Home » Ford » Troubleshooting » 2004 Ford Ranger

2004 Ford Ranger Support Question

Find answers below for this question about 2004 Ford Ranger.
Need a 2004 Ford Ranger manual? We have 9 online manuals for this item!

Ford Overview Questions Manuals Reviews Videos Research

Question posted by flynjim on October 27th, 2014

The Windshield Wipers & Washer Comes On When I Turn The Headlights On...

I Was Told That The Smart Junction Box Was The Problem... what Are Your Thoughts...? thanks............ Jim

I Know the Answer!

I have the same question
Request More Information

Current Answers

Answer #1: Posted by BusterDoogen on October 27th, 2014 8:56 AM

This answer was accepted by the poster of the original question.

BusterDoogen

Member since:
October 30th, 2011

Points: 28,565,407

1,100
points

Since the high beam & wiper/washer are all in the signal stalk & would check it for a short circuit. Just an idea.

I hope this is helpful to you!

Please respond to my effort to provide you with the best possible solution by using the "Acceptable Solution" and/or the "Helpful" buttons when the answer has proven to be helpful. Please feel free to submit further info for your question, if a solution was not provided. I appreciate the opportunity to serve you!

Related Manual Pages

Scheduled Maintenance Guide 5th Printing - Page 7

... necessary). OWNER CHECKS AND SERVICES General Owner's Information It is tight (see Owner's Guide). Check Every Month for operation. engine oil fluid level. windshield washer solvent fluid level. washer spray, wiper operation, and clean all interior and exterior lights. and lubricate all hinges, latches, door check straps (see Owner's Guide) Scheduled Maintenance 7 General Owner...

Scheduled Maintenance Guide 5th Printing - Page 13

...great. This can help identify any potential issue before there are any problems. Ford Motor Company suggests the following multi-point inspection to be performed..., exterior lamps, turn signals and hazard warning lights. ❑ Check radiator, coolers, heater and air conditioning hoses. ❑ Inspect windshield washer spray and wiper operation. ❑ Check windshield for crack, chips...

Warranty Guide 5th Printing - Page 12

... You, as the owner, are responsible for example, but are on windshield stress cracks will be provided for the first 12 months in service, ...-enhancing powertrain components Damage Caused by use and/or exposure to the elements. You, as follows: • wiper blade replacements are responsible for Љoff-road use onlyЉ installed after the vehicle leaves the control of...

Audio Guide 1st Printing - Page 1

... M T R ET R Audiophile System CAUTIONS WARNINGS TREMOR Pioneer Audiophile System EM OR T R ET R M O R. Turn off , it may result in a custom enclosure behind the front seats. The 10-inch subwoofer speaker is capable of peak...) dissipates heat during operation, keep your vehicle. This enclosure should not come in each corner. TREMOR Pioneer *F4L5J19G218AA* 4L5J-19G218-AA JUNE 2003 ...

Owner Guide 3rd Printing - Page 1

.../MP3 16 16 17 20 24 Climate Controls Heater only Manual heating and air conditioning 33 33 34 Lights Headlamps Turn signal control Bulb replacement 36 36 39 40 Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control 45 45 46 47 47 48 Locks and Security Keys Locks...

Owner Guide 3rd Printing - Page 10

If any light remains on after the engine is first turned to the ON position to check the bulb. Solid illumination after starting the ...Check fuel cap: Illuminates when the fuel cap may cause the Check Engine warning light to come on may not be properly installed. A warning light may illuminate when a problem exists with this light on . 10 2004 Ranger (ran) Owners Guide (post-2002-fmt)...

Owner Guide 3rd Printing - Page 17

To tune a preset station, press the desired memory preset. If pressed for less than .5 seconds, the system will come back to a "nominal" listening level when the ignition is turned back on. If the volume is turned off, the volume will seek to 6. AM/FM STEREO SINGLE CD SYSTEM (IF EQUIPPED) 17 2004 Ranger (ran...

Owner Guide 3rd Printing - Page 19

... 11. If the volume is set above a certain level and the ignition is turned off, the volume will repeat continuously until sound returns. The selection will come back on at a "nominal" listening level when the ignition switch is turned back on the current CD in random order. 7. In CD mode, press to advance...

Owner Guide 3rd Printing - Page 23

...) Owners Guide (post-2002-fmt) USA English (fus) ON/OFF/Volume: Press to increase/decrease volume. Turn to turn ON/OFF. In CD and MP3 flat file mode, you may set SCAN on at a "nominal" listening...19. In tape mode, you may set the scan on or off , the volume will come back on or off . If a CD is turned back on or off . In MP3 directory mode, you may set a station: Select ...

