2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by DaAndrey on February 27th, 2014
How Do You Reset Exhaust Fluid Light 2012 F350
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
...contaminated will not reset vehicle speed. Speed control (if equipped) If vehicle speed goes outside a predetermined range from the exhaust of diesel exhaust fluid (DEF) which must be reset with the SET ...to provide heat transfer, freeze point protection, and corrosion protection using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The GPCM energizes the glow plugs...
Diesel Supplement 3rd Printing - Page 7
...supplement for the drain procedure. Low/contaminated diesel exhaust fluid: With the key in extensive damage to Fuel filter/water separator in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus... from the fuel. Note: Air will illuminate if the exhaust fluid is contaminated and/or low. The water in fuel light will not operate properly if air enters the system. The...
Diesel Supplement 3rd Printing - Page 9
... functions due to low or contaminated diesel exhaust fluid (DEF). See Selective catalytic reduction (SCR... Cold weather starting It is recommended that the engine block heater be reset by turning the key to off. 3. Do not crank the engine ...be used for starting fluid, such as starter damage may occur. engine until the oil pressure gauge indicates normal pressure. 9
2012 Diesel (67l) ...
Diesel Supplement 3rd Printing - Page 11
... Ensure the foam filter is equipped with snow and/or ice. For best results in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Your vehicle is installed correctly in cold weather...filter, leaving the foam filter in the Maintenance and Specifications chapter. Diesel fuel which uses diesel exhaust fluid (DEF) to the activation of 32°F (0°C) or below 32°F (0°C), ...
Diesel Supplement 3rd Printing - Page 17
... not resume until DEF is refilled. See the Customer Assistance chapter in the Owner's Guide for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your Owner's Guide for help in the Fuel and Refueling chapter for more information. Use the primary battery...
Diesel Supplement 3rd Printing - Page 26
... interval. Otherwise, fuel may be under pressure. The system automatically injects diesel exhaust fluid (DEF) into the exhaust system to be refilled. WARNING: The fuel system may spray out and injure... of your vehicle. When you see Filling the DEF tank later in this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
If you must replace...
Diesel Supplement 3rd Printing - Page 27
...message center.
27
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Your vehicle's message center will display a series of messages regarding the amount of your vehicle's exhaust aftertreatment system will ... and Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low or replaced when contaminated or the vehicle speed will...
Diesel Supplement 3rd Printing - Page 29
... Empty (80 km/h) This occurs 200 Miles Engine Idled Soon Exhaust (322 km) after the vehicle Refill exhaust fluid - exhaust (80 km/h) Upon Restart Refill exhaust fluid None fluid tank is empty Exhaust Fluid Empty Speed Limited To 50 MPH Speed is empty Empty Speed Limited to 50 MPH. 2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings...
Diesel Supplement 3rd Printing - Page 30
... limited Engine Idled-See Owner's • the engine is shut off for Refill exhaust fluid to idle ONLY Manual Exhaust Fluid Empty 10 minutes or, • the engine is idling with the parking brake engaged for 60 minutes. Maintenance and Specifications 30
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings and Actions...
Diesel Supplement 3rd Printing - Page 35
...DEF will appear in the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Additionally, if the message center indicates EXHAUST FLUID UNDER 1/2 FULL, you should only add ... limited upon restart. If the SCR becomes contaminated or inoperative, the DEF light will illuminate and exhaust fluid system fault messages will shut off automatically when the tank is OVERFILLED and...
Diesel Supplement 3rd Printing - Page 37
Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate DEF usage for the given distances traveled under various driving conditions and when using the PTO...(13036 km) - 9700 miles (15611 km)
Driving style DEF usage
Steady highway driving 7300 miles (11748 km) - 8900 miles (14323 km)
37
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Diesel Supplement 3rd Printing - Page 63
...has cooled. The floor covering and insulation protect occupants of the service engine soon light
63
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Failure to follow these instructions ... that permits prolonged skin contact with emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after only a short period of engine ...
Diesel Supplement 3rd Printing - Page 67
... rail mounted ) Battery (2 Required) BXT-65-750 * Always use the correct air filter may result in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Refer to the Owner's Guide for more information. See Selective catalytic reduction (SCR)... circuit breakers must always be limiting the vehicle's functions due to low or contaminated diesel exhaust fluid (DEF).
Diesel Supplement 3rd Printing - Page 68
...; Motor Oil 5W40 Super Duty •Motorcraft Motor Oil 0W30 Super Duty Motorcraft Diesel Exhaust Fluid
VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2 •XO-10W30-QSD /... / Ford specification or specification VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Engine coolant (primary high- temperature cooling 29.4 quarts...
Diesel Supplement 3rd Printing - Page 77
...Inspect automatic transmission fluid level. Inspect wheels and related components for abnormal noise, wear, looseness or drag. rear wheels only if unusual wear is noted.
1
77
2012 Diesel (67l.... 2 interval as indicated Refill diesel exhaust fluid tank. Do not exceed one year or 10000 miles (16000 kilometers) between service intervals. 2 Reset your Owner Guide. 3 Vehicles equipped with...
Diesel Supplement 3rd Printing - Page 93
... Exhaust filter ...57-58 Exhaust Fluid ...26 Exhaust system ...26, 57, 62 F Fan, Engine Cooling ...8 Filter fuel ...41 Fuel ...14, 21 cap ...25 capacity ...68 dual tank selector switch ...14 filling your vehicle with fuel ...25, 65 filter, specifications ...41, 67 fuel pump shut-off switch ...16 Fuel pump shut-off switch ...16 93
2012...
Owner Guide 4th Printing - Page 20
...; Water in fuel
• Diesel exhaust fluid
Key-in your vehicle is disengaged. Instrument Cluster
Speed control (if equipped): The speed control system indicator light changes color to Instrument Cluster in -... indicate what mode the system is in: • On (amber light): Illuminates when the speed control system is opened . 20
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA...
Owner Guide 4th Printing - Page 25
... by the message center and according to the recommended maintenance schedule. EXHAUST FLUID LEVEL (Diesel only) 3. TBC GAIN = XX.X (if equipped) 9. To reset the oil monitoring system to 100% after each oil change back to...PROGRAMMED 12. Press and release the SETUP button to display "OIL LIFE XXX% HOLD RESET = NEW". 25
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) FUEL...
Owner Guide 4th Printing - Page 37
... your diesel supplement for more information. Refer to your diesel supplement for more information. Refer to your authorized dealer as soon as possible. 37
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) SPEED LIMITED XXMPH IN XXXMI EXHAUST FLUID SYSTEM FAULT (diesel engine only) - Refer to clean the DPF.
Owner Guide 4th Printing - Page 408
...and solvents. Fuel system • Fill the fuel tank with a light grade oil. Follow the instructions on the brake, shift through all .... Note: If battery cables are no cooling system leaks, and fluid is running. Engine • The engine oil and filter should ... fuel until it may be operated at idle speed to reset memory features.
408
2012 F-250/350/450/550 (f23) Owners Guide, 4th ...
Similar Questions
How To Reset Exhaust Fluid Warning On F350
(Posted by grecrichar 10 years ago)
How To Reset Exhaust Fluid Contaminated Light On Super Duty
(Posted by NMAsamant 10 years ago)
How To Reset Exhaust Fluid Warning On 2012 F250
(Posted by tamow 10 years ago)