1997 Ford F150 Support Question
1997 Ford F150 Support Question
Find answers below for this question about 1997 Ford F150.Need a 1997 Ford F150 manual? We have 5 online manuals for this item!
Question posted by you2too on September 22nd, 2014
Ran Out Of Gas. Not Getting Fuel To The Fuel Rail. 1997 F150 6cyl Automatic.
I checked fuse, good. I tested relay , good click. tested fuel shut off, continuity. Pulled fuel fillter, pour dark fuel out of inlet and outlet ends. (1) I am pulling tank and clean, going to test fuel pump and fuel level valve. (2) Do I need to change the valve that goes to the fuel rail? (3) when I pull the injectors, will I be able to clean them? if so what type of chemical should I use? or do they need replacing? (4) I am going to blow the lines out, are there any valves along any lines that I could damage? (5) What other steps should I take ? Thanks Charlie guinn [email protected] 817-296-3504
Current Answers
Related Manual Pages
Customer Assistance Guide 1st Printing - Page 2
... contact your Ford or Lincoln-Mercury dealer. Even non-warranty related tows, like accidents or getting stuck in the mud or snow, are not eligible for quick reference. To obtain information about...GETTING ROADSIDE ASSISTANCE To fully assist you should you have a flat tire • jump-start the battery if it becomes discharged • unlock the vehicle if you are locked out • bring fuel ...
Customer Assistance Guide 1st Printing - Page 7
..., where allowed by a simple majority vote. The Board makes every effort to a foreign country, contact the appropriate foreign embassy or consulate. These officials can only get fuel with an anti-knock index lower than 30 days to the Board at a fair and impartial decision, decided by law. To Request a DSB Brochure/Application...
Warranty Guide 1st Printing - Page 7
...and exhaust manifolds, flywheel, timing gear, harmonic balancer, valve covers, oil pan and pump, water pump, fuel pump and fuel system (excluding fuel lines and fuel tank), high pressure lines, gaskets and seals, glow plugs,...actual mileage cannot be inoperative for emissions warranties (page 11) . After the end of time with no deductible. NOTE: Some components may also be covered by alteration, ...
Warranty Guide 1st Printing - Page 8
... fluids • oil/air filters • brake linings/pads • tire rotation • cleaning/polishing • wiper blades • clutch linings 8 Damage Caused by failure to maintain the vehicle, ...improperly maintaining the vehicle, or using the wrong fuel, oil, lubricants or fluids. See the Owner Guide for correct fluid types and levels, and consult the Service Guide for these items. ...
Warranty Guide 1st Printing - Page 13
... can include being denied the right to use your vehicle if: • the vehicle is testes at high altitude, but is certified to Catalyst) • Electronic Engine Control Sensors and Switches • Exhaust Gas Recirculation (EGR) Valve, Spacer, Plate and Associated Parts • Exhaust Heat Control Valve • Exhaust Manifold 13 WHAT IS COVERED?
Warranty Guide 1st Printing - Page 14
...; Pulsed Secondary Air Injection Valve/Secondary Air Injection Pump and Associated Parts • Spark...Valve • Volume Air Flow Sensor (1) Flex Fuel Vehicle only. • Fuel Filler Cap and Neck Restrictor • Fuel Injection System • Fuel Injector Supply Manifold • Fuel Sensor (1) • Fuel Tank (Gasoline Only) • Fuel Tank Pressure Control Valve (1) • Fuel...
Warranty Guide 1st Printing - Page 20
... • Exhaust Gas Recirculation (EGR) Valve, Spacer, Plate and Associated Parts • Exhaust Heat Control Valve • Exhaust Manifold • Fuel Filler Cap and Neck Restrictor • Fuel Injection System (1) • Fuel Injector Supply Manifold • Fuel Sensor (2) • Fuel Tank (Gasoline Only) • Fuel Tank Pressure Control Valve (2) • Fuel Vapor Storage Canister...
Warranty Guide 1st Printing - Page 21
... reveal a defect, the Defects Warranty does not apply.
Coverage for 1997-Model Vehicles Under Long-Term Defects Warranty (Coverage for five years or 100,000 years. (2) Flex Fuel Vehicle only. Your Ford dealer maintains a complete list of Parts. Left Exhaust Manifold - Right Fuel Tank Intake Manifold Throttle Body Assembly (MFI)
1 Mountaineer only 2 Escort/Tracer...
Owner Guide 1st Printing - Page 7
... 60 30 20
20 40 km/h
50 60 80
100
H
70
120
DOOR AJAR
000005
80
140
L 18 8
ABS
BRAKE
F E
CHECK ENGINE
!
10 0
90
180
MPH
0 0 1 0
100
FUEL RESET
LOW RANGE 4x4
LOW FUEL
F H E
DOOR AJAR
40 60 30 20
20 40 km/h
50 60 80
100
70
120
L H 18 C 8
000005
80
140...
Owner Guide 1st Printing - Page 10
... Momentarily illuminates when the ignition is turned on and the engine is engaged. If the light stays on the end of the gearshift lever, may flash steadily if a malfunction has been detected. For more information, refer to ... control indicator light (TCIL) The TCIL (OFF), located on or continues to flash, the ABS needs to Fuel pump shut-off switch in the Roadside emergencies chapter.
Owner Guide 1st Printing - Page 11
...50 60 80
100
H
70
120
DOOR AJAR
000005
80
140
L 18 8
ABS
BRAKE
F E
CHECK ENGINE
!
10 0
90
180
MPH
0 0 1 0
100
LOW FUEL
F H E L H 18 C 8
40 60 30 20
20 40 km/h
50 60 80
100...
70
120
000005
80
140
2 1
3
4 5
ABS
BRAKE
!
10 0
90
180
MPH
0 010
100
0 RPMx1000
CHECK ENGINE
6
Testing warning lights ...
Owner Guide 1st Printing - Page 14
Fuel gauge Indicates the fuel level. Instrumentation
Tachometer (if equipped) Indicates the engine speed in the Maintenance and care chapter. If it cool.
H C
F
E
15 Switch off the ignition and let it enters the red section, the engine is overheating. Refer to Checking and adding engine coolant or What you should know about fail safe cooling...
Owner Guide 1st Printing - Page 22
Controls and features
Fuel pump shut-off switch Refer to the Roadside emergencies chapter for information on operating the fuel pump shut-off switch.
23
Owner Guide 1st Printing - Page 134
... the engine cranks but does not start after a collision, the fuel pump shut-off switch may have been activated. Turn the ignition switch to the OFF position. 2. Pause for leaks in the fuel system.
135 Depress to warn traffic of vehicle breakdown, approaching danger, etc. Check fuel system for leaks. 3. Roadside emergencies
HAZARD LIGHTS CONTROL Use...
Owner Guide 1st Printing - Page 139
Roadside emergencies
Fuses Position 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 ... battery charge and stop/turn lamps 4WD transfer case shift motor and clutch Driver power seat Fuel pump Instrument panel fuse panel ignition switch feed Instrument panel fuse panel ignition switch feed I/P fuse panel battery feed I/P blower PCM power Power windows Not used Not used Trailer tow electronic ...
Owner Guide 1st Printing - Page 140
... Description Windshield wipers HI/LO speed Windshield wipers run/park relay Washer pump relay Fuel pump relay Horn relay PCM power relay
Primary battery fuses (megafuses) Primary battery fuses are located under the PRIMARY BATTERY FUSE cover next to starter relay. Ford recommends that megafuses only be serviced by a qualified service technician.
1
2
3
Location 1 2 3
Amperage Description...
Owner Guide 1st Printing - Page 154
...the battery and all fuel related parts. Turn off the engine and remove the key. 3. Working with long hair. • Do not work on • Automatic transmission
155 Set the... parking brake, depress the clutch and place the gearshift in P (Park). 2. Turn off the engine and remove the key. 3. Maintenance and care
could get caught in ...
Owner Guide 1st Printing - Page 160
...Set the parking brake and ensure the gearshift is on level ground. Open the hood. It is used that you fuel your engine application. To check the oil: 1. Checking engine oil Check the engine oil each time you use the appropriate ...are designed for your vehicle. Make sure the vehicle is latched in P (Park) (automatic transmission) or 1 (First) (manual transmission). 3.
Owner Guide 1st Printing - Page 188
... in a collision. If you hear a hissing sound, wait until it to fuel spray and fire. Automotive fuels can damage the fuel system or cause it stops before completely removing the cap. FUEL Important safety precautions Do not overfill the fuel tank. The pressure in the fuel tank can cause serious injury or death if misused or mishandled.
189...
Owner Guide 1st Printing - Page 191
... continue to protect the fuel system. Fill the tank completely and record the initial odometer reading.
192 Calculating fuel economy To accurately calculate your dealer or a qualified service technician. Cleaner air Ford approves the use of gasolines to prevent any aftermarket products to your fuel tank if you are available. We recommend the use a high-quality fuel...
Similar Questions
Where The Remote Anti Theft System Relay In A 1997 F150
(Posted by ginrud3 9 years ago)
Door Switch On A 1997 F150 4.2l Xlt Won't Unlock Doors
(Posted by hhhYHWH7 10 years ago)
1997 Ford F150 How To Check Transfer Case Fluid Level
(Posted by MrHibene 10 years ago)
