2. Installation - Refer to Motorcraft part numbers in this chapter. See Fuel filter/water separator earlier in this supplement for more information. To install the new DFCM filter, see Installation - DFCM filter 1. Removal - DFCM filter later in the Maintenance chapter for the fuel filter kit part number.
41
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Install the new...
Diesel Supplement 3rd Printing - Page 42
... engine will drain.
42
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Removal - Engine-mounted fuel filter The engine-mounted fuel filter is not tightened to completely bleed off. Therefore, it is recommended to place a shop rag below the filter connectors to absorb the small amount of fuel that will not run properly if the DFCM fuel filter is not...
Diesel Supplement 3rd Printing - Page 43
... entering the system through the filter bowl seal or drain. Do this a total of six times in place. 2. Engine-mounted fuel filter 1. After filter service, a no start or rough running engine may require the fuel filter to be purged of the filter. Maintenance and Specifications
2. Install the new filter into the filter bracket. Turn the filter clockwise to lock it to...
Diesel Supplement 3rd Printing - Page 46
...filter and oil pan drain plug and wait for which engine operation with sulfur content other than ultra-low sulfur diesel (ULSD) • use of normal driving) • low-speed operation/stationary use of fuels...(over 10 minutes per hour of high-sulfur diesel fuel 46
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Replace the filter. 3. Reset the Intelligent Oil Life Monitor™. See...
Diesel Supplement 3rd Printing - Page 64
...constitute tampering are experiencing, consult an authorized dealer. 64
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The... • a plugged or disconnected air inlet system or engine air filter element. • water in the fuel filter/water separator. • a clogged fuel filter. • contaminated fuel. • air in the Warranty Guide, are applicable to loose connections...
Diesel Supplement 3rd Printing - Page 74
... chapter Refer to Special operating conditions later in this chapter Normal schedule Maximum Fuel Filter Change Interval Normal schedule 22,500 miles (36,000 km) or as ...additive strength (corrosion inhibitor) After initial change Check Every Month Engine air filter restriction gauge Fuel filter/water separator; drain if necessary (or if indicated by the message center (whichever comes first)...
Diesel Supplement 3rd Printing - Page 84
... for Vehicle Operation) As required Change engine oil and filter as indicated by message center and perform services listed in...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) some F-350s, all F-450/550s) Change transfer case fluid (4WD vehicles) Every 60,000 miles Flush and refill engine coolant; Operating the engine with a (80,000 km) Dana rear axle; and frame-mounted fuel filters...
Diesel Supplement 3rd Printing - Page 86
...replace filter as indicated by gauge Change engine oil and filter Inspect and lubricate U-joints Replace engine- some F-350s, all F-450/550s)... functional holes in each engine oil and filter change; and frame-mounted fuel filters
Every 7,500 miles (12,000 km... filter Replace wheel bearing grease/grease seals if non-sealed bearings are kept clean/clear of the Owner's Guide.
86
2012 Diesel...
Owner Guide 4th Printing - Page 39
.... OK
39
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) If the message does not come back, the low fuel pressure condition was due to low fuel levels in the... warm and during low fuel tank level operation, i.e. The message center is not low, the fuel filters must be changed regardless of the fuel filter does not remedy the low fuel pressure message during normal operation...
Owner Guide 4th Printing - Page 45
... only) On/Off On/Off One Stage or Two Stage Hold OK if coolant maintenance performed Hold OK if Fuel Filter Changed
Maintenance
45
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus)
Determine which magnetic zone you are in for your geographic location by referring to the zone map.
3 2 4 5
1
15...
Owner Guide 4th Printing - Page 53
...fuel pressure message is not low, the fuel filters must be void from using additives that do not meet or exceed Ford specifications. At this , use an anti-gel additive. Press OK to your diesel supplement for more information. 53
2012 F-250/350/450/550... when the SCR system detects a fault. Displayed when a fuel filter change is normal. The engine will eventually enter into an ...
Owner Guide 4th Printing - Page 386
... vehicle in this does not happen, follow the remaining steps. 3. FUEL FILTER Your vehicle is equipped with the fuel tank. The pressure in an overfilled tank may spray out and injure...or others. 386
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) WHAT YOU SHOULD KNOW ABOUT AUTOMOTIVE FUELS Important safety precautions WARNING: Do not overfill the fuel tank. See Adding...
Owner Guide 4th Printing - Page 437
... if equipped with grease fittings Replace cabin air filter (if equipped) Replace engine air filter Change engine oil and filter Inspect wheels and related components for abnormal noise,...
Exclusive use of E85 (Flex Fuel Vehicles only) Every oil change If ran exclusively on E85, fill the fuel tank full interval with regular unleaded fuel 437
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing...
Owner Guide 4th Printing - Page 440
... or change may be changed anytime the axle has been submerged in water California fuel filter replacement: If the vehicle is registered in California, the California Air Resources...completion of SM or SN quality, the normal oil change interval is 3,000 mile (4,800 km). 440
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Add four ounces (118 mL) of additive friction modifier...
Similar Questions
How To Drain Water From Ford 6.7 Diesel Filter F 550
(Posted by tenjreic 10 years ago)
Where Is The Fuel Filter On A 2012 Ford F550 With A V-10
(Posted by pravda 10 years ago)