Owner Guide 3rd Printing - Page 26

... AM/FM; Compression (Audiophile audios only): In CD/MP3 modes, press to manually reverse in a CD track. 13. The selection will come back on at a "nominal" listening level when the ignition switch is turned back on the current CD/MP3 in the current directory. FF (Fast forward): Press to increase/decrease volume...

Owner Guide 3rd Printing - Page 29

... a station: Select frequency band AM/FM; The selection will come back on at a "nominal" listening level when the ignition is turned back on. 10. ON/OFF/VOL (Volume): Press to Track... in a CD track. 13. Memory presets: To set above a certain level and the ignition is turned off, the volume will repeat continuously until sound returns. FADE: Press rear speakers. In MP3 directory mode...

Owner Guide 3rd Printing - Page 45

... position); Turn the blade at an angle from the vehicle. Attach the new wiper to the wiper arm and press it from desired interval to increase the speed of the wipers. Pull the wiper arm away from the wiper arm. Replace wiper blades every 6 months for up to remove it into place until a click is heard. 3. Windshield washer: Push...

Owner Guide 3rd Printing - Page 138

... 30A 10A 5A 10A Passenger Compartment Fuse Panel Description Instrument panel dimmer switch Trailer tow park lamps Right low beam headlamp Left low beam headlamp Windshield wipers/washer Radio (RUN/ACCY) Headlamp illumination indicator Restraints Control Module (RCM), PADI (Passenger Air bag Deactivation Indicator) Cluster air bag indicator Cluster (RUN/START), 4x4 module...

Owner Guide 3rd Printing - Page 139

... Description Smart Junction Box (SJB) (Logic power) Center console subwoofer amplifier Horn, Interior lamps High beam headlamp, High beam indicator (cluster) One-touch down relay Power windows Turn signals/Hazards... interlock, Speed control module, Back-up lamps, Overdrive cancel switch, Electronic flasher (turn/hazard) Starter relay Spare Headlamps (low and high beam) Radio Accessory relay Brake ...

Owner Guide 3rd Printing - Page 146

... Location 41 Fuse Amp Rating 15A* Power Distribution Box Description Heated Exhaust Gas Oxygen (HEGO) sensors, EVAP canister vent valve, Exhaust Gas Recirculation (EGR) stepper motor, Transmission Trailer tow (left turn) Not used Not used Wiper HI/LO relay Wiper Park/Run relay A/C clutch solenoid Washer pump relay PCM relay Fuel pump relay Fog lamp...

Owner Guide 3rd Printing - Page 173

... wipe properly, substances on the vehicle's glass or the wiper blades may be cleaned with a dry cloth. 173 2004...wipers do not function properly. WINDOWS AND WIPER BLADES The windshield, rear and side windows and the wiper blades should be the cause. Be sure to replace wiper... these items, please follow these tips: • The windshield, rear windows and side windows may be cleaned regularly....

Owner Guide 3rd Printing - Page 181

... only if they provide cold weather protection without damaging the vehicle's paint finish, wiper blades or washer system. 181 2004 Ranger (ran) Owners Guide (post-2002-fmt) USA English (fus) Only use of methanol, a common windshield washer antifreeze additive. Maintenance and Specifications WINDSHIELD WASHER FLUID • 2.3L engine • 3.0L and 4.0L engines Add fluid to...

Owner Guide 3rd Printing - Page 182

...Turn the engine off and wait a few minutes for the oil to the scheduled maintenance guide for the appropriate intervals for checking the engine oil. 1. Set the parking brake and ensure the gearshift is on level ground. 2. Note: Do not put washer... Failure to use washer fluid with antifreeze protection in cold weather could result in impaired windshield vision and increase the risk of...

Owner Guide 3rd Printing - Page 248

...) ...238 Vehicle loading ...118 camper bodies ...133 Ventilating your vehicle ...100 W Warning lights (see Lights) ...10 Washer fluid ...181 Water, Driving through ...118 Windows power ...47 Windshield washer fluid and wipers ...45 checking and adding fluid ...181 replacing wiper blades ...45 Wrecker towing ...160 248 2004 Ranger (ran) Owners Guide (post-2002-fmt) USA English...

Quick Reference Guide 2nd Printing - Page 2

... to activate all interior lamps and instrument panel lights. 8 8 CLIMATE CONTROL SYSTEM Please see reverse side for the best fuel economy. SIGNAL AND WIPER/WASHER CONTROL 13 TURN Rotate the windshield wiper control to dim. Push and hold for optional electrical accessories. The foglamps will illuminate. Rotate up to tilt the mirror. Rotating the dimmer...