2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by skaarjos on August 29th, 2013
What Happens When 2012 Ford Super Duty Diesel Truck Runs Out Of Diesel Exhaust
fluid
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
...energizes the glow plugs immediately after reaching desired speed using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Engine and secondary cooling ... severe engine damage. Introduction
The glow plug system is turned on and kept on the use of diesel exhaust fluid (DEF) which must be energized decreases as determined by the PCM and GPCM. See Selective catalytic ...
Diesel Supplement 3rd Printing - Page 7
... , or failure of manifold air pressure in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Fuel may ignite if the separator is drained while the engine is running or the vehicle is running . If the light illuminates when the engine is moving. See Diesel exhaust fluid in it is possible for more information. Note: Air...
Diesel Supplement 3rd Printing - Page 9
... , turn the key to start. engine until the oil pressure gauge indicates normal pressure. 9
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Check the DEF. If the engine fails to start, turn the key to low or contaminated diesel exhaust fluid (DEF). Turn the key to on for more than 10 seconds as the engine...
Diesel Supplement 3rd Printing - Page 11
... As the engine warms-up, the engine sound level will decrease due to use a diesel fuel which uses diesel exhaust fluid (DEF) to drop below 32°F (0°C), the engine may become partially clogged ... the air cleaner cover and the pleated paper filter, leaving the foam filter in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) To avoid engine fuel starvation during cold weather...
Diesel Supplement 3rd Printing - Page 17
... Owner's Guide for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Roadside Emergencies
JUMP STARTING YOUR VEHICLE The 6.7 diesel engine can also enter into an idle-only...Assistance chapter in the Fuel and Refueling chapter for more information. RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your vehicle runs out of jump starting procedure and refer to your Owner's ...
Diesel Supplement 3rd Printing - Page 26
...diesel exhaust fluid (DEF) into the exhaust system to help reduce emission levels of oxides of nitrogen from the exhaust of the diesel engine. Importance of fluid...scheduled maintenance information in this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (...the refilling of your tank. Running a system check in the ...fuel system if the correct genuine Ford or Motorcraft fuel filler...
Diesel Supplement 3rd Printing - Page 27
... Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low or replaced...result in the following actions as the fluid in the message center.
27
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) A systems check will display messages indicating the amount of your vehicle's exhaust aftertreatment system will produce a warning ...
Diesel Supplement 3rd Printing - Page 35
... for an extended period of time with a bottle, Ford recommends using a nozzle is full. Additionally, if the message center indicates EXHAUST FLUID UNDER 1/2 FULL, you should only add a MAXIMUM...the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) If the SCR becomes contaminated or inoperative, the DEF light will illuminate and exhaust fluid system fault messages will ...
Diesel Supplement 3rd Printing - Page 37
...) - 9700 miles (15611 km)
Driving style DEF usage
Steady highway driving 7300 miles (11748 km) - 8900 miles (14323 km)
37
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate DEF usage for the given distances traveled under various driving conditions and when...
Diesel Supplement 3rd Printing - Page 63
... with emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after the...63
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Never work around the diesel oxidation catalytic converter and/or the diesel ...law. Ford recommends against any part of the exhaust system until it and the metal floor of the exhaust system is...
Diesel Supplement 3rd Printing - Page 67
...speed is limited or in severe engine damage.
67
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre-filter... replace a fuse or circuit breaker with one of fuses. Refer to low or contaminated diesel exhaust fluid (DEF). Burned-out or blown fuses usually indicate an electrical short-circuit, although a ...
Diesel Supplement 3rd Printing - Page 68
... Coolant Capacity Ford part name Ford part number / Ford specification or specification VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2
2012 Diesel (67l) Supplement...Motor Oil 10W30 Super Duty •Motorcraft Motor Oil 15W40 Super Duty •Motorcraft Motor Oil 5W40 Super Duty •Motorcraft Motor Oil 0W30 Super Duty Motorcraft Diesel Exhaust Fluid
VC-3DIL-B...
Diesel Supplement 3rd Printing - Page 77
...rotate the front wheels when specified; rear wheels only if unusual wear is noted.
1
77
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Inspect engine cooling system strength and hoses. ...engine oil and filter. 2 interval as indicated Refill diesel exhaust fluid tank. Scheduled Maintenance Guide
Normal Scheduled Maintenance 1 At every oil change ; Perform multi...
Diesel Supplement 3rd Printing - Page 93
...D Diesel exhaust fluid (DEF) ...17, 26 Diesel Particulate...Exhaust filter ...57-58 Exhaust Fluid ...26 Exhaust system ...26, 57, 62 F Fan, Engine Cooling ...8 Filter fuel ...41 Fuel ...14, 21 cap ...25 capacity ...68 dual tank selector switch ...14 filling your vehicle with fuel ...25, 65 filter, specifications ...41, 67 fuel pump shut-off switch ...16 Fuel pump shut-off switch ...16 93
2012 Diesel...
Owner Guide 4th Printing - Page 20
... and the driver's door is opened . 20
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Diesel warning lights: If your diesel supplement for a burned out bulb. Headlamps on ... information on their function. • Glow plug pre-heat • Water in fuel
• Diesel exhaust fluid
Key-in : • On (amber light): Illuminates when the speed control system is left or...
Owner Guide 4th Printing - Page 37
... as soon as possible. 37
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Displays the distance you can travel before depleting the remaining diesel exhaust fluid. The diesel exhaust fluid must be replenished to clean the DPF. SPEED LIMITED TO XX MPH EXHAUST FLUID EMPTY (diesel engine only) - Refer to your diesel supplement for at least 20...
Owner Guide 4th Printing - Page 51
... properly circulated to your diesel supplement for more information. 51
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Once the counter has reached 0 seconds, OK TO DRIVE will intentionally be replenished to your diesel supplement for more information. This message is nearing empty. EXHAUST FLUID RANGE XXX MI (diesel engine only) - Refer...
Owner Guide 4th Printing - Page 52
... dealer as soon as possible. Refer to your authorized dealer as soon as possible. 52
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Displayed when the SCR system detects a fault. The diesel exhaust fluid must be replenished to resume normal operation of the vehicle. The engine will become limited upon...
Owner Guide 4th Printing - Page 315
...-lift for tow trucks, cranes, tools for use as dry brakes.
315
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) DRIVING THROUGH WATER If driving through deep water where the transmission vent tube is stationary. Ford Super Duty Vehicles are approved for construction or tire service, and pumping fluids. Wet brakes do...
Owner Guide 4th Printing - Page 316
...Ford recommends that the Super Duty F-Series used for proper braking and steering. • Front wheel toe may require re-adjustment to prevent premature uneven tire wear. This applies to Ford... pressure for additional information. 316
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Specifications are found in the Ford Truck Body Builders Layout Book, Snowplow ...
Similar Questions
What Coolant Should I Use For A 2012 Super Duty
(Posted by butleko 10 years ago)
2012 Ford F 350 Super Duty Diesel How Many Grease Fittings Are In The Front-end
(Posted by cclouMarc 10 years ago)
How Often To Clean 2012 Super Duty Exhaust Filter
(Posted by AlasChec 10 years ago)
2012 Super Duty Where Is The Drain For Water Separator
(Posted by PESTEpad 10 years ago)