2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by nerglam on February 19th, 2014
How To Fill Exhaust Fluid On Ford F350
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 5
... to be energized decreases as determined by the PCM and GPCM. Speed control (if equipped) If vehicle speed goes outside a predetermined range from the exhaust of diesel exhaust fluid (DEF) which must be reset with the SET +/- The GPCM energizes the glow plugs immediately after reaching desired speed using accelerator pedal.
5
2012 Diesel...
Diesel Supplement 3rd Printing - Page 7
...will not operate properly if air enters the system. Note: Air will illuminate if the exhaust fluid is contaminated and/or low. Instrument Cluster
Water in fuel: During refueling, it . Allowing...chapter for the drain procedure. Refer to remove water from the fuel. See Diesel exhaust fluid in the Maintenance and Specifications chapter of this light will enter into your tank. GAUGES...
Diesel Supplement 3rd Printing - Page 9
... seconds before the glow plug activation time ends, the glow plugs will need to be reset by turning the key to low or contaminated diesel exhaust fluid (DEF). After the engine starts, allow it to 3 (off , turn the key to idle for more information. This is not started before trying again. Do...
Diesel Supplement 3rd Printing - Page 11
... paper filter, leaving the foam filter in the Maintenance and Specifications chapter. Do not use a fuel with a diesel fuel conditioner module (DFCM) which uses diesel exhaust fluid (DEF) to the activation of this occurs, the engine may need to use alcohol based additives to the DEF tank. For proper cold weather fill...
Diesel Supplement 3rd Printing - Page 17
... jump starting procedure and refer to your vehicle runs out of DEF, it will not resume until DEF is refilled. RUNNING OUT OF DEF (DIESEL EXHAUST FLUID) If your Owner's Guide for any jump starting .
Diesel Supplement 3rd Printing - Page 26
...automatically injects diesel exhaust fluid (DEF) into the exhaust system to ...disengage in a collision, which may be under pressure. See Message center in this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) For instructions on refilling your DEF tank, see this supplement for any damage to the fuel tank or fuel system if the correct genuine Ford...
Diesel Supplement 3rd Printing - Page 27
... the amount of your Owner's Guide. WARNING: Tampering or disabling your vehicle's exhaust aftertreatment system will result in severe vehicle performance limitation including eventual speed limiting to ... immediately. Maintenance and Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF) must be refilled when low or replaced when contaminated or the ...
Diesel Supplement 3rd Printing - Page 29
... Approximately 99 Miles Limited to 50 MPH (159 km) left before Refill exhaust fluid None (80 km/h) Exhaust Fluid exhaust fluid tank is limited Vehicle restarted with (80 km/h) Exhaust Fluid Refill exhaust fluid to 50 MPH 0 Miles (0 km) - exhaust (80 km/h) Upon Restart Refill exhaust fluid None fluid tank is empty Exhaust Fluid Empty Speed Limited To 50 MPH Speed is empty Empty Speed Limited...
Diesel Supplement 3rd Printing - Page 30
... DEF Warnings and Actions - Instrument Cluster Messages (Optional message center messages shown, base message center messages similar) Customer Distance/Exhaust Fluid Cluster Message Requested Vehicle Actions Level or Action Actions This occurs when the exhaust fluid is empty and: • The vehicle's diesel fuel tank is refueled or, Engine is limited Engine Idled-See...
Diesel Supplement 3rd Printing - Page 35
...a problem with an automatic preheating system which can cause damage. Additionally, if the message center indicates EXHAUST FLUID UNDER 1/2 FULL, you should only add a MAXIMUM of 2 gallons (6.7L) of your vehicle ..., 3rd Printing USA (fus) Do not continue to contamination of time with a bottle, Ford recommends using a nozzle is similar to this may prevent filling of DEF to the tank ...
Diesel Supplement 3rd Printing - Page 37
... (fus) Your usage may vary depending on: driving style, trailer towing, loaded vehicle weight, weather, idle time, PTO usage, etc. Maintenance and Specifications
Typical Diesel Exhaust Fluid (DEF) Usage The charts below illustrate approximate DEF usage for the given distances traveled under various driving conditions and when using the PTO.
