2012 Ford F350 Super Duty Support Question
2012 Ford F350 Super Duty Support Question
Find answers below for this question about 2012 Ford F350 Super Duty.Need a 2012 Ford F350 Super Duty manual? We have 2 online manuals for this item!
Question posted by Carldelt on September 10th, 2013
How To Drain Coolant On 2012 F350
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 3
... km) of : • a frame-mounted diesel fuel conditioner module (DFCM) / primary filter with an electric fuel pump and water drain, • an engine-mounted secondary fuel filter, • a fuel injector for each cylinder (8 total), • a high-pressure ...message. Introduction
WARNINGS Throughout this supplement for more information. 3
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Diesel Supplement 3rd Printing - Page 4
... plugs (one per cylinder) • the glow plug control module (GPCM) • engine coolant temperature (ECT) sensor • barometric pressure (BARO) sensor • environmental temperature sensor
4
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Introduction
The DFCM should be drained at the recommended service intervals to maintain oil viscosity. If these modified engine...
Diesel Supplement 3rd Printing - Page 5
... plugs immediately after reaching desired speed using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The coolant serves three primary purposes: to cool the transmission, exhaust gas...are used to the Special operating conditions section for more information about coolant additives and coolant change intervals. See Selective catalytic reduction (SCR) system in the ...
Diesel Supplement 3rd Printing - Page 7
...engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Refer to be pumped into the fuel system if the DFCM is drained while the system is running . WARNING: Do not drain the DFCM ...not operate properly if air enters the system. Your vehicle's fuel system is possible for the drain procedure. Instrument Cluster
Water in fuel: During refueling, it . See Diesel exhaust fluid in ...
Diesel Supplement 3rd Printing - Page 10
...IF EQUIPPED) Your vehicle may be equipped with and without a trailer in the Owner guide
10
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) When the engine idle shutdown process has ...or N (Neutral) for 3-5 minutes which will simulate key off (PTO) mode. • The engine coolant temperature is below 60°F (16°C). • The exhaust emission control device (DPF) is still ...
Diesel Supplement 3rd Printing - Page 12
...arctic temperatures of operation to prevent condensation in optimum condition. • Use the proper coolant solution at the concentration recommended to protect the engine against damage from a reputable manufacturer... or below, it is recommended that you use an approved idle speed increase device.
12
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Also, if necessary, make sure they...
Diesel Supplement 3rd Printing - Page 20
...filter assembly 12. Automatic transmission dipstick 3. Brake fluid reservoir 4. Power steering fluid reservoir
8. Engine oil fill 9. Secondary cooling system coolant reservoir 11. Windshield washer fluid reservoir
20
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Maintenance and Specifications
IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT F-Super Duty
13
5
1
2
3
4
12...
Diesel Supplement 3rd Printing - Page 21
... high-sulfur diesel fuel, the engine must be a factory built high-sulfur engine (available as ULSD) in engine coolant system damage, engine overheating, SCR and/or DPF damage and possible base engine damage. 21
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) FUEL REQUIREMENTS - Maintenance and Specifications
SCHEDULED MAINTENANCE The scheduled maintenance...
Diesel Supplement 3rd Printing - Page 34
...clean. Once the level in the DEF bottle has stopped dropping, return the container to induce flow. Once the spout has drained, remove the spout from the DEF container and install the cap back on the bottle. 8. If the container is re-useable...6. Maintenance and Specifications
4B. after use the DEF spout with water and a damp cloth.
34
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Diesel Supplement 3rd Printing - Page 38
...DFCM) located on the frame-rail under the driver-side floorboard near the transmission Water should be passed through to drain the water separator. If water level is equipped with PTO) PTO usage DEF usage < - - - PTO ...message center directs you to the engine and may cause fuel injection equipment damage. 38
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) PTO usage - This will occur...
Diesel Supplement 3rd Printing - Page 39
Fuel may be sure that the drain valve is fully tightened. 5. Make sure that the drain valve is fully tightened, then remove the container from under the drain port (see illustration). 3. Note: A loose drain valve can allow air to illuminate, have the fuel system checked and repaired.
39
2012 Diesel (67l) Supplement, 3rd Printing USA (fus...
Diesel Supplement 3rd Printing - Page 41
...the amount seal swelling, removal of this chapter for the fuel filter kit part number.
41
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Replace the seal prior to reinstalling the ...vehicle is mounted on the frame rail under the driver-side floorboard near the transmission. Drain the DFCM. This part number includes filters and seals for more information. Install the new...
Diesel Supplement 3rd Printing - Page 42
The system will drain.
42
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) To remove it, do the following . Therefore, it clockwise onto DFCM housing, allowing fuel to the mechanical stop . ...
Diesel Supplement 3rd Printing - Page 43
... discard the filter. Turn the filter clockwise to lock it to the mechanical stop.
43
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Make sure the drain is entering the system through the filter bowl seal or drain. Installation - See Purging air from the fuel system after DFCM and engine-mounted fuel filter...
Diesel Supplement 3rd Printing - Page 48
..., overheating or freezing. Water alone (without engine coolant may change does not indicate the engine coolant has degraded nor does it require the engine coolant to be drained, the system to be flushed, or the engine coolant to be harmful and compromise the corrosion protection of the engine coolant.
48
2012 Diesel (67l) Supplement, 3rd Printing USA...
Diesel Supplement 3rd Printing - Page 50
... at 2,000 rpm for more information. 50
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Shut engine off and let it has been drained or become extremely low. 1. Shut the engine... off , and remove the pressure relief cap as listed on the reservoir. After any coolant has been added, check the coolant concentration. Before...
Diesel Supplement 3rd Printing - Page 74
... to make sure they are functional and clear of debris
74
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) drain if necessary (or if indicated by the message center (whichever comes...80,000 km), or as indicated from the coolant tests for concentration (freeze-point) or additive strength (corrosion inhibitor) Use engine coolant specified in the Maintenance product specifications and capacities...
Owner Guide 4th Printing - Page 381
...coolant) can cause engine damage from corrosion, overheating or freezing. • Do not use of engine coolants may void the warranty. Slowly turn it counterclockwise and remove the cap. 381
2012 ... the engine coolant may change does not indicate the engine coolant has degraded nor does it require the engine coolant to be drained, the system to be flushed, or the engine coolant to be ...
Owner Guide 4th Printing - Page 382
... application). 8. Slowly turn it cool. 2. Fill the coolant reservoir slowly with prediluted engine coolant to obtain a 50% coolant concentration. If the concentration is almost full. 9. If necessary, add enough prediluted engine coolant to bring the coolant level to the engine coolant reservoir. Your cooling system may take several drains and additions to the FULL COLD level, or...
Owner Guide 4th Printing - Page 426
...owner's guide. lubricate if necessary Hinges/latches/outside locks for wear; lubricate if necessary 426
2012 F-250/350/450/550 (f23) Owners Guide, 4th Printing USA (fus) Any adverse condition.... clean if necessary Cooling system fluid level and coolant strength Door weatherstrips for proper operation; clean if necessary Body and door drain holes for wear and proper pressure, including spare ...
Similar Questions
How To Drain Fuel Water Separator On 2012 F350
(Posted by PrBos 10 years ago)
Power Distribution Box Location On 2012 F350 Diesel
I'm not sure where the PDB is on my 2012 F350. My trailer brake and RT LT signal lights do not work ...
I'm not sure where the PDB is on my 2012 F350. My trailer brake and RT LT signal lights do not work ...
(Posted by thuld01 10 years ago)