2012 Ford F250 Super Duty Support Question
2012 Ford F250 Super Duty Support Question
Find answers below for this question about 2012 Ford F250 Super Duty.Need a 2012 Ford F250 Super Duty manual? We have 2 online manuals for this item!
Question posted by jaPanaxu on November 24th, 2013
Where Do You Fill Def Tank On 2012 F250
The person who posted this question about this Ford automobile did not include a detailed explanation. Please use the "Request More Information" button to the right if more details would help you to answer this question.
Current Answers
Related Manual Pages
Diesel Supplement 3rd Printing - Page 4
... coolant temperature (ECT) sensor • barometric pressure (BARO) sensor • environmental temperature sensor
4
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Fast start glow plug system The diesel engine glow... in fuel indicator light. Fuel is illuminated, seek service from the fuel tank by the message center message and water in the Maintenance and Specifications chapter....
Diesel Supplement 3rd Printing - Page 5
...speed goes outside a predetermined range from the exhaust of diesel exhaust fluid (DEF) which must be replenished at certain intervals. The GPCM energizes the glow plugs immediately after reaching desired... speed using accelerator pedal.
5
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Engine and secondary cooling system The ...
Diesel Supplement 3rd Printing - Page 7
...while the system is running or the vehicle is running . The engine will enter into your tank. Your vehicle's fuel system is contaminated and/or low. Note: Air will not operate properly ...system could result in extensive damage to, or failure of manifold air pressure in the engine.
7
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Refer to Fuel filter/water separator in the ...
Diesel Supplement 3rd Printing - Page 9
...starter damage may occur. If the engine is not started before trying again. Check the DEF. See Selective catalytic reduction (SCR) system in an idle-only mode, the SCR system...low or contaminated diesel exhaust fluid (DEF). This is to the engine and possible personal injury. engine until the oil pressure gauge indicates normal pressure. 9
2012 Diesel (67l) Supplement, 3rd Printing...
Diesel Supplement 3rd Printing - Page 11
... Maintenance and Specifications chapter of PCM-controlled sound reduction features. When filling the vehicle's DEF tank in a heavy snow storm or blowing snow conditions, the engine air induction may be... Remove the air cleaner cover and the pleated paper filter, leaving the foam filter in 11
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) To avoid engine fuel starvation during cold...
Diesel Supplement 3rd Printing - Page 12
...cetane improvers or non alcohol-based cetane improvers from freezing. • Try to keep the fuel tank full as much as possible at the end of operation to prevent condensation in the fuel system...The following instructions: • Make sure that you use an approved idle speed increase device.
12
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Remove any debris, snow and/or ice on...
Diesel Supplement 3rd Printing - Page 14
... avoid splashing water into the diesel engine can result in the Owner Guide. 14
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Engine block heater (if equipped) Refer to the right of fuel in the currently selected tank. Your fuel gauge and the DTE (distance to empty) will display the amount of...
Diesel Supplement 3rd Printing - Page 17
...-only mode. See the Customer Assistance chapter in the Owner's Guide for more information.
17
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) See the Selective Catalytic Reduction (SCR) System section in finding a retailer that sells DEF. Contact roadside assistance for help in the Fuel and Refueling chapter for more information. Use...
Diesel Supplement 3rd Printing - Page 22
...intervals section in the Schedule Maintenance chapter. • Do not store biodiesel fuel in the fuel tank for more than 1 month. • Consider changing brands or reducing biodiesel content if you have... message appearing. • Do not use raw oils, fats or waste cooking greases. 22
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Vehicles with engines configured for use with diesel...
Diesel Supplement 3rd Printing - Page 26
... if it is low and needs to be maintained. For instructions on refilling your DEF tank, see this section. 26
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) The vehicle warranty may result in the message center when the DEF level is less than 1/2 full. Otherwise, fuel may be displayed in possible personal injury...
Diesel Supplement 3rd Printing - Page 27
...or U.S. Prior to this occurring a message will result in the DEF tank nears empty. If the DEF becomes empty or contaminated fluid is depleted. For more information on warning...2012 Diesel (67l) Supplement, 3rd Printing USA (fus) WARNING: Tampering or disabling your Owner's Guide. Maintenance and Specifications
DEF warning messages and vehicle operations WARNING: Diesel Exhaust Fluid (DEF...
Diesel Supplement 3rd Printing - Page 28
... center indicating required actions to add a minimum of 0.5 gallons (1.9L) of DEF. Maintenance and Specifications
• Further vehicle operation without refilling your DEF tank will resume when the DEF tank is refilled. This must occur before detecting the increased level of DEF to the tank to enter an idle-only condition. For either vehicle speed limiting or...
Diesel Supplement 3rd Printing - Page 29
exhaust (80 km/h) Upon Restart Refill exhaust fluid None fluid tank is empty Exhaust Fluid Empty Speed Limited To 50 MPH Speed is empty Empty Speed Limited to 50 MPH. 2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings and Actions - Fluid Empty reaches the 0 mile (0 km) exhaust fluid range
Maintenance and...
Diesel Supplement 3rd Printing - Page 30
30
2012 Diesel (67l) Supplement, 3rd Printing USA (fus)
Low DEF Warnings ...and Actions -
Instrument Cluster Messages (Optional message center messages shown, base message center messages similar) Customer Distance/Exhaust Fluid Cluster Message Requested Vehicle Actions Level or Action Actions This occurs when the exhaust fluid is empty and: • The vehicle's diesel fuel tank...
Diesel Supplement 3rd Printing - Page 31
...-capped filler port located next to the paint. Maintenance and Specifications
Filling the DEF tank Your vehicle is no longer guaranteed.
31
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) Repairs resulting from the tank for repair work, etc., the same DEF must not be used , but they are recommended as its purity is equipped...
Diesel Supplement 3rd Printing - Page 32
.... To fill the DEF tank, see your eyes, flush them with eyes, skin or clothing. Should DEF contact your authorized dealer or do the following procedure applies to skin, eyes and mucous membranes. Remove the spout from the DEF container. When opening the cap on the container until it is tight.
32
2012 Diesel (67l...
Diesel Supplement 3rd Printing - Page 34
..., the fluid level in the container, retain it for later use the DEF spout with water and a damp cloth.
34
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) When the DEF tank is empty, discard the empty container, or recycle if possible. Overfilling the DEF tank can cause damage to the vertical position slightly below the...
Diesel Supplement 3rd Printing - Page 35
Note: Some filling station nozzles may cause spilling and overfill the tank which allows the DEF system to fill the tank as required by the California Air Resources Board (CARB) and /or U.S. Filling the DEF tank in cold climates DEF will appear in the message center. 35
2012 Diesel (67l) Supplement, 3rd Printing USA (fus) To prevent overfilling...
Diesel Supplement 3rd Printing - Page 36
...DEF guidelines and information • Use only DEF that has spilled with water or any DEF that carries the trademark: American Petroleum Institute (API) certified DEF or ISO 22241. • Do not put DEF in the diesel fuel tank. • Do not overfill the DEF tank... • Do not store DEF bottle in a well ventilated area.
36
2012 Diesel (67l) Supplement, 3rd Printing USA ...
Diesel Supplement 3rd Printing - Page 93
... capacities ...68 Coolant additive ...68 Coolant change ...47, 52, 68 Cooler ...5 D Diesel exhaust fluid (DEF) ...17, 26 Diesel Particulate Filter (DPF) ...57-58, 62 Drivebelt ...70 E Emergencies, roadside jump..., Engine Cooling ...8 Filter fuel ...41 Fuel ...14, 21 cap ...25 capacity ...68 dual tank selector switch ...14 filling your vehicle with fuel ...25, 65 filter, specifications ...41, 67 ...