Diesel Supplement 3rd Printing - Page 63
...) Tampering with emissions control systems (including related sensors and the diesel exhaust fluid (DEF) injection system) can stay hot even after the engine is very high. Failure to follow these instructions may result in reduced . Ford recommends against any part of the exhaust system until it and the metal floor of the vehicle. engine...
Diesel Supplement 3rd Printing - Page 67
...must always be limiting the vehicle's functions due to your vehicle to low or contaminated diesel exhaust fluid (DEF). Higher rated fuses or circuit breakers could allow circuit overloading in the Maintenance and ... due to fire. Insert a second fuse. MOTORCRAFTா PART NUMBERS Item Ford Part Number Engine oil filter FL-2051 Foam pre-filter FA-1907 * Air filter FA-1902 Fuel filter...
Diesel Supplement 3rd Printing - Page 68
... Duty •Motorcraft Motor Oil 0W30 Super Duty Motorcraft Diesel Exhaust Fluid
VC-3DIL-B (US) CVC-3DIL-B (Canada) / WSS-M97B44-D2 •... gallons (22.7L)
Diesel Exhaust Fluid (DEF) - 68 MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES Item Motorcraft Specialty Orange Engine Coolant Capacity Ford part name Ford part number / Ford specification or specification VC-3DIL-B...
Diesel Supplement 3rd Printing - Page 77
... Lubricate if equipped with grease fittings (4WD vehicles). Replace filter if necessary. Inspect exhaust system and heat shields. Inspect front axle and U-joints; Inspect wheels and related ...oil and filter change Change engine oil and filter. 2 interval as indicated Refill diesel exhaust fluid tank. Inspect engine cooling system strength and hoses. rear wheels only if unusual wear ...
Diesel Supplement 3rd Printing - Page 93
... capacities ...68 Coolant additive ...68 Coolant change ...47, 52, 68 Cooler ...5 D Diesel exhaust fluid (DEF) ...17, 26 Diesel Particulate Filter (DPF) ...57-58, 62 Drivebelt ...70 ... ...44 filter, specifications ...67 refill capacities ...68 specifications ...44, 68 Exhaust brake ...14 Exhaust filter ...57-58 Exhaust Fluid ...26 Exhaust system ...26, 57, 62 F Fan, Engine Cooling ...8 Filter fuel ...
Owner Guide 4th Printing - Page 20
... the indicators stay on or flash faster, check for detailed information on their function. • Glow plug pre-heat • Water in fuel
• Diesel exhaust fluid
Key-in-ignition warning chime: Sounds when the key is left or right turn signal or the hazard lights are turned on . Headlamps on warning...
Owner Guide 4th Printing - Page 25
... release the SETUP button to display "OIL LIFE XXX% HOLD RESET = NEW". 25
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) EXHAUST FLUID LEVEL (Diesel only) 3. CHARGING SYSTEM 6. TBC GAIN = XX.X (if equipped) 9. OIL LIFE 2. MYKEY DISTANCE (if MyKey is present. ADMIN KEYS PROGRAMMED Note: Some systems...
Owner Guide 4th Printing - Page 38
... the SCR system detects a fault. Displayed when the SCR system detects a fault. ENGINE IDLED SEE MANUAL EXHAUST FLUID SYSTEM FAULT (diesel engine only) - Refer to be void from using additives that do not meet or exceed Ford specifications. LOW FUEL PRESSURE SEE MANUAL (diesel engine only) - Refer to your diesel supplement for more...
Owner Guide 4th Printing - Page 53
... - SEE OWNER'S MANUAL EXHAUST FLUID SYSTEM FAULT (diesel engine only) - To prevent this point the vehicle must be void from using additives that do not meet or exceed Ford specifications. If the message ... the SCR system detects a fault. If the message reappears after the DRIVE TO CLEAN EXHAUST SYSTEM message has displayed and the vehicle operator has not driven the vehicle above , please...
Similar Questions
How To Reset Exhaust Fluid Warning On F350
(Posted by grecrichar 10 years ago)
How Many Gallons Of Diesel Exhaust Fluid In A 2012 Ford F350
(Posted by 69cJohnKl 10 years ago)
Diesel Exhaust Fluid Ford F350 How To Fill
(Posted by junk4jul 10 years ago